Documente Academic
Documente Profesional
Documente Cultură
G3500
GENERATOR SET
ENGINE
PERFORMANCE
CATERPILLAR ENGINE DIVISION
Contents
2
Performance Book Users Guide
Fuel will be listed as "NAT GAS" for "pipeline" Engines operating with light loads will be operating
natural gas (methane) with methane numbers with a negative intake manifold pressure. This
between 67 and 100, "LANDFILL" for low energy negative manifold pressure tends to draw excessive
fuels with a methane number greater than 130, and oil down the valve guides and past the rings,
"PROPANE" for propane fuel with a 34 methane leading to increased oil consumption. The lighter
number. the load, and the longer the duration of the light
load, the more oil an engine should be expected to
Fuel System will be listed as "HPG IMPCO" (high
consume over a given period of time. Longer
pressure gas with an Impco carburetor, "LPG
periods of light loading could lead to carbon build-
IMPCO" (low pressure gas with an Impco
up on the valves, spark plugs, and behind the
carburetor), or "LPG DELTEC" (low pressure gas
piston rings. Deposits in the cylinders can also
with a Woodward/Deltec carburetor). There are
develop, and in extreme cases, cylinder liner
times when an air-fuel ratio control will be required
polishing can occur. Carbon build-up can result in
to meet the emissions levels shown on the
power losses, poor performance and accelerated
performance sheet at all load points. When this is
wear of components causing decreased times
the case, the words “with air-fuel ratio control” will
between maintenance intervals and increased
appear on the line directly below fuel system.
maintenance costs.
This information, along with the title block at the
Gas engine duty (load) cycles expected on an
top of the page, denotes the engine model and its
engine will vary from one application to another.
intended application. It must be consistent with the
Some applications expect cyclical daily load
engine to which the data is being applied.
changes. These load fluctuations are often tied to
Note: The data displayed in this book represents a production schedules or shift changes. Engines in
gas engine used in an industrial power application. these applications may operate at or near rated
The actual data may vary due to site specific rating load most of the day while operating at part load
and operating conditions. Contact your local during the night. Engines in these cyclical demand
Caterpillar dealer for site specific performance applications rarely will see full load for long periods
information. of time. Depending on the duration of the low load
on the engines, engines in these applications may
expect to operate for many years without deviating
Engine Specific Rating Information from the normal maintenance schedule and
The engine without fan rating at standard practices.
conditions is displayed here at 100%, 75% and 50% Other application duty cycles may be tied to
load levels. seasonal power demands or relatively short periods
of planned light loads. Light engine loads
Light Engine Loading experienced in these applications may be below
Gas engines are designed to operate continuously recommended levels for periods up to a year. For
at industry accepted high ratings and provide these applications, modifying some operating
optimum service life. Unfortunately, an engine parameters may enhance a lightly loaded engine
cannot be designed to operate efficiently at both performance. Ignition will be improved under light
continuous full load levels and at low loads. For loads by setting the spark plug gap slightly wider
example, engines operating at full load are than normal and by retarding the ignition timing.
designed to consume some oil in order to fully Retarding the ignition timing will also increase the
lubricate the engine and maintain good wear intake manifold pressure. Adjusting the carburetor
characteristics. This same engine operating at low power screw to a leaner setting can also increase
load factors and the resulting lower cylinder and intake manifold pressure.
negative intake manifold pressures will result in Changes to these parameters will enhance engine
more oil consumption than at high load factor. light load performance and may bring oil
Since most engines are designed to operate at consumption to acceptable levels, but it might also
maximum loads, it is not recommended to operate impact the engine’s full load performance
an engine continuously at low load levels. A capabilities. Excessive engine adjustment may not
general rule used for most gas engines is that allow satisfactory load acceptance or higher load
standard emission engines should be operated at operation without further engine adjustment.
75% of their rated load (torque) or above while low
emission engines should be operated at 50% load
(torque) or above.
3
Performance Book Users Guide
Natural gas engines can be operated at light loads Engine Emissions Data
for limited periods of time with no harmful effects.
Table 1 lists engine low load operating intervals The information in the Engine Emissions Data
that are known to be safe operating intervals. After section displays emission values for nitrous oxides
operation at the lower load levels, operate the (NOx as NO2) carbon monoxide (CO), total
engine for a minimum of two hours at a load level hydrocarbons (THC), non-methane hydrocarbons
that is more than 70 percent of the engine rated (NMHC), and exhaust oxygen. There is also a value
load. The increased engine load raises the cylinder for lambda, a calculated comparison of the air and
temperature and pressure, cleaning the deposits fuel ratios.
from the combustion chamber. Operating the There are large tolerances, (± 20%) in the total
engine at lighter loads for periods longer than hydrocarbons, non-methane hydrocarbons and
those listed may increase oil consumption and carbon monoxide data. This large tolerance is made
overall maintenance costs. Valve and guide seals necessary due to engine-to-engine variability and
designed to reduce oil flow down the valve guides, tolerances designed into the measurement
decrease oil consumption and restore engine instrumentation. Because of these large tolerances,
performance and maintenance intervals should be and the market need to guarantee engine emission
considered if a customer’s light load is expected to levels, the data listed for THC, NMHC, and CO on
regularly exceed the hour guidelines displayed in low emission engines has an additional 20% added
table below. to the nominal measured data. The resulting value
The following table is provided to define the represents a "not to exceed" emission levels.
recommended hours of continuous light load Though the actual emission levels of an engine are
operation that can be tolerated at a given load. probably closer to the measured (mean) levels, the
additional 20% provides the necessary safety factor
Recommended Gas Engine Low Load Operation Intervals to allow this value to be a "not to exceed" emission
G3300, G3400, G3500 G3600 level. The NOx data has tolerances built into the
Engine Load
(Torque) displayed value, and is a "not to exceed" value as
NA TA TA
well, but it is not listed at the high side of the
0-30% 1/2 hour 1/2 hour 1/2 hour* tolerance band. There is enough adjustment range
31-40% 2 hour 2 hour 2 hour* in the engine to set the NOx to a specific value
41-50% 8 hour 8 hour 2 hour* despite the engine-to-engine variability.
51-60% 24 hour Continuous Continuous
Data in the Caterpillar on-line technical marketing
61-100% Continuous Continuous Continuous information system (TMI) includes the same
tolerances listed here. The emission data from
either source will be used by the factory to calculate
* When a G3600 series engine operating at load levels below guaranteed emission levels for a given set of
51%, it is not operating in auto air/fuel ratio control. Submit a
light load profile to your local dealer for evaluation and specific site conditions.
system adjustment recommendations.
It is important to understand the trends depicted by
this data, particularly for low emission engines
Engine Data applied to areas where emissions are closely
This section provides specific fuel consumption watched. On engines without automatic air-fuel
information, turbocharger compressor outlet ratio control, the emission levels are not constant
pressure and temperature, intake manifold pressure over the entire load range. The specific emissions
and temperature, and timing information. This tend to become higher on a g/bkW-hr (g/bhp-hr)
section also provides information about the mass basis as the load decreases. If an engine will be
and volume flows of the intake air and exhaust consistently running at a point less than full load,
gases. Use this data when sizing intake air and the engine air-fuel ratio can be adjusted so that the
ventilation systems, fuel piping, and exhaust O2% in the exhaust is set for the required emission
equipment. levels at the less than rated load level.
