Documente Academic
Documente Profesional
Documente Cultură
ASSIGNMENT 4
NAME MATRIC NO
SECTION: 01 P
LECTURER: DR. MUHAMMED NAFIS BIN OSMAN ZAHID
Start
Material Selection
And Dimension
Cutting Process
Assemble Locator
And Clamping Device
Jigs Is Fixed On
Workpiece
Finishing
End
PROCESS PLANNING FOR PRODUCT
1. Profile countouring
We do profile countouring to shape the body of the product by using end mill tool.
2. Roughing
Roughing use after profile countering
3. Drilling
Cutting Depth 1 mm
1. Jigs Body
2. Clamping Plate
PROCESS PLAN:
First of all, we designed the product and decided the material for the product. Material
used is aluminium.
Next, every part of the product is measured.
The process was started with profile countering. The tool that is used was end mill tool
10mm to cut the edge as well as to make it easier to clamp.
After that, roughing process is used to make another shape on the center of the
product. Tool end mill with 10 mm diameter is used to cut the product.
After profile contouring and roughing has been done, the product is placed on the jigs
that has been designed and the product is clamped.
Screw and clamping plate are attach to the jigs body.
Drilling process is done on the both side. The diameter for both holes are 40mm.
For the top hole, the product is placed in a horizontal position and is attached it to
clamping plate and drilling process is ready to be done.
Figure 10: Assembled product