Documente Academic
Documente Profesional
Documente Cultură
E
Copyright
Disclaimer
The contents of this document are subject to revision without notice due to
continued progress in methodology, design and manufacturing.
Ericsson shall have no liability for any error or damages of any kind resulting
from the use of this document.
Contents
1.1 Introduction
This adaptation describes the Graphical User Interfaces (GUIs) of MINI-LINK
Traffic Node Adaptation and of the related NEs for the first increment of "Fault
Management for Traffic Node". This adaptation describes also how to configure
and visualize the MINI-LINK Traffic Node Adaptation and NE parameters.
1.2 Operation
Operation of MINI-LINK Traffic Node Adaptation is handled according to general
descriptions in OPERATOR GUIDE.
1.3 Configuration
General configuration of MINI-LINK Manager when using the MINI-LINK Traffic
Node Adaptation is performed according to descriptions in CONFIGURATION
GUIDE, Configure Adaptations subsection and in the MINI-LINK TN Adaptation
Configuration of the Server Installation Guide. All MINI-LINK Traffic Node
associated configuration windows are described in the chapters below.
In the NE property pages, only three tabs exist: "Basic", "Address" and "LM"
tab. For a generic description see the Configuration Guide, Configure NEs
subsection.
This tab is the standard basic tab for a NE in MINI-LINK Manager 6.1
customized for the specific case.
The NE type field, in fact, shows the AMM type. It could be one of the following
values:
A MINI-LINK Traffic Node NE has its own IP address and it can be inserted in a
TCP/IP network. It has both an embedded Web Server (HTTP), to provide a
web management interface (LCT), and an SNMPv3 Agent, to provide an SNMP
management interface to an External Management System.
Figure 2 LM Tab
Table 2 LM Tab
Name Description Access
LM Name Choose one of the registered LMs. Read Only
IP Address Here you can only read the IP address Read Only
or the host name of the NE.
Table 2 LM Tab
HTTP Port Set as default to "80" that defines the Read / Modify
HTTP port for connection with the ML
TN LCT. Possible values are between
1 up to 65535.
LCT View LCT User Name with view access level Read Only
Operator User (min 1, max 32 characters).
Name
LCT View LCT User password with view access Read Only
Operator level (min 8, max 19 characters).
Password
LCT Control LCT User Name with control access Read / Modify
Operator User level (min 1, max 32 characters).
Name
LCT Control LCT User password with control access Read / Modify
Operator level (min 8, max 19 characters).
Password
OK Exit the window with saved settings. Activate
Cancel Exit the window without saving. Activate
Apply Saves the settings without closing the Activate
window.