Documente Academic
Documente Profesional
Documente Cultură
VISRETAIN = 1
LIMITS = OFF
PLINEGEN = 1
UCSFOLLOW = 0
UNITS
DECIMAL MODE (METRIC) ARCHITECTURAL (IMPERIAL)
PRECISION – METRIC = 3 – ARCHITECTURAL = 1/8”
ANGLE DIRECTION = DEFAULT – LDT CONTROLLED
ANGLE DIRECTION OF MEASUREMENT = DEFAULT – LDT CONTROLLED
NCS Templates
MEASUREMENT – METRIC = 1 – IMPERIAL = 0
UCSICON = 1
UCS to WORLD
INSBASE = 0,0,0
GRIDMODE = 0
ISAVEPERCENT = 0
LIMCHECK = 0
CECOLOR to BYLAYER
CELTYPE to BYLAYER
CELWEIGHT to BYLAYER (-1)
PDMODE = 34
PDSIZE = 0.5
QTEXTMODE = 0
SNAPEMODE = 0
VISRETAIN = 1
LIMITS = OFF
PLINEGEN = 1
UCSFOLLOW = 0
UNITS
DECIMAL MODE (METRIC) ARCHITECTURAL (IMPERIAL)
PRECISION – METRIC = 3 – ARCHITECTURAL = 1/8”
ANGLE DIRECTION = DEFAULT – LDT CONTROLLED
Page Ð 9
ANGLE DIRECTION OF MEASUREMENT = DEFAULT – LDT CONTROLLED
The Drawing Standard files (dws) are used in AutoCAD to verify the layers existing in the
drawing adhere to the desired standards. These files are:
Sample Company Layers.dws
Sample NCS Layers.dws
The Drawing Layer States files (las) are used by AutoCAD to set the characteristics oflayers
that exist in the drawing (ON/OFF, FREEZE/THAW, colors, linetypes, etc.). After using the
dwt file mentioned above when creating a new drawing, you can restore the default layer
state to ensure the layers have the proper characteristics. There are two layer state files
provided:
Sample Company Layers.las
Sample NCS Layers.las
Refer to Sample Company Layers.xls for a detailed list of layer names and discipline names.
Page Ð 10