The number represented by the term "lambda" is a
comparison of the air-fuel ratio as the engine is
actually set to the air-fuel ratio at a stoichiometric
setting. The actual equation for lambda is:
Lambda = air/fuel ratio (actual) / air/fuel ratio
(stoichiometric)
4
Performance Book Users Guide
If the lambda of an engine is about 1.1 or below, 5. “Heat Rejection to Lube Oil" is the amount of
the engine is considered to be a "rich burn", or heat rejected from the lube oil to the cooling
"stoichiometric" ("Stoich") engine. (An engine media in the oil cooler. Depending on the
operating at a lambda of 1 is an engine operating at cooling system design used, this heat will need
a theoretically perfect air-fuel ratio, where all of the to be dissipated in the jacket water cooling
fuel and oxygen in the air is consumed in the system, the aftercooler cooling system or will
combustion process). An engine with a 3-way need to be cooled as a separate circuit. If the
catalyst will typically operate with a lambda of heat rejected to lube oil is zero ("0") or not
between 1 and 1.1. Engines with a lambda of about listed, the lube oil heat is included in the heat
1.4 or higher are considered to be "lean burn", or rejected to jacket water value. If the heat
"low emission" engines. rejected to lube oil is a value greater than zero
(0), then this heat needs rejected. If the lube oil
Engine Heat Balance Data heat is to be rejected to the aftercooler circuit,
The term heat balance refers to the fact that the add this heat value to the "Heat Rejection to
heat input introduced as fuel into the engine equals Aftercooler" value.
the sum of the heat and work outputs. kW (Btu) 6. "Total Heat Rejection to Exhaust (to 25°C
values for energy input, work output, total exhaust, (77°F))" is the total heat available in the exhaust
exhaust to 350°F (177°C) for engines in English when it is cooled from the stack temperature
units or 120°C (250°F) for engines in metric units, down to standard conditions of 25°C (77°F).
aftercooler, radiator and jacket water/oil cooler are When expressed in Higher Heating Value
listed in low heat value due to the fact that the (HHV), it includes the latent heat of
latent heat of vaporization is lost to the exhaust in vaporization. At standard conditions, 465 kJ
the combustion process. (970 Btu) are released as each Kg (pound) of
Formula: steam is condensed to water. The figures
shown for total exhaust are in terms of low
Total heat input = work output + total exhaust heat heat value and, therefore, do not include the
+ radiation + jacket water rejection heat + oil cooler heat of vaporization.
rejection heat + aftercooler rejection heat.
7. "Heat Rejection to Exhaust (LHV to 350°F
1. "Total Heat Input Energy" is figured by (177°C) for engines in English units or 120°C
multiplying the BSFC (MJ/bkW-hr (Btu/bhp-hr)) (250°F) for engines in metric units)" is not a
times the kilowatt (horsepower) output to get separate component of the heat balance
kW/hr (Btu/hr). [To obtain kW/min (Btu/min), equation. It is a part of the "Total Heat
divide by 60]. Fuel volume consumed is Rejection to Exhaust (to 25°C (77°F))". It
obtained by dividing the total heat by the heat represents the easily recoverable exhaust heat
content of the fuel [36.2 mJ/N•m3 (920 Btu/cu ft) rejection value typically used in exhaust heat
for low heat value and 37 mJ/N•m3 recovery calculations. This value is the heat
(995 Btu/cu ft) for high heat value]. The energy available when cooling the exhaust gas from
input is listed in low heat value (LHV). the stack temperature down to the listed
temperature. This figure, plus the jacket water
2. "Work Output" is the total kilowatt
heat rejection, is commonly used in
(horsepower) developed expressed in terms of
determining steam or recoverable heat
the heat required to develop the kilowatt
production available from the jacket water and
(horsepower). It is expressed in kW (Btu/min)
exhaust without condensing the water vapor in
where 1 kW = 60 kJ/min (1 hp = 42.4 Btu/min).
the exhaust gas. Water will typically condense
3. "Heat Rejection to Jacket Water" is the total out of the exhaust gas at a temperature
amount of heat picked up by the engine cooling between 50-60°C (122-140°F), depending on
system. On a standard temperature cooling how lean the engine is set.
system, those which do not exceed 99°C
There is a reason for the difference in reported
(210°F) outlet, the oil cooler heat rejection is
temperatures between English and metric
typically included in this figure. To confirm
units. It is customary to report exhaust gas
this, look at the heat rejection to the lube oil. If
data at 350°F (177°C) levels in North America
the lube oil heat is included in the jacket water
and other English unit countries while it is
heat rejection, the value for the heat rejected to
more common in metric unit areas, particularly
lube oil will not be listed or will be a value of
Europe, to report the exhaust gas data at 120°C
zero ("0").
(250°F).
4. "Heat Rejection to Atmosphere (Radiation)" is
the amount of heat loss from the surface of the
engine into the engine room or surrounding
ambient.
5
Performance Book Users Guide
Ev = Exhaust Flow by Volume (CFM) For cooling systems using oil cooler and jacket
water in series (combined circuit), use a tolerance of
8. "Heat Rejection to Aftercooler" is given for ± 10% for the combined oil cooler and jacket water
standard conditions of 25°C (77°F) and 153 m heat rejection.
(500 ft) altitude. The actual heat rejection of the
engine aftercooler circuit is increased for Engine Noise Data
higher ambient temperatures and altitudes. To The Engine Noise Data section contains noise data
maintain a constant intake manifold for both mechanical and exhaust noise. The
temperature, as inlet temperature to the measurements were made using the A-weighted
aftercooler goes up, so does the heat that must (dB(A)) scale which adjusts the sound levels to
be removed. At higher altitudes, as the air account for the filtering properties of the human ear.
pressure decreases, the turbocharger must For a complete discussion on noise, consult the
work harder to compress the incoming air to Caterpillar Gas Engine Application and Installation
the required boost pressure. Be sure to use the Guide (LEKQ2368).
aftercooler heat rejection factor to adjust for
ambient and altitude conditions. Failure to Fuel Usage Guide
properly account for these factors could cause
the engine to detonate and shut the engine The Fuel Usage Guide shows the engine derate
down or, in extreme cases, can cause factor required for a given fuel and what engine
premature engine failure. timing the engine should be set at to use that fuel.
Note that engine deration occurs as the methane
number decreases. Methane number is a scale to
measure ignition and burning characteristics of
various fuels. Representative values are shown
below:
6
Performance Book Users Guide
Most dry pipeline natural gas has a methane Aftercooler Heat Rejection Factors
number of 67 or above. A gas analysis should be
made to determine the percentage of each The "Aftercooler Heat Rejection Factor" is stated for
constituent that exists in the fuel. The methane standard conditions of 25°C (77° F) and 153 m
number of the fuel should then be determined by (500 ft) altitude. To keep the engine from going into
using the Caterpillar "Methane Number Program" detonation, it is important to maintain a constant
(LEKQ6378-02). Once the methane number of the inlet air temperature at the air intake manifold.
fuel is known, consult the fuel usage guide to Therefore, as the ambient air temperature goes up
determine if an engine derate is required to beyond standard conditions, so must the heat
maintain the appropriate engine detonation margin. rejection for the aftercooler circuit. Also, as altitude
An asterisk (*) by the “Derate Factor/Engine Timing” increases, the turbocharger must work harder to
numbers will indicate that an air-fuel ratio control overcome the lower atmospheric pressure. Both of
will be required to maintain a safe detonation these conditions increase the amount of heat that
margin at the indicated load while achieving the must be removed from the inlet air by the
NOx emissions levels listed in the “Engine Emissions aftercooler. Use the aftercooler heat rejection factor
Data” section. to adjust for heat rejection increases due to
ambient and/or altitude conditions above engine
Generally speaking, use a high compression ratio design levels. Multiply this factor times the listed
engine for digester and pipeline quality gas, and a aftercooler heat rejection and its tolerance to
low compression ratio engine for propane and field identify the actual heat rejection required of the
gas. Consult your Caterpillar dealer or factory for aftercooler system to maintain proper engine
assistance in determining the proper engine to use operating conditions. Failure to properly account
for a fuel in question. for these factors could result in detonation and
cause the engine to shutdown or fail.
Altitude Deration Factors
If the oil cooler is to be located on the same circuit
This chart shows the engine deration that will be as the aftercooler, the value of the oil cooler heat
required for various ambient temperatures and rejection should not be included in this calculation.
altitudes the engine may be applied at. The ambient Since the oil cooler heat rejection needs to be
temperature is defined as the temperature of the dissipated, it should be added back with the
combustion air as it enters the engine at the air inlet. aftercooler heat rejection after the altitude and
The identified derate factor should be multiplied temperature factors have been calculated.
times the total available kilowatt (horsepower) to Arbitrarily increasing the value of the oil cooler heat
determine the maximum power available from the rejection by multiplying it times the Aftercooler
engine at the specific site conditions. Use this Heat Rejection Factor will simply cause you to
information to help determine actual engine power oversize this portion of the cooling system, adding
available for your site. cost to the system without improving the
aftercooler cooling system performance or the
Actual Engine Rating Calculation value to the overall system.
