Documente Academic
Documente Profesional
Documente Cultură
router
The following instructions are provided to help you set up a router so that you
can connect your TiVo DVR to a wireless network. This procedure, and the
content of any of the screens shown, may change if the router software is
revised. Refer to the manufacturer’s web site for the most current information.
Begin this process with your computer connected directly to your cable modem
or DSL modem. The installer CD will prompt you when it is time to add the router
hardware to the system.
The utility assumes that you do not have a router already set up on your
network and that the computer is directly connected to the cable modem.
6. If this is your setup, click Yes. The utility displays an overview of the
process for adding the router.
IMPORTANT: If you are replacing your current router with a Netgear
wireless router, you can either click No and follow the additional
instructions displayed by the setup utility, or you can disconnect your
current router, click Yes, and go to the next step in this procedure.
7. Click Next to proceed.
8. Follow the instructions to turn off the modem and disconnect the power
cord, and then click Next.
9. Follow the instructions to disconnect the Ethernet cable from the modem,
and then click Next.
10. Connect the supplied Ethernet/CAT5 Cable from the modem to the
router’s Internet/Uplink port (the port that is set apart from the other ports
on the router, as shown on the screen) and then click Next.
11. Connect an Ethernet cable from the Ethernet port on your computer to one
of the other ports on the router and then click Next.
12. Connect power to the Modem, wait a minute or two for the modem to
complete its startup sequence, and then connect power to the router.
When the Power, Wireless, Internet, and the LAN indicators on the router
are lit, click Next.
13. The utility restarts the network and shows a progress screen. When the
network restart is complete, the utility is ready to install the router
firmware. Click Next to proceed.
14. The router will now begin applying the firmware update that was
downloaded earlier. Click Next.