Documente Academic
Documente Profesional
Documente Cultură
MAGNA/CURE
®
UDC-HV
Photopolymer dual cure direct emulsion for the broadest range of applications.
MAGNA/CURE® UDC-HV
UDC-HV dual cure emulsions are designed for the
widestrange of imaging applications. UDC-HV
provides these additional benefits:
SAFETY AND HANDLING Coated, unexposed screens can be stored as long as one
Avoid contact with skin and eyes. month in a clean, cool, dry and completely dark area.
Refer to MSDS for further information.
Expiration date. Always check the expiration date on
SPECIFICATIONS sensitizer bottle to assure freshness.
UDC-HV
INSTRUCTIONS
DEGREASE RECLAIM
Using Chroma/Clean™ mesh degreaser, Apply Chroma/Strip™ screen
Work work up a lather on both sides of mesh. reclaimer to both sides of screen.
under Flood screen and frame thoroughly with Scrub area to be reclaimed with a
yellow water, then dry. stiff nylon brush to ensure entire
lights.
surface is wet and let it work a few
MIX moments until stencil begins to dis-
Mix emulsion and sensitizer according to instructions on solve. Remove stencil residue with
bottle. Let emulsion stand at least two hours before using. pressure washer, then rinse with
water, thoroughly flooding screen
COAT and frame.
Fill scoop coater with room temperature
emulsion. Slowly apply first coat to print EXPOSURE GUIDELINES
side. Then coat squeegee side with one Note: Exposure times are suggested only as a guide.
to three coats depending upon thickness Use the Chromaline Exposure Calculator to determine
required. If thicker stencil is required, optimal exposure times. Individual exposure times
additional coats may be applied to print may vary depending upon equipment used, bulb age,
side after initial drying of stencil. Be sure and other shop conditions.
to dry thoroughly between coats.
SUGGESTED MINIMUM
DRY Exposure Guidelines
Thoroughly dry screen in horizontal
position, print side down, using Mesh Time
a dark, clean drying cabinet. 158 mesh TPI
Temperature should not exceed 60 - 90 sec.
(62 cm)
110°F (43°C).
230 mesh TPI
45 - 60 sec.
EXPOSE (90 cm)
Place emulsion side of photopositive 305 meshTPI
30 - 45 sec.
in contact with print side of screen. (120 cm)