It is important to note that the Altitude/Temperature
Deration Factor and the Fuel Usage Guide deration Rating Conditions and Definitions
are not cumulative, i.e., they are not to be added
together. The actual power rating of the engine Ratings are based on ISO3046/1 standard reference
should be equal to the largest deration of the two. conditions of 25°C (77°F) and 100 kPa (29.61 in Hg).
The same is true for the Low Energy Fuel deration
and the Fuel Usage Guide deration. However, the Continuous is the engine power and speed
Altitude/Temperature deration and low Energy Fuel capability of the engine that can be used without
deration are cumulative; and they must be added interruption or load cycling.
together in the method shown below. To determine Ratings are based on dry natural gas having an LHV
the actual power available, take the lowest rating (low heat value) of 36.2 mJ/N•m3 (920 Btu/cu ft).
identified between the following two procedures. Variations in altitude, temperature, and gas
1) (Altitude/Temperature Deration) + (Low Energy compositions from standard conditions may
Fuel Deration) require a reduction in engine horsepower.
7
Gas Engine Performance Book Parameters DM5900-00
8
Gas Engine Performance Book Parameters DM5901-00
This data sheet contains the notes, conditions and Conditions and Definitions
definitions required to accurately apply a Caterpillar
gas engine performance book specification. Engine rating obtained and presented in
accordance with ISO 3046/1 (standard reference
Notes: conditions of 25°C (77°F) and 100 kPa (29.61 in Hg)).
No overload permitted at rating shown. Consult
(1) Fuel consumption tolerance according to the altitude derating curves for applications above
ISO 3046/1. Tolerance is +5% of full load data. maximum rated altitude and/or temperature.
(2) Heat Rejection to Jacket Water and Heat
Rejection to Exhaust tolerance is ±8% of full
load data.
(3) Heat Rejection to Aftercooler tolerance is ±8%
of full load data.
(4) Heat Rejection to Atmosphere (radiated) is
±25% of full load data.
(5) Heat Rejection to Lube Oil tolerance is ± 20%
of full rated load. If heat rejection to lube oil
=0, then the lube oil heat is included in the
jacket water heat rejection value.
(6) Heat Rejection to Jacket Water:
-If Heat Rejection Lube Oil = 0, then Jacket
Water Heat Rejection = Jacket Water heat + Oil
Cooler heat (This is also known as a
"combined" cooling circuit)
-If Heat Rejection Lube Oil > 0, then Jacket
Water Heat Rejection = Jacket Water heat only
(This is also known as a "two circuit" or a
"three circuit" cooling system)
(7) Heat Rejection to Aftercooler is recorded at
standard conditions. The value of this number
will increase for temperatures above standard
conditions. Consult the "Aftercooler Heat
Rejection Factors" table on page two of the
performance sheet for correction factors.
(8) For two circuit systems where the aftercooler
and oil cooler are on the same circuit, add the
"heat rejection to lube oil" to the "heat
rejection to aftercooler" number only after any
aftercooler heat rejection factors have been
calculated and added to the "heat rejection to
aftercooler" for the total heat load in this
circuit. The "heat rejection to lube oil" should
not be affected by the aftercooler heat
rejection factor.
(9) Emissions data shown are dry, not to exceed
values. Published part load data may require
engine adjustment. Consult the factory for
special emission setting information.
(10) Inlet Manifold Temperature measured at the
intake manifold plenum.
(11) Timing indicated is for use with the minimum
fuel methane number specified. Consult the
appropriate fuel usage guide for timing at
other methane numbers.
9
G3500Arrangements — ???????? Family Index
Generator Engine Arrangement
810 856 (1148) 1200 LE 8 99 (210) 32 (90) N/A HPG LA3058 DM5151 40-41 220-221
810 856 (1148) 1200 LE 11 99 (210) 32 (90) N/A HPG PA4873 DM5150 42-43 222-223
810 856 (1148) 1200 LE 11 99 (210) 32 (90) N/A LPG PA4873 DM5152 44-45 224-225
1035 1090 (1462) 1800 LE 11 99 (210) 54 (130) N/A LPG LA1231 DM5167 46-47 226-227
975 1010 (1354) 1500 1/2 TA LUFT 12 99 (210) 54 (130) N/A LPG LA2947 DM1228 58-59 238-239
975 1010 (1354) 1500 1/2 TA LUFT 12 127 (260) 54 (130) N/A LPG LA2947 DM1240 60-61 240-241
975 1010 (1354) 1500 TA LUFT 12 99 (210) 54 (130) N/A LPG LA2947 DM1231 62-63 242-243
975 1010 (1354) 1500 TA LUFT 12 127 (260) 54 (130) N/A LPG LA2947 DM1243 64-65 244-245
970 1011 (1355) 1500 LE 8 99 (210) 54 (130) N/A HPG PA4874 DM5156 66-67 246-247
970 1011 (1355) 1500 LE 11 99 (210) 54 (130) N/A HPG PA4875 DM5157 68-69 248-249
970 1011 (1355) 1500 LE 11 99 (210) 54 (130) N/A LPG PA4875 DM5158 70-71 250-251
1030 1070 (1435) 1500 1/2 TA LUFT 12 99 (210) 32 (90) N/A LPG LA2947 DM5166 72-73 252-253
1030 1070 (1435) 1500 1/2 TA LUFT 12 127 (260) 32 (90) N/A LPG LA2947 DM5161 74-75 254-255
1030 1070 (1435) 1500 TA LUFT 12 99 (210) 32 (90) N/A LPG LA2947 DM5162 76-77 256-257
1030 1070 (1435) 1500 TA LUFT 12 127 (260) 32 (90) N/A LPG LA2947 DM5163 78-79 258-259
1030 1070 (1435) 1500 1/2 TA LUFT 12 99 (210) 70 (158) 32 (90) LPG LA2947 DM1229 80-81 260-261
1030 1070 (1435) 1500 1/2 TA LUFT 12 127 (260) 70 (158) 32 (90) LPG LA2947 DM1241 82-83 262-263
1030 1070 (1435) 1500 TA LUFT 12 99 (210) 70 (158) 32 (90) LPG LA2947 DM1232 84-85 264-265
1030 1070 (1435) 1500 TA LUFT 12 127 (260) 70 (158) 32 (90) LPG LA2947 DM1244 86-87 266-267
1025 1070 (1435) 1500 LE 11 99 (210) 32 (90) N/A HPG PA4875 DM5159 88-89 268-269
1025 1070 (1435) 1500 LE 11 99 (210) 32 (90) N/A LPG PA4875 DM5165 90-91 270-271
10
G3500Arrangements — ???????? Family Index
Generator Engine Arrangement
600 642 (861) 1200 LE 8 99 (210) 32 (90) N/A HPG PA4937 DM5169 108-109 288-289
600 642 (861) 1200 LE 11 99 (210) 32 (90) N/A HPG PA4935 DM5173 110-111 290-291
600 642 (861) 1200 LE 11 99 (210) 32 (90) N/A LPG PA4935 DM5115 112-113 292-293
600 642(861) 1200 LE 8 127 (260) 32 (90) N/A HPG PA4937 DM5113 114-115 294-295
600 642(861) 1200 LE 11 127 (260) 32 (90) N/A HPG PA4935 DM5114 116-117 296-297
600 642(861) 1200 LE 11 127 (260) 32 (90) N/A LPG PA4935 DM5116 118-119 298-299
725 758 (1017) 1500 LE 11 99 (210) 54 (130) N/A HPG PA4933 DM5123 124-125 304-305
725 758 (1017) 1500 LE 11 127 (260) 54 (130) N/A HPG PA4933 DM5121 126-127 306-307
725 758 (1017) 1500 LE 11 99 (210) 54 (130) N/A LPG PA4933 DM5126 128-129 308-309
725 758 (1017) 1500 LE 11 127 (260) 54 (130) N/A LPG PA4933 DM5125 130-131 310-311
765 803 (1077) 1500 LE 8 99 (210) 32 (90) N/A HPG PA4932 DM5170 132-133 312-313
765 803 (1077) 1500 LE 8 127 (260) 32 (90) N/A HPG PA4932 DM5132 134-135 314-315
