Documente Academic
Documente Profesional
Documente Cultură
Launch Date
February 2010
•Text may not appear to be in the logical order when flowing around figures.
•Text may continue on a following page without indication.
•Figures may not appear on the page containing the figure reference.
•EDOC hot link references can over write text.
708P89779
February 2010
© 2010 by Xerox Corporation. All rights reserved. Xerox® and the sphere of connectivity design are trademarks of Xerox Corporation in the US and/or other countries.
Other company trademarks are also acknowledged.
While every care has been taken in the preparation of this manual, no liability will be accepted by Xerox Europe arising out of any inaccuracies or omissions.
All service documentation is supplied to Xerox external customers for informational purposes only. Xerox service documentation is intended for use by certified, product trained service per-
sonnel only. Xerox does not warrant or represent that it will notify or provide to such customer any future change to this documentation. Customer performed service of equipment, or
modules, components or parts of such equipment may affect whether Xerox is responsible to fix machine defects under the warranty offered by Xerox with respect to such equipment. You
should consult the applicable warranty for its terms regarding customer or third-party provided service.
7 Wiring Data
Plug Jack Locations
PJ Locations.................................................................................................................... 7-3
Wiring Diagrams
Wiring Diagrams.............................................................................................................. 7-31
Figure 11 Scanner PWB (W/O TAG 150) Figure 12 Exposure lamp inverter
PJ76 (65-90ppm)
Inverter assembly PJ49
PJ152
Single board controller PWB
PJ93
module
Developer bias connection
Developer module
PJ800
PJ75
Figure 24 HVPS
PJ120
PJ122
Fuser drawer connector PJ100
PJ18
(harness)
Figure 27 ROS
Xerographic CRUM
PJ144
PJ530
PJ279
PJ636
PJ280
PJ36
PJ82
PJ299
Product Description
*Model No. or Product Name:
List damaged and affected part(s) of the machine by description and part number:
Customer Identification
*Customer Name: *Name of Customer Contact Person:
Fax:
* Required information is preceeded by asterisk, title shown in red, turquoise wash background
Details of Incident
*Description Of Incident: (Check all that apply)
Smoke
Describe quantity and duration of smoke:
Other, Describe:
MANDATORY DESCRIPTION (above): Provide a detailed description of all valid factors that may have
contributed to the incident. Hardware involved in the incident should be preserved and retained for further
investigation should investigation be deemed necessary by EH&S.
LIST INCIDENT DESCRIPTIONS AND SUPPORT DIAGRAMS/DATA INCLUDED OR ATTACHED:
*Did external emergency response provider(s) such as fire department, ambulance, etc. respond?
No Yes Identify: (i.e., source, names of individuals)
Apparent cause of incident (identify part that is suspect to be responsible for the incident)
* Required information is preceeded by asterisk, title shown in red, turquoise wash background
JOB TITLE:
DATE: