Documente Academic
Documente Profesional
Documente Cultură
Description of work
Turbocharger, lubricate servo-motor linkage
Note:
Note:
- Work procedure:
Work procedure:
Note:
If the trim under the driver seat has not yet been removed:
Note:
Description of work Page 6 / 105
Battery concepts
Warning!
Warning!
Note:
- Reinstall cover.
Description of work Page 11 / 105
Note:
- Reinstall cover.
Note:
Warning!
possible accidents.
Note:
Note:
Note:
Batteries, check
Note:
Warning!
Warning!
Inspection Service:
Warning!
Note:
Causes
Note:
Note:
- Check the tire size used on the vehicle with the sizes in
the table and correct tire pressure regardless of engine
type.
Pliers 3314
Note:
Wear limit: 2 mm
Note:
Wear limit: 2 mm
Note:
Hydraulic unit
Brake calipers
Warning!
Note:
Warning!
Note:
Warning!
adapter.
Note:
Note:
Sequence: Clutch slave cylinder, wheel brake cylinder, Quantity of brake fluid that must
brake caliper flow out:
Clutch slave cylinder bleeder valve 0.15 liter
Right rear 0.25 liter
Left rear 0.25 liter
Right front 0.25 liter
Left front 0.25 liter
- Re-install cover.
upward.
Note:
Warning!
Warning!
Note:
Note:
- Close the front left side window fully by lifting and holding
the button in the drivers door, then release button.
Note:
and checks for all possible control modules for this vehicle
type.
Note:
Caution!
Static malfunction
Sporadic malfunctions
Note:
Note:
Removing:
Note:
Installing:
- Re-install cover.
Base break-up
Note:
Note:
Removing:
Note:
Installing:
Note:
Refractometer T10007
Description of work Page 41 / 105
Note:
Refractometer T10007
Note:
Freeze protection to C
Actual value Specified value 6-cyl. engine 6-cyl. engine 1)
0 -25 4,0 6,0
-35 4,5 7,5
-5 -25 3,5 5,0
-35 4,0 6,5
-10 -25 2,5 4,0
-35 3,5 5,5
-15 -25 2,0 3,0
-35 3,0 4,5
-20 -25 1,0 2,0
-35 2,0 3,5
-25 -35 1,5 2,0
-30 -35 1,0 1,5
-35 -40 0,5 1,0
Mixture ratio:
Note:
Note:
VAS 6096 .
Note:
Note:
Note:
Removing
Note:
Note:
Installing
Note:
Removing
- Open clamps - 1 - .
Note:
Description of work Page 53 / 105
Installing
Note:
- Connect connector - 3 - .
Description of work Page 54 / 105
Note:
Caution!
Description of work Page 56 / 105
or
Note:
- Screw in the new oil drain plug hand-tight and then fasten
to the specified torque.
Warning!
Removing
Note:
Installing
Removing
Note:
Installing
Note:
Installing
General notes
Note:
- Pull out oil dipstick and wipe with clean rag. Replace
dipstick and push down to stop.
Caution!
Removing:
Description of work Page 63 / 105
Installing:
Caution!
Note:
Note:
Description of work Page 64 / 105
- Remove bolts - A - .
- Remove screws - B - .
Fuel system
Oil circuit
Air conditioning
Intake system
Caution!
Note:
Caution!
Note:
- Sunroof: Function
Note:
Note:
depth
Caution!
Note:
Caution!
Note:
Description of work Page 72 / 105
Test requirements:
Note:
or
Headlamps:
Note:
Fog lights:
Left headlamp
Description of work Page 76 / 105
connecting .
Note:
Note:
Note:
- Perform adjustment:
1 - Height adjustment
Note:
Rear window:
Refractometer T10007
Note:
Mixture ratio:
Note:
Note:
can be made.
or
- a - -100 mm
- b - - 75 mm
- c - - 230 mm
- d - - 50 mm
Note:
adjusted.
Every service
(adapted)!
- Select in succession:
Brand
Model
Model year
Engine Code
- Select in succession:
End Adaptation
Indicated on display:
Indicated on display:
Note:
- Select in succession:
Brand
Model
Model year
Engine Code
- Select in succession:
Description of work Page 91 / 105
End Adaptation
Indicated on display:
Indicated on display:
Description of work Page 92 / 105
- Check mountings.
Note:
Note:
- Set the time using the thumb wheel as well as the 12/24
hour clock mode settings.
Note:
Note:
Note:
Puller T10095 A
Puller T40039
Removing:
Description of work Page 99 / 105
Note:
Installing:
Description of work Page 101 / 105
Note:
Removing:
Note:
Installing:
Note:
Automatic headlamps