765 803 (1077) 1500 LE 11 99 (210) 32 (90) N/A HPG PA4933 DM5131 136-137 316-317
765 803 (1077) 1500 LE 11 127 (260) 32 (90) N/A HPG PA4933 DM5130 138-139 318-319
765 803 (1077) 1500 LE 11 99 (210) 32 (90) N/A LPG PA4933 DM5210 140-141 320-321
765 803 (1077) 1500 LE 11 127 (260) 32 (90) N/A LPG PA4933 DM5139 142-143 322-323
725 758 (1017) 1500 1/2 TA LUFT 12 99 (210) 54 (130) N/A LPG LA2942 DM1953 152-153 332-333
725 758 (1017) 1500 TA LUFT 12 99 (210) 54 (130) N/A LPG LA2942 DM1956 154-155 334-335
725 758 (1017) 1500 1/2 TA LUFT 12 127 (260) 54 (130) N/A LPG LA2942 DM1965 156-157 336-337
725 758 (1017) 1500 TA LUFT 12 127 (260) 54 (130) N/A LPG LA2942 DM1968 158-159 338-339
770 803 (1077) 1500 1/2 TA LUFT 12 99 (210) 32 (90) N/A LPG LA2942 DM1952 160-161 340-341
770 803 (1077) 1500 TA LUFT 12 99 (210) 32 (90) N/A LPG LA2942 DM1955 162-163 342-343
770 803 (1077) 1500 1/2 TA LUFT 12 127 (260) 32 (90) N/A LPG LA2942 DM1964 164-165 344-345
770 803 (1077) 1500 TA LUFT 12 127 (260) 32 (90) N/A LPG LA2942 DM1967 166-167 346-347
770 803 (1077) 1500 1/2 TA LUFT 12 99 (210) 70 (158) 32 (90) LPG LA2942 DM1954 168-169 348-349
770 803 (1077) 1500 TA LUFT 12 99 (210) 70 (158) 32 (90) LPG LA2942 DM1957 170-171 350-351
770 803 (1077) 1500 1/2 TA LUFT 12 127 (260) 70 (158) 32 (90) LPG LA2942 DM1966 172-173 352-353
770 803 (1077) 1500 TA LUFT 12 127 (260) 70 (158) 32 (90) LPG LA2942 DM1969 174-175 354-355
11
G3500Arrangements — ???????? Family Index
Generator Engine Arrangement
12
English
Units
Section
13
14
G3516 High Speed Jacket Water System Performance TM9732-00
ft of
H2O
50
45
40
External Restriction
35
30
25
20
315
10
5
B A
0
180 200 220 240 260 280 300 320 340 360 380 400 420 440 460 480 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9729 JW Pump
gal/min -----------------------Feet of Water -----------------------
211.4 35.4 Drive Ratio 1.33:1
237.8 29.2
264.2 23.0 For high speed (1301 - 1800 rpm) ratings
290.6 47.6 16.8
317.1 40.3 10.7
343.5 33.1 4.5 Curves indicate maximum allowable external resistance.
369.9 25.8 Do not project curves.
396.3 18.6
422.7 11.3
449.2 4.1
15
G3516 Low Speed Jacket Water System Performance TM9733-00
ft of
H2O
50
45
40
External Restriction
35
30
25
20
15
10
5
B A
0
180 200 220 240 260 280 300 320 340 360 380 400 420 440 460 480 500 520 540 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9729 JW Pump
gal/min -----------------------Feet of Water -----------------------
237.8 29.2 Drive Ratio 2:1
264.2 23.0
290.6 47.6 16.8 For low speed (1300 rpm and below) ratings
317.1 40.3 10.7
343.5 33.1 4.5
369.9 25.8 Curves indicate maximum allowable external resistance.
396.3 18.6 Do not project curves.
422.7 11.3
449.2 4.1
16
G3512 HIgh Speed Jacket Water System Performance DM0569-00
ft of
H2O
50
45
40
External Restriction
35
30
25
20
15
10
B A
0
120 140 160 180 200 220 240 260 280 300 320 340 360 380 400 420 440 460 480 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9729 JW Pump
gal/min -----------------------Feet of Water -----------------------
132.1 42.2 Drive Ratio 1.33:1
158.5 54.9 37.3
185.0 49.8 32.5 For high speed (1301-1800 rpm) ratings
211.4 44.7 27.6
237.8 39.5 22.7
264.2 34.4 17.8 Curves indicate maximum allowable external resistance.
290.6 29.2 12.9 Do not project curves.
317.1 24.1 8.1
343.5 19.0 3.2
369.9 13.8
396.3 8.7
422.7 3.5
17
G3512 Low Speed Jacket Water System Performance DM0570-00
ft of
H2O
60
55
50
45
40
External Restriction
35
30
25
20
15
10
5
A
B
0
80 100 120 140 160 180 200 220 240 260 280 300 320 340 360 380 400 420 440 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 Engine equipped with water cooled exhaust manifolds
Pump Speed rpm 2400 2000 or with dry exhaust manifolds and JW aftercooler.
2W9726 JW Pump
External Flow -----------------------External Resistance--------------
gal/min -----------------------Feet of Water ----------------------- Drive Ratio 2:1
132.1 30.1
158.5 47.5 25.6 For low speed (1300 rpm and below) ratings
185.0 42.7 21.1
211.4 37.8 16.6
237.8 33.0 12.1 Curves indicate maximum allowable external resistance.
264.2 28.1 7.6 Do not project curves.
290.6 23.2 3.1
317.1 18.4
343.5 13.5
369.9 8.7
396.3 3.8
18
G3508 High Speed Jacket Water System Performance TM3095-03
ft of
H2O
45
40
External Restriction
35
30
25
20
15
10
5 B
A
0
120 140 160 180 200 220 240 260 280 300 320 340 360 380 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9726 JW Pump
gal/min -----------------------Feet of Water -----------------------
159 34.8 Drive Ratio 1.33 to 1
185 28.9
211 22.6 For high speed (1301-1800 rpm) ratings
238 37.4 16.7
264 30.5 10.8
291 23.3 4.9 Curves indicate maximum allowable external resistance.
317 16.1 Do not project curves.
343 8.9
349 7.5
359 4.6
370 1.6
19
G3508 Low Speed Jacket Water System Performance TM3089-03
ft of
H2O
45
40
External Restriction
35
30
25
20
15
10
5
B
A
0
120 140 160 180 200 220 240 260 280 300 320 340 360 380 400 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
2W9726 JW Pump
External Flow -----------------------External Resistance--------------
gal/min -----------------------Feet of Water ----------------------- Drive Ratio 2.0 to 1
185 28.5
211 22.6 For low speed (1300 rpm and below) ratings
238 37.4 16.7
264 30.5 10.8
291 23.3 4.9 Curves indicate maximum allowable external resistance.
317 16.1 Do not project curves.
343 8.9
370 2.0
20
G3500 High Speed Auxiliary Water System Performance DM0571-00
ft of
H2O
30
25
External Restriction
20
15
10
A
5
B
0
60 70 80 90 100 110 120 130 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 1W9954 AW Pump
Pump Speed rpm 2400 2000
Drive Ratio 2:1
External Flow -----------------------External Resistance--------------
gal/min -----------------------Feet of Water ----------------------- For high speed (1301-1800 rpm) ratings
79.3 20.3
84.5 17.2
89.8 14.0 Curves indicate maximum allowable external resistance.
92.5 12.5 Do not project curves.
95.1 29.3 10.9
97.8 27.5 9.3
100.4 25.7 7.7
103.0 24.0 6.2
105.7 22.2 4.6
108.3 20.5
111.0 18.7
113.6 16.9
116.3 15.2
118.9 13.4
121.5 11.6
124.2 9.9
21
G3500 Low Speed Auxiliary Water System Performance DM0572-00
ft of
H2O
35
30
25
External Restriction
20
15
10 A
5
B
0
60 70 80 90 100 110 120 130 140 150 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 1W9954 AW Pump
Pump Speed rpm 2400 2000
Drive Ratio 2:1
External Flow -----------------------External Resistance--------------
gal/min -----------------------Feet of Water ----------------------- For low speed (1300 rpm and below) ratings
79.3 20.3
84.5 17.2
87.2 15.6 Curves indicate maximum allowable external resistance.
