Documente Academic
Documente Profesional
Documente Cultură
PILE Size/Type: 24" SQ PCP Length (ft): Bent/Pier No: 21-3 PILE No:
Rated Energy Operating Rate
HAMMER Make/Model: D50 S/N: (ft-lbs): (BPM):
REF Elev: ← Input REF MIN TIP Elev: -50.00 PILE CUTOFF Elev: -4.50
PILE DATA:
PAY ITEM No: WORK ORDER No:
MANUFACTURED By: MFR's PILE No: DATE CAST:
PILE HEAD Rod Read: PILE HEAD Elev: PILE TIP Elev:
Top of SOIL PLUG Elev (for Open Ended Pipe Piles & H-piles): Natural Ground Elev:
Input 'Natural Ground EL' ONLY when natural ground surface is below embankment/fill material. Otherwise, leave this cell BLANK
NO PAY SET
DRIVING OF
Pile
LOAD TEST
Batter ?
PILE TYPE
DYNAMIC
PENETRATION
REDRIVE
TOTAL
SPLICE /
SPLICE
CHECK
ORIGINAL LENGTH
↓
CODE
EACH
HOLE
Structure No.: 150272 Depth Table Extended (ft): 100 Bent/Pier No.: 21-3 Pile No.: 0
Depth R R R
Input E 1 Blows Stroke Notes Depth E 34 Blows Stroke Notes Depth E 67 Blows Stroke Notes
Start LP↓ F 0.00 F 33.00 F 66.00
0.00 1 1.00 33.00 - 34.00 66.00 - 67.00
Standard Notes & Note No.'s 1‐28
Std. ↓ = Pile Ran, F1, F2, F3, F4 = (Fuel Settings 1‐4), ST = stop, CC = cushion change, HR = high rebound,
Notes: TP = Test Pile, DC = Driving Criteria, PR = Practical Refusal, SC = set check, DLT = Dyn. Load Test
Note 1:
Note 2:
Note 3:
Note 4:
Note 5:
Note 6:
Note 7:
Note 8:
Note 9:
Note 10:
Note 11:
Note 12:
Note 13:
Note 14:
Note 15:
Note 16:
Note 17:
Note 18:
Note 19:
Note 20:
Note 21:
Note 22:
Note 23:
Note 24:
Note 25:
Note 26:
Note 27:
Note 28: