Documente Academic
Documente Profesional
Documente Cultură
Answer: 40C
3. When connected Earthing and Earth continuity conductor to one earth electrode,
it shall be lable at or immediately adjacent to the point at which the connection is
made.
Answer: earthing conductor, do not disconnect
4. Buried plate electrode – does it have more advantages over strip electrode?
Answer: no
8. The room in which a private generating plaint installed should be of such that the
Plant can be easily and adequately maintain.
Answer:
Well ventilated
Provide with exhaust pipe or duck to discharge exhaust fumes from the
prime mover to the outside.
12.What are the two (2) types of voltage use on lamp holder?
Answer: Extra low voltage and low voltage
13.If there is a heating system with two (2) heater.
How would you achieve
Answer:
Low series them
Medium One switch to neutral
High parallel both
39. What are the main things of can earn when choosing generator?
Answer: supply voltage and total load.
41. What type of start would you use for a 200 hp wound roto motor
Answer: you would use a three-phase roto resistance starter.
42. What type of start would you use for a 500 hp three-phase motor?
Answer: you would use autotransformer or soft strant method.
43. How would you get 190 volt from a 415-v supply?
Answer: it’s not possible.
45. How would you get 415 volts supply to give 22ov/120v?
Answer: Autotransformer.
46. How would you reverse the rotation of a single-phase motor?
Answer: you can exchange rotation by changing the current flow and the
starting winding, also forward reverse selector switch.
47: what type of wimmy system would you use on a workshop garage/
Answer: pvc- swa or xlpe
53. Where in the meter socket in an edusam delta supply do you find the 190-volt
leg?
Answer: facing meter socket it must be to the extreme right.
55. What are the (3) criteria in regards to the installation of meter socket?
Answer: height 5,6 to 6,6” (measure from center). 100 feet from service provider
and 5 feet from boundary.
56. If you have 415 volts supply and you need to light up the circuit with 220 volts.
What kind of switch and breaker is used to control the circuit?
Answer: single pole switch, single pole circuit breaker.
Because it will be connected one phase too neutral.
65.In terms of what would you ensure that you have in place
for decking inspection?
Answer: pipes are properly secured to the steel or decking
And the octagonal boxes are properly nail to the ply and stuffed
With cement bag
66.What is arching?
Answer: potentian difference between two contacts.