92.5 12.5 Do not project curves.
95.1 29.3 10.9
97.8 27.5 9.3
103.0 24.0 6.2
105.7 22.2 4.6
111.0 18.7
113.6 16.9
118.9 13.4
121.5 11.6
124.2 9.9
22
G3516 Jacket Water Flow vs Pressure Drop
Across Block for Cogen Engine
40
Max
35
Pressure Drop Across Block
30
(in. Hg)
25
20
15
Min
10
250 300 350 400 450 500 550 600
Jacket Water Flow
(gal/min)
Max
30
Pressure Drop Across Block
25
(in. Hg)
20
15
10
Min
5
200 250 300 350 400 450 500
Jacket Water Flow
(gal/min)
23
G3508 Jacket Water Flow vs Pressure Drop
Across Block for Cogen Engine
30
25
Pressure Drop Across Block
Max
20
(in. Hg)
15
10
5
Min
0
100 150 200 250 300 350 400 450
Jacket Water Flow
(gal/min)
24
Notes
25
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7515 7909 8676
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1554 1244 963
Air Mass Flow (Wet) lb/hr 6892 5514 4271
Compressor Out Pressure in. HG (abs) 61.3 59 52.2
Compressor Out Temperature °F 268 240 202
Inlet Manifold Pressure in. HG (abs) 58.7 49.5 39.9
Inlet Manifold Temperature (10) °F 134 133 133
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 864 840 793
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4235 3329 2487
Exhaust Gas Mass Flow (Wet) lb/hr 7273 5820 4510
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.38 1.46 1.53 1.61 1.69 1.77 1.77 1.77 1.77 1.77 1.77 1.77 1.77
AIR INLET TEMP.
120 1.29 1.36 1.44 1.52 1.59 1.67 1.67 1.67 1.67 1.67 1.67 1.67 1.67
110 1.19 1.27 1.34 1.42 1.50 1.57 1.57 1.57 1.57 1.57 1.57 1.57 1.57
100 1.10 1.17 1.25 1.32 1.40 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
90 1.01 1.08 1.15 1.22 1.30 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
80 1.00 1.00 1.06 1.13 1.20 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
70 1.00 1.00 1.00 1.03 1.10 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5144-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
27
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7700 8080 9196
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1365 1046 732
Air Mass Flow (Wet) lb/hr 6054 4639 3246
Compressor Out Pressure in. HG (abs) 60.9 58 52.4
Compressor Out Temperature °F 257 238 209
Inlet Manifold Pressure in. HG (abs) 54.5 46 38.5
Inlet Manifold Temperature (10) °F 133 133 131
Timing (11) °BTDC 23 23 23
Exhaust Stack Temperature °F 912 855 786
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3893 2863 1906
Exhaust Gas Mass Flow (Wet) lb/hr 6451 4952 3476
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.43 1.51 1.60 1.69 1.77 1.86 1.86 1.86 1.86 1.86 1.86 1.86 1.86
AIR INLET TEMP.
120 1.33 1.41 1.49 1.58 1.66 1.75 1.75 1.75 1.75 1.75 1.75 1.75 1.75
110 1.22 1.30 1.38 1.47 1.55 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64
100 1.12 1.20 1.28 1.36 1.44 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53
90 1.01 1.09 1.17 1.25 1.33 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
80 1.00 1.00 1.06 1.14 1.22 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
70 1.00 1.00 1.00 1.03 1.11 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5143-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
29
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7515 7909 8676
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1554 1244 963
Air Mass Flow (Wet) lb/hr 6892 5514 4271
Compressor Out Pressure in. HG (abs) 61.3 59 52.2
Compressor Out Temperature °F 268 240 202
Inlet Manifold Pressure in. HG (abs) 58.7 49.5 39.9
Inlet Manifold Temperature (10) °F 134 133 133
Timing (11) °BTDC 23 23 23
Exhaust Stack Temperature °F 864 840 793
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4235 3329 2487
Exhaust Gas Mass Flow (Wet) lb/hr 7274 5821 4511
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.38 1.46 1.53 1.61 1.69 1.77 1.77 1.77 1.77 1.77 1.77 1.77 1.77
AIR INLET TEMP.
120 1.29 1.36 1.44 1.52 1.59 1.67 1.67 1.67 1.67 1.67 1.67 1.67 1.67
110 1.19 1.27 1.34 1.42 1.50 1.57 1.57 1.57 1.57 1.57 1.57 1.57 1.57
100 1.10 1.17 1.25 1.32 1.40 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
90 1.01 1.08 1.15 1.22 1.30 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
80 1.00 1.00 1.06 1.13 1.20 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
70 1.00 1.00 1.00 1.03 1.10 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5146-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
31
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7700 8080 9196
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1365 1046 732
Air Mass Flow (Wet) lb/hr 6054 4639 3246
Compressor Out Pressure in. HG (abs) 60.9 58 52.4
Compressor Out Temperature °F 257 238 209
Inlet Manifold Pressure in. HG (abs) 54.5 46 38.5
Inlet Manifold Temperature (10) °F 133 133 131
Timing (11) °BTDC 23 23 23
Exhaust Stack Temperature °F 912 855 786
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3878 2849 1892
Exhaust Gas Mass Flow (Wet) lb/hr 6426 4927 3451
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.43 1.51 1.60 1.69 1.77 1.86 1.86 1.86 1.86 1.86 1.86 1.86 1.86
AIR INLET TEMP.
120 1.33 1.41 1.49 1.58 1.66 1.75 1.75 1.75 1.75 1.75 1.75 1.75 1.75
110 1.22 1.30 1.38 1.47 1.55 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64
100 1.12 1.20 1.28 1.36 1.44 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53
90 1.01 1.09 1.17 1.25 1.33 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
80 1.00 1.00 1.06 1.14 1.22 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
70 1.00 1.00 1.00 1.03 1.11 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5145-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
33
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7335 7540 8104
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2264 1680 991
Air Mass Flow (Wet) lb/hr 10040 7450 4392
Compressor Out Pressure in. HG (abs) 69.2 64 45.9
Compressor Out Temperature °F 287 264 179
Inlet Manifold Pressure in. HG (abs) 62.4 47.9 30.2
Inlet Manifold Temperature (10) °F 136 135 138
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °F 842 820 862
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5977 4368 2681
Exhaust Gas Mass Flow (Wet) lb/hr 10437 7756 4611
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.36 1.43 1.50 1.57 1.64 1.71 1.71 1.71 1.71 1.71 1.71 1.71 1.71
AIR INLET TEMP.
120 1.28 1.34 1.41 1.48 1.55 1.62 1.62 1.62 1.62 1.62 1.62 1.62 1.62
110 1.19 1.25 1.32 1.39 1.45 1.52 1.52 1.52 1.52 1.52 1.52 1.52 1.52
100 1.10 1.16 1.23 1.29 1.36 1.43 1.43 1.43 1.43 1.43 1.43 1.43 1.43
90 1.01 1.08 1.14 1.20 1.27 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
80 1.00 1.00 1.05 1.11 1.18 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
70 1.00 1.00 1.00 1.02 1.09 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
60 1.00 1.00 1.00 1.00 1.00 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5148-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
35
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6960 7137 7780
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2215 1547 1063
Air Mass Flow (Wet) lb/hr 9824 6861 4714
Compressor Out Pressure in. HG (abs) 68.9 58.6 44.3
Compressor Out Temperature °F 307 254 185
Inlet Manifold Pressure in. HG (abs) 61.3 44.1 30.8
Inlet Manifold Temperature (10) °F 143 139 137
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 781 811 813
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5563 3996 2756
Exhaust Gas Mass Flow (Wet) lb/hr 10195 7146 4921
G3516
130 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66
AIR INLET TEMP.
120 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70 0.67
110 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
100 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
90 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
80 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
70 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.34 1.41 1.48 1.55 1.59 1.59 1.59 1.59 1.59 1.59 1.59 1.59 1.59
AIR INLET TEMP.
