Documente Academic
Documente Profesional
Documente Cultură
Guest LDOMs cannot talk to primary/control Domain, viceversa but same guest and control domain can talk
with anyone else on the network (Doc ID 1451652.1)
In this Document
Symptoms
Cause
Solution
APPLIES TO:
SYMPTOMS
Guest logical domains cannot talk to the primary/control domain and viceversa. But the same guest and control domain can talk with any
other domain on the network.
CAUSE
SOLUTION
The reason is one has not configured the control domain for inter-domain communications.
If one just want guest domains to communicate with the outside world then one should plumb up the switch vsw's.
For eg.
If one wants to communicate between the guest domains and the control domain, one will need to replace the primaryinterface for eg
(e1000g0) with vsw0.
#ifconfig -a
bash-3.00# ifconfig -a
lo0: flags=2001000849<UP,LOOPBACK,RUNNING,MULTICAST,IPv4,VIRTUAL> mtu 8232 index 1
inet 127.0.0.1 netmask ff000000
e1000g0: flags=1000843<UP,BROADCAST,RUNNING,MULTICAST,IPv4> mtu 1500 index 2
inet 10.1.2.xx netmask ffffff00 broadcast 10.1.2.255
ether 0:21:28:3f:a3:50
VSW
NAME MAC NET-DEV ID DEVICE LINKPROP DEFAULT-VLAN-ID PVID VID MTU MODE
INTER-VNET-LINK
primary-vsw0 00:14:4f:fb:44:fb e1000g0 0 switch@0 1 1 1500 on
#ifconfig -a
lo0: flags=2001000849<UP,LOOPBACK,RUNNING,MULTICAST,IPv4,VIRTUAL> mtu 8232 index 1
inet 127.0.0.1 netmask ff000000
1 of 2 12-03-2019, 00:51
Document Display https://support.oracle.com/epmos/faces/SearchDocDisplay?_adf.ctrl-stat...
If you have other guest domains bound to that switch, same command needs to be run for those domains.
6)#reboot
7)#ldm list-config (verify it booted off the newconfig, it should say "current")
where GD1 is the guest domains bound to that switch. If you have other guest domains bound to that switch, same command needs to be
run for those domains.
where GD1 is the guest domains bound to that switch. If you have other guest domains bound to that switch, same command needs to be
run for those domains.
2 of 2 12-03-2019, 00:51