Documente Academic
Documente Profesional
Documente Cultură
2
should be within the same range as your Art-Net or sACN
Ethernet Connections interface’s IP address. We recommend making the first
three octets match on both devices.
Redpark L4-NETP/L2-NET Ethernet connections through legacy accessories are
dedicated to transmitting DMX over Art-Net or sACN.
For direct ethernet connections to an Art-Net or sACN
Other network communications (Smart Lights, MIDI,
interface or node, Luminair also supports Redpark’s L4-NETP
OSC) still require a normal Wi-Fi connection on your
and L2-NET Lightning to Ethernet accessories for iOS
device.
devices. With these accessories, you connect the lightning
connector to your iOS device, and the ethernet connector to a NOTE: Your DMX interface will see DMX transmitted from
router, or directly to an Art-Net or sACN interface/light. the iOS built-in network interface as a different source
(and IP address) from data sent via the ethernet
After connecting the lightning to ethernet cable, it will take a
connection. If your interface is configured for HTP
moment for DMX transmissions to begin, as the device is
merging, you may need to reset your interface’s buffer or
powered up and obtains a connection. The cable’s options
cycle power when switching between connection
can be configured in Luminair’s Status view > Ethernet.
methods. If you prefer to only transmit DMX when
We recommend connecting the ethernet side of the cable ethernet is connected, turn the “Prevent Wi-Fi when
before connecting to the iOS device running Luminair. It’s disconnected” to ON.
also necessary to remove the lightning connector
whenever you want Luminair to resume transmitting DMX
data over Wi-Fi.
3
IP address, Subnet, Router
Legacy Accessories and DNS. The IP address
should be within the same
range as your Art-Net or
sACN interface’s IP address.
Redpark L4-NETP/L2-NET
We recommend making the
For direct ethernet connections to an Art-Net or sACN first three octets match on
interface or node, Luminair also supports Redpark’s L4-NETP both devices.
and L2-NET Lightning to Ethernet accessories for iOS
Ethernet connections
devices. With these accessories, you connect the lightning
through legacy accessories
connector to your iOS device, and the ethernet connector to
are dedicated to transmitting
a router, or directly to an Art-Net or sACN interface/light.
DMX over Art-Net or sACN.
After connecting the lightning to ethernet cable, it will take a Other network
moment for DMX transmissions to begin, as the device is communications (Smart
powered up and obtains a connection. The cable’s options Lights, MIDI, OSC) still require
can be configured in Luminair’s Status view > Ethernet. a normal Wi-Fi connection on your device.
We recommend connecting the ethernet side of the cable NOTE: Your DMX interface will see DMX transmitted from
before connecting to the iOS device running Luminair. It’s the iOS built-in network interface as a different source
also necessary to remove the lightning connector (and IP address) from data sent via the ethernet
whenever you want Luminair to resume transmitting DMX connection. If your interface is configured for HTP
data over Wi-Fi.
merging, you may need to reset your interface’s buffer or
By default the L2-NET/L4-NETP will be configured for cycle power when switching between connection
DHCP connections when detected. If you are connected methods. If you prefer to only transmit DMX when
through a network router, the IP address will be provided ethernet is connected, turn the “Prevent Wi-Fi when
and further configuration may not be necessary.When disconnected” to ON.
connecting directly to an Art-Net or sACN interface/light,
or you want to change the you will need to disable DHCP
in Luminair’s Ethernet settings, and assign an appropriate
4
©2017 Synthe FX LLC All Rights Reserved