120 1.26 1.33 1.39 1.46 1.50 1.50 1.50 1.50 1.50 1.50 1.50 1.50 1.50
110 1.17 1.24 1.31 1.38 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
100 1.09 1.16 1.22 1.29 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
90 1.01 1.07 1.14 1.20 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
80 1.00 1.00 1.05 1.11 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
70 1.00 1.00 1.00 1.03 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5147-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
37
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6998 7176 7822
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2174 1518 1043
Air Mass Flow (Wet) lb/hr 9640 6733 4626
Compressor Out Pressure in. HG (abs) 66.9 57.1 43.5
Compressor Out Temperature °F 272 227 166
Inlet Manifold Pressure in. HG (abs) 58.5 42.8 30.6
Inlet Manifold Temperature (10) °F 143 139 137
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 781 811 813
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5459 3921 2704
Exhaust Gas Mass Flow (Wet) lb/hr 10004 7012 4829
G3516
130 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.63
AIR INLET TEMP.
120 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64
110 1.00 1.00 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66
100 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
90 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.74 0.71 0.68
80 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
70 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
60 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
(°F) 50 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.41 1.48 1.55 1.59 1.59 1.59 1.59 1.59 1.59 1.59 1.59 1.59 1.59
AIR INLET TEMP.
120 1.31 1.38 1.45 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49
110 1.21 1.28 1.36 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
100 1.12 1.18 1.26 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
90 1.02 1.09 1.16 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
80 1.00 1.00 1.06 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5149-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
39
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7471 7628 7960
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2326 1739 1128
Air Mass Flow (Wet) lb/hr 10316 7710 5003
Compressor Out Pressure in. HG (abs) 69.3 60.3 44.5
Compressor Out Temperature °F 282 244 171
Inlet Manifold Pressure in. HG (abs) 63.4 49.3 34.1
Inlet Manifold Temperature (10) °F 116 112 107
Timing (11) °BTDC 35 35 35
Exhaust Stack Temperature °F 847 847 846
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6173 4618 3001
Exhaust Gas Mass Flow (Wet) lb/hr 10735 8031 5227
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
AIR INLET TEMP.
120 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.80 0.77 0.74
80 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.32 1.38 1.44 1.50 1.56 1.62 1.62 1.62 1.62 1.62 1.62 1.62 1.62
AIR INLET TEMP.
120 1.24 1.30 1.36 1.42 1.48 1.54 1.54 1.54 1.54 1.54 1.54 1.54 1.54
110 1.17 1.22 1.28 1.34 1.40 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
100 1.09 1.15 1.20 1.26 1.32 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
90 1.01 1.07 1.12 1.18 1.24 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
80 1.00 1.00 1.04 1.10 1.16 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
70 1.00 1.00 1.00 1.02 1.07 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
60 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5151-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
41
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7049 7119 7614
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2314 1631 1117
Air Mass Flow (Wet) lb/hr 10261 7232 4952
Compressor Out Pressure in. HG (abs) 69.5 56.9 45.1
Compressor Out Temperature °F 309 264 191
Inlet Manifold Pressure in. HG (abs) 64 46.8 32.3
Inlet Manifold Temperature (10) °F 116 111 109
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 770 792 797
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5766 4148 2858
Exhaust Gas Mass Flow (Wet) lb/hr 10658 7535 5169
G3516
130 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66
AIR INLET TEMP.
120 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70 0.67
110 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
100 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
90 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
80 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
70 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.28 1.34 1.40 1.46 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49
AIR INLET TEMP.
120 1.21 1.27 1.33 1.38 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
110 1.14 1.20 1.26 1.31 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
100 1.08 1.13 1.18 1.24 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
90 1.01 1.06 1.11 1.17 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
80 1.00 1.00 1.04 1.09 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
70 1.00 1.00 1.00 1.02 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5150-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
43
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7087 7158 7656
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2270 1600 1096
Air Mass Flow (Wet) lb/hr 10069 7096 4859
Compressor Out Pressure in. HG (abs) 67.5 55.5 44.3
Compressor Out Temperature °F 275 235 171
Inlet Manifold Pressure in. HG (abs) 61 45.2 32
Inlet Manifold Temperature (10) °F 116 111 109
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 770 792 797
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5658 4070 2804
Exhaust Gas Mass Flow (Wet) lb/hr 10458 7394 5072
G3516
130 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.63
AIR INLET TEMP.
120 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64
110 1.00 1.00 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66
100 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
90 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.74 0.71 0.68
80 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
70 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
60 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
(°F) 50 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.33 1.39 1.45 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
AIR INLET TEMP.
120 1.25 1.31 1.37 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
110 1.17 1.23 1.29 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
100 1.09 1.15 1.21 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
90 1.01 1.07 1.13 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
80 1.00 1.00 1.04 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5152-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
45
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7784 8018 8480
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 3042 2263 1417
Air Mass Flow (Wet) lb/hr 13489 10035 6285
Compressor Out Pressure in. HG (abs) 70.1 60.5 45.1
Compressor Out Temperature °F 306 268 197
Inlet Manifold Pressure in. HG (abs) 63.5 49.4 35.3
Inlet Manifold Temperature (10) °F 138 134 130
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 886 881 917
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8319 6175 3993
Exhaust Gas Mass Flow (Wet) lb/hr 14056 10472 6591
G3516
130 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66
AIR INLET TEMP.
120 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70 0.67
110 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
100 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
90 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
80 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
70 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.33 1.39 1.46 1.52 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56
AIR INLET TEMP.
120 1.25 1.31 1.37 1.44 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47
110 1.17 1.23 1.29 1.36 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
100 1.09 1.15 1.21 1.27 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
90 1.01 1.07 1.13 1.19 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
80 1.00 1.00 1.05 1.11 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
70 1.00 1.00 1.00 1.03 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5167-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
47
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7897 8144 8911
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2097 1433 936
Air Mass Flow (Wet) lb/hr 9300 6352 4150
Compressor Out Pressure in. HG (abs) 67 60.9 45.8
Compressor Out Temperature °F 290 253 183
Inlet Manifold Pressure in. HG (abs) 62.6 45.5 31.3
Inlet Manifold Temperature (10) °F 149 147 149
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 847 865 887
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6035 4244 2851
Exhaust Gas Mass Flow (Wet) lb/hr 10495 7280 4812
G3516
130 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.63
AIR INLET TEMP.
120 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64
110 1.00 1.00 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66
100 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
90 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.83 0.79 0.76 0.74 0.71 0.68
80 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
70 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
60 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
(°F) 50 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.36 1.43 1.50 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53
AIR INLET TEMP.
120 1.27 1.34 1.41 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
110 1.18 1.25 1.32 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35
100 1.09 1.16 1.23 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
90 1.01 1.07 1.14 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
80 1.00 1.00 1.05 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5153-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
49
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7161 7371 7808
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 3040 2316 1602
Air Mass Flow (Wet) lb/hr 13480 10272 7106
Compressor Out Pressure in. HG (abs) 78.8 66.6 49
Compressor Out Temperature °F 307 260 190
Inlet Manifold Pressure in. HG (abs) 74 56.7 39.2
Inlet Manifold Temperature (10) °F 137 134 132
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 954 959 971
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8683 6639 4634
Exhaust Gas Mass Flow (Wet) lb/hr 13958 10638 7363
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.35 1.41 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42
AIR INLET TEMP.
