Documente Academic
Documente Profesional
Documente Cultură
ELECTRICAL SPECIFICATIONS
Voltage Capacity A Amp-Hours (Ah) Energy (kWh)
10-Hr 20-Hr 48-Hr 72-Hr 100-Hr 100-Hr
6V
346 377 401 410 415 2.50
CHARGING INSTRUCTIONS
Charger Voltage Settings (at 77°F/25°C)
0.005 volt per cell for every 1°C below 25°C 0.005 volt per cell for every 1°C above 25°C 100 1.277 2.122 6.37
0.0028 volt per cell for every 1°F below 77°F 0.0028 volt per cell for every 1°F above 77°F
90 1.258 2.103 6.31
40
100
Temperature (C)
Temperature (F)
30
80
20
DOD VS CYCLE LIFE IN A STATIONARY APPLICATION
60
5500
10
40
0
5000
20
-10
0 4500
-20
Number of Cycles
-20 -30
4000
-40 -40
2.10
2000
90
42°F (6°C)
80 2.08
1500
Open Circuit Voltage Per Cell
60 2.04
500
50 2.02
75°F (24°C)
40 1.99 0
20% 30% 40% 50% 60% 70% 80%
30 1.97
Depth-of-Discharge
20 1.94
85°F (29°C)
10 1.92
0 2 4 6 8 10 12 14 16 18 20
*PERIODIC CHARGE
FREQUENCY
Provide a periodic freshening charge to maintain a SOC greater than the threshold of 70%.
DIMENSIONS INCHES (MM) - shown with LT
16.70
(424)
17.55 (446)
HEIGHT
15.83
(402)
Polyon™
by Trojan Battery
D
TERMINAL CONFIGURATIONS
5 LT L-Terminal
Chemical reactions internal to the battery are driven by voltage and temperature. The higher Deep-cycle batteries used in off-grid and unstable grid applications are heavily cycled at
the battery temperature, the faster chemical reactions will occur. While higher temperatures partial state of charge (PSOC). Operating at PSOC on a regular basis can quickly diminish the
can provide improved discharge performance the increased rate of chemical reactions will overall life of a battery, which results in frequent and costly battery replacements.
result in a corresponding loss of battery life. As a rule of thumb, for every 10°C increase in To address the impact of PSOC on deep-cycle batteries in renewable energy (RE), inverter
temperature the reaction rate doubles. Thus, a month of operation at 35°C is equivalent in backup and telecom applications, Trojan Battery has now included Smart Carbon™ as a
battery life to two months at 25°C. Heat is an enemy of all lead acid batteries, FLA, AGM and standard feature in its Solar Industrial and Solar Premium flooded battery lines.
gel alike and even small increases in temperature will have a major influence on battery life.
A. T he amount of amp-hours (Ah) a battery can deliver when discharged at a constant rate at 86°F (30°C) and maintain a voltage above C. H
eight taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.
1.75 V/cell. Capacities are based on peak performance. D. T erminal images are representative only.
B. D
imensions may vary depending on type of handle or terminal. Batteries should be mounted with 0.5 inches (12.7 mm) spacing minimum. E. Weight may vary.
© 2017 Trojan Battery Company, LLC. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted from this publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this
publication at any time, without notice or obligation.