Documente Academic
Documente Profesional
Documente Cultură
Carefully unpack your digitizer and Place the GPS Antenna where it has a
1 check it is not damaged and all 2 Connect the Ethernet Cable 112293‐PL
to the digitizer and then to your Local 3 good view of the sky and connect the
BNC connector to the digitizer 4
Connect the Console cable 112294‐PL
to the digitizer and to the RS232 Port
accessories are present. Area Network (LAN). or an RS232 to USB Adapter connected
to your computer
Starting KMI Rock application...
I: Modules created: 49
I: DataIntegrator: Pre-Event buffer ready and
published. The digitizer’s LEDs will turn green
Kinemetrics Rock Platform
7 6 and then the middle LED will turn
Orange for several minutes as the
(www.kinemetrics.com)
You can now connect the remaining You can now connect your sensors to the unit. Shown here is a sensor
Now use a web browser to connect to the 10 interface cables to your digitizer. 11 connected to channel 1‐3. Using the Web Interface record a sensor test
9 IP address using the user name “rock” and
the password “kmi” ‐ now you can operate
Here a Modem Cable 111946‐PL and or review the live data using the Waveform Viewer. Please be aware
Dual Serial cable 111941‐PL have that you may need to configure the sensor parameters (type, voltage
your digitizer using the simple Web been connected. range and sensitivity) to match the actual sensor in order to get valid
Interface. sensor test results.
P/N 300690 Rev. A