120 1.27 1.32 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
110 1.18 1.24 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
100 1.10 1.16 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
90 1.02 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM0988-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
51
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7246 7421 7942
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 3048 2290 1593
Air Mass Flow (Wet) lb/hr 13516 10155 7065
Compressor Out Pressure in. HG (abs) 79.6 68.2 49.6
Compressor Out Temperature °F 316 274 204
Inlet Manifold Pressure in. HG (abs) 75.4 56.9 39.3
Inlet Manifold Temperature (10) °F 137 134 131
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 1018 1022 1031
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 9104 6862 4808
Exhaust Gas Mass Flow (Wet) lb/hr 14007 10527 7329
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.33 1.39 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
120 1.25 1.31 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
110 1.17 1.23 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
100 1.09 1.15 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
90 1.02 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM0873-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
53
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6916 7134 7507
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2854 2146 1462
Air Mass Flow (Wet) lb/hr 12657 9517 6485
Compressor Out Pressure in. HG (abs) 77.7 61.8 46.3
Compressor Out Temperature °F 304 245 180
Inlet Manifold Pressure in. HG (abs) 70 51.8 36.7
Inlet Manifold Temperature (10) °F 142 135 131
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 984 989 998
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8340 6294 4321
Exhaust Gas Mass Flow (Wet) lb/hr 13129 9878 6737
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.36 1.42 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
120 1.27 1.34 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
110 1.19 1.25 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
100 1.10 1.16 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
90 1.02 1.08 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
80 1.00 1.00 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM0991-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
55
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6965 7210 7617
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2885 2183 1495
Air Mass Flow (Wet) lb/hr 12792 9682 6630
Compressor Out Pressure in. HG (abs) 76.4 65.7 47.9
Compressor Out Temperature °F 300 260 187
Inlet Manifold Pressure in. HG (abs) 70.9 54.1 37.2
Inlet Manifold Temperature (10) °F 135 134 131
Timing (11) °BTDC 19 19 19
Exhaust Stack Temperature °F 1033 1029 1050
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8708 6579 4570
Exhaust Gas Mass Flow (Wet) lb/hr 13262 10042 6883
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.36 1.42 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
120 1.27 1.33 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
110 1.19 1.25 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
100 1.10 1.16 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
90 1.02 1.08 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
80 1.00 1.00 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM0876-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
57
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6953 7209 7693
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2999 2293 1592
Air Mass Flow (Wet) lb/hr 13301 10168 7059
Compressor Out Pressure in. HG (abs) 74.8 64.3 48.2
Compressor Out Temperature °F 305 259 189
Inlet Manifold Pressure in. HG (abs) 70.3 55 38.8
Inlet Manifold Temperature (10) °F 137 134 132
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 921 934 954
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8361 6452 4546
Exhaust Gas Mass Flow (Wet) lb/hr 13763 10525 7312
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.35 1.41 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42
AIR INLET TEMP.
120 1.26 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
110 1.18 1.24 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
100 1.10 1.16 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
90 1.01 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1228-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
59
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7035 7258 7824
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2970 2266 1573
Air Mass Flow (Wet) lb/hr 13172 10049 6973
Compressor Out Pressure in. HG (abs) 75.5 65.8 48.8
Compressor Out Temperature °F 315 273 203
Inlet Manifold Pressure in. HG (abs) 71.6 55.2 38.9
Inlet Manifold Temperature (10) °F 137 134 131
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 982 995 1013
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8654 6663 4685
Exhaust Gas Mass Flow (Wet) lb/hr 13641 10412 7232
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.33 1.39 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
120 1.25 1.31 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
110 1.17 1.23 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
100 1.09 1.15 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
90 1.01 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1240-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
61
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6714 6977 7396
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2781 2105 1443
Air Mass Flow (Wet) lb/hr 12334 9333 6400
Compressor Out Pressure in. HG (abs) 73.7 59.8 45.6
Compressor Out Temperature °F 302 244 180
Inlet Manifold Pressure in. HG (abs) 66.6 50.3 36.4
Inlet Manifold Temperature (10) °F 142 135 131
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 950 963 981
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7930 6059 4212
Exhaust Gas Mass Flow (Wet) lb/hr 12786 9683 6647
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.36 1.42 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47
AIR INLET TEMP.
120 1.27 1.34 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
110 1.19 1.25 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
100 1.10 1.16 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
90 1.01 1.08 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
80 1.00 1.00 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1231-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
63
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6762 7051 7505
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2817 2150 1483
Air Mass Flow (Wet) lb/hr 12491 9533 6577
Compressor Out Pressure in. HG (abs) 72.6 63.4 47.1
Compressor Out Temperature °F 298 259 187
Inlet Manifold Pressure in. HG (abs) 67.4 52.5 36.8
Inlet Manifold Temperature (10) °F 135 134 131
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °F 997 1002 1031
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8292 6356 4476
Exhaust Gas Mass Flow (Wet) lb/hr 12942 9883 6825
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.35 1.42 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
120 1.27 1.33 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
110 1.18 1.25 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
100 1.10 1.16 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
90 1.01 1.07 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
80 1.00 1.00 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1243-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
65
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7976 8046 8586
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2842 2036 1417
Air Mass Flow (Wet) lb/hr 12602 9028 6281
Compressor Out Pressure in. HG (abs) 75.4 66.7 49.5
Compressor Out Temperature °F 299 267 198
Inlet Manifold Pressure in. HG (abs) 67.3 50.3 36.5
Inlet Manifold Temperature (10) °F 144 139 135
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °F 905 901 901
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7886 5647 3933
Exhaust Gas Mass Flow (Wet) lb/hr 13135 9432 6568
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
AIR INLET TEMP.
120 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.80 0.77 0.74
80 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.36 1.42 1.49 1.56 1.62 1.69 1.69 1.69 1.69 1.69 1.69 1.69 1.69
AIR INLET TEMP.
120 1.27 1.34 1.40 1.47 1.53 1.59 1.59 1.59 1.59 1.59 1.59 1.59 1.59
110 1.19 1.25 1.31 1.38 1.44 1.50 1.50 1.50 1.50 1.50 1.50 1.50 1.50
100 1.10 1.16 1.23 1.29 1.35 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
90 1.02 1.08 1.14 1.20 1.26 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
80 1.00 1.00 1.05 1.11 1.17 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
70 1.00 1.00 1.00 1.02 1.08 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
60 1.00 1.00 1.00 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5156-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
67
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7490 7662 8083
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2656 1974 1261
Air Mass Flow (Wet) lb/hr 11780 8755 5591
Compressor Out Pressure in. HG (abs) 73.7 63 46
Compressor Out Temperature °F 314 265 189
Inlet Manifold Pressure in. HG (abs) 65.8 49.8 33.6
Inlet Manifold Temperature (10) °F 140 138 138
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 840 844 864
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7022 5241 3412
Exhaust Gas Mass Flow (Wet) lb/hr 12280 9140 5861
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
AIR INLET TEMP.
120 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.80 0.77 0.74
80 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.32 1.38 1.44 1.51 1.57 1.63 1.63 1.63 1.63 1.63 1.63 1.63 1.63
AIR INLET TEMP.
120 1.24 1.30 1.36 1.43 1.49 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55
110 1.16 1.22 1.28 1.35 1.41 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47
100 1.09 1.15 1.20 1.27 1.33 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
90 1.01 1.07 1.13 1.18 1.24 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
80 1.00 1.00 1.05 1.10 1.16 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
70 1.00 1.00 1.00 1.02 1.08 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
60 1.00 1.00 1.00 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5157-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
DM5157-00
69
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7255 7636 8136
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2765 2094 1330
Air Mass Flow (Wet) lb/hr 12260 9284 5896
Compressor Out Pressure in. HG (abs) 71.7 66.8 48.5
Compressor Out Temperature °F 302 266 192
Inlet Manifold Pressure in. HG (abs) 65.3 50.1 32.9
Inlet Manifold Temperature (10) °F 142 133 118
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 847 847 865
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7332 5561 3597
Exhaust Gas Mass Flow (Wet) lb/hr 12750 9671 6170
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.34 1.40 1.47 1.53 1.60 1.67 1.67 1.67 1.67 1.67 1.67 1.67 1.67
AIR INLET TEMP.
120 1.26 1.32 1.38 1.45 1.52 1.58 1.58 1.58 1.58 1.58 1.58 1.58 1.58
110 1.17 1.24 1.30 1.36 1.43 1.50 1.50 1.50 1.50 1.50 1.50 1.50 1.50
100 1.09 1.15 1.22 1.28 1.34 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
90 1.01 1.07 1.13 1.19 1.26 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
80 1.00 1.00 1.05 1.11 1.17 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
70 1.00 1.00 1.00 1.02 1.08 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
60 1.00 1.00 1.00 1.00 1.00 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5158-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
71
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6732 7110 7614
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 3028 2363 1654
Air Mass Flow (Wet) lb/hr 13428 10481 7333
Compressor Out Pressure in. HG (abs) 75.3 65.1 48.9
Compressor Out Temperature °F 308 260 192
Inlet Manifold Pressure in. HG (abs) 69.9 54.1 38.8
Inlet Manifold Temperature (10) °F 104 98 92
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 905 918 932
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8347 6577 4653
Exhaust Gas Mass Flow (Wet) lb/hr 13904 10855 7599
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.29 1.34 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35
AIR INLET TEMP.
