Documente Academic
Documente Profesional
Documente Cultură
80520928
Flight Operations
ATIS OAT vs ECAM (SD)OAT Creation date dossier:
02-OCT-2018
Customer Services
Messages :
Message :
Dear Andrey,
QUESTION:
Dear Team,
According to FCOM PRO-NOR-SOP-21 P 1/4 #On ground, hot weather conditions may cause overheating
to be detected around the bleed ducts in the wings, resulting in #AIR L (R) WING LEAK# warnings. Such
warnings may be avoided during transit by keeping the slats in Configuration 1 when the OAT is above 30
°C.#
Aurora Airlines wants to know which one OAT should pilots use: gotten from ATIS information or
presented on ECAM (SD)? As a rule, ECAM OAT is more than ATIS one.
And second question is when may slats/flaps be retracted after first procedure?
Best regards,
Tech pilot
Andrey Danilchenko
ANSWER:
Most of the time ATIS OAT is not the real time temperature since ATIS messages are updated in fixed
intervals or when there is a significant change in the information.
This is the reason why Airbus recommends using the ECAM OAT.
Message reference:
80520928/003 © AIRBUS S.A.S 2018. All rights reserved. Confidential and proprietary document. This document and all information contained herein
is the sole property of AIRBUS S.A.S. No intellectual property rights are granted by the delivery of this document or the disclosure of its
content. This document shall not be reproduced or disclosed to a third party without the express written consent of AIRBUS S.A.S. This Page 1/2
Export date: document and its content shall not be used for any purpose other than that for which it is supplied.
04-OCT-2018
Dossier Reference:
80520928
Flight Operations
ATIS OAT vs ECAM (SD)OAT Creation date dossier:
02-OCT-2018
Customer Services
As indicated in the PRO-ABN-AIR, the AIR L(R) WNG LEAK DET FAULT can be triggered up to 5 minutes
after second engine shut down.
Therefore Airbus recommends to retract slats/flaps past 5 minutes after second engine shut down.
However, as indicated in FCOM PRO-NOR-SOP-21, to avoid damage on the RTLU (Rudder Travel Limit
Unit) mechanical stop, the SLATS/FLAPS should be retracted before all ADIRS are set to OFF
simultaneously.
We hope this satisfactorily responds to your request and we remain available for any additional
information and assistance.
Best regards,
Benoit de Wavrechin
Phone: +33(0)5 61 93 44 94
Fax: +33(0)5 61 93 29 68
Mailto:benoit.de-wavrechin@airbus.com
Message reference:
80520928/003 © AIRBUS S.A.S 2018. All rights reserved. Confidential and proprietary document. This document and all information contained herein
is the sole property of AIRBUS S.A.S. No intellectual property rights are granted by the delivery of this document or the disclosure of its
content. This document shall not be reproduced or disclosed to a third party without the express written consent of AIRBUS S.A.S. This Page 2/2
Export date: document and its content shall not be used for any purpose other than that for which it is supplied.
04-OCT-2018