120 1.22 1.27 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
110 1.15 1.20 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
100 1.08 1.13 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5166-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
73
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6831 7046 7406
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 3083 2343 1618
Air Mass Flow (Wet) lb/hr 13673 10390 7173
Compressor Out Pressure in. HG (abs) 77.2 66.9 49.1
Compressor Out Temperature °F 318 270 195
Inlet Manifold Pressure in. HG (abs) 72.3 55 38.4
Inlet Manifold Temperature (10) °F 106 99 94
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 957 966 991
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8823 6750 4747
Exhaust Gas Mass Flow (Wet) lb/hr 14155 10761 7436
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.28 1.33 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
AIR INLET TEMP.
120 1.21 1.26 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
110 1.14 1.19 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
100 1.08 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
90 1.01 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5161-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
75
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6559 6872 7272
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2869 2193 1494
Air Mass Flow (Wet) lb/hr 12724 9725 6625
Compressor Out Pressure in. HG (abs) 74.9 61.6 46.8
Compressor Out Temperature °F 306 250 183
Inlet Manifold Pressure in. HG (abs) 67.7 51.5 36.2
Inlet Manifold Temperature (10) °F 106 99 92
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 912 934 937
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7962 6186 4230
Exhaust Gas Mass Flow (Wet) lb/hr 13193 10091 6882
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.29 1.34 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
120 1.22 1.27 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
110 1.15 1.20 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
100 1.08 1.13 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
90 1.01 1.06 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5162-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
77
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6668 6977 7441
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2911 2240 1558
Air Mass Flow (Wet) lb/hr 12912 9932 6910
Compressor Out Pressure in. HG (abs) 74.1 64.5 48
Compressor Out Temperature °F 304 264 196
Inlet Manifold Pressure in. HG (abs) 68.3 52.7 37.2
Inlet Manifold Temperature (10) °F 104 98 93
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 970 981 999
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8416 6526 4600
Exhaust Gas Mass Flow (Wet) lb/hr 13383 10299 7170
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.29 1.34 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
120 1.22 1.27 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
110 1.15 1.20 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
100 1.08 1.13 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
90 1.01 1.06 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5163-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
79
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6732 7110 7614
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 3028 2363 1654
Air Mass Flow (Wet) lb/hr 13428 10481 7333
Compressor Out Pressure in. HG (abs) 75.3 65.1 48.9
Compressor Out Temperature °F 308 260 192
Inlet Manifold Pressure in. HG (abs) 69.9 54.1 38.8
Inlet Manifold Temperature (10) °F 104 98 92
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 905 918 932
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8346 6576 4652
Exhaust Gas Mass Flow (Wet) lb/hr 13902 10854 7599
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.29 1.34 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35
AIR INLET TEMP.
120 1.22 1.27 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
110 1.15 1.20 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
100 1.08 1.13 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1229-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
81
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6831 7046 7406
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 3083 2343 1618
Air Mass Flow (Wet) lb/hr 13673 10390 7173
Compressor Out Pressure in. HG (abs) 77.2 66.9 49.1
Compressor Out Temperature °F 318 270 195
Inlet Manifold Pressure in. HG (abs) 72.3 55 38.4
Inlet Manifold Temperature (10) °F 106 99 94
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 957 966 991
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8823 6750 4747
Exhaust Gas Mass Flow (Wet) lb/hr 14155 10761 7436
G3516
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.28 1.33 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
AIR INLET TEMP.
120 1.21 1.26 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
110 1.14 1.19 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
100 1.08 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
90 1.01 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1241-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
83
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6559 6872 7272
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2869 2193 1494
Air Mass Flow (Wet) lb/hr 12724 9725 6625
Compressor Out Pressure in. HG (abs) 74.9 61.6 46.8
Compressor Out Temperature °F 306 250 183
Inlet Manifold Pressure in. HG (abs) 67.7 51.5 36.2
Inlet Manifold Temperature (10) °F 106 99 92
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 912 934 937
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7962 6186 4230
Exhaust Gas Mass Flow (Wet) lb/hr 13192 10090 6882
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.29 1.34 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
120 1.22 1.27 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
110 1.15 1.20 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
100 1.08 1.13 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
90 1.01 1.06 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1232-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 8
85
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6668 6977 7441
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2911 2240 1558
Air Mass Flow (Wet) lb/hr 12912 9932 6910
Compressor Out Pressure in. HG (abs) 74.1 64.5 48
Compressor Out Temperature °F 304 264 196
Inlet Manifold Pressure in. HG (abs) 68.3 52.7 37.2
Inlet Manifold Temperature (10) °F 104 98 93
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 970 981 999
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 8416 6526 4600
Exhaust Gas Mass Flow (Wet) lb/hr 13383 10299 7170
G3516
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.29 1.34 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
120 1.22 1.27 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
110 1.15 1.20 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
100 1.08 1.13 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
90 1.01 1.06 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1244-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
87
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7352 7485 7899
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2769 2039 1310
Air Mass Flow (Wet) lb/hr 12280 9044 5810
Compressor Out Pressure in. HG (abs) 74 63.5 46.9
Compressor Out Temperature °F 317 266 191
Inlet Manifold Pressure in. HG (abs) 65.9 49.5 33.7
Inlet Manifold Temperature (10) °F 111 106 104
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 824 826 847
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7229 5339 3501
Exhaust Gas Mass Flow (Wet) lb/hr 12800 9442 6089
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
AIR INLET TEMP.
120 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.80 0.77 0.74
80 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.83 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.27 1.32 1.37 1.43 1.48 1.54 1.54 1.54 1.54 1.54 1.54 1.54 1.54
AIR INLET TEMP.
120 1.20 1.26 1.31 1.36 1.41 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47
110 1.14 1.19 1.24 1.29 1.35 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
100 1.07 1.12 1.17 1.22 1.28 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
90 1.01 1.06 1.11 1.16 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
80 1.00 1.00 1.04 1.09 1.14 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
70 1.00 1.00 1.00 1.02 1.07 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
60 1.00 1.00 1.00 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5159-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
89
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7145 7578 7975
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2875 2236 1414
Air Mass Flow (Wet) lb/hr 12752 9915 6268
Compressor Out Pressure in. HG (abs) 73 69.2 49.8
Compressor Out Temperature °F 303 278 199
Inlet Manifold Pressure in. HG (abs) 66 52 34.3
Inlet Manifold Temperature (10) °F 112 108 107
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 833 829 853
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 7542 5853 3784
Exhaust Gas Mass Flow (Wet) lb/hr 13263 10321 6553
G3516
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
130 1.28 1.33 1.39 1.44 1.49 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55
AIR INLET TEMP.
120 1.21 1.26 1.32 1.37 1.42 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
110 1.15 1.20 1.25 1.30 1.35 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
100 1.08 1.13 1.18 1.23 1.28 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
90 1.01 1.06 1.11 1.16 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
80 1.00 1.00 1.04 1.09 1.14 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
70 1.00 1.00 1.00 1.02 1.07 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
60 1.00 1.00 1.00 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5165-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
91
®
G3512 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7501 7894 8506
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1167 890 660
Air Mass Flow (Wet) lb/hr 5172 3947 2924
Compressor Out Pressure in. HG (abs) 58.4 54 43.1
Compressor Out Temperature °F 243 223 166
Inlet Manifold Pressure in. HG (abs) 53.7 43.3 32.2
Inlet Manifold Temperature (10) °F 140 138 137
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 869 838 786
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3195 2386 1694
Exhaust Gas Mass Flow (Wet) lb/hr 5466 4178 3090
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.48 1.57 1.66 1.75 1.85 1.94 1.94 1.94 1.94 1.94 1.94 1.94 1.94
AIR INLET TEMP.
120 1.36 1.45 1.54 1.63 1.73 1.82 1.82 1.82 1.82 1.82 1.82 1.82 1.82
110 1.25 1.33 1.42 1.51 1.60 1.70 1.70 1.70 1.70 1.70 1.70 1.70 1.70
100 1.13 1.22 1.30 1.39 1.48 1.58 1.58 1.58 1.58 1.58 1.58 1.58 1.58
90 1.02 1.10 1.19 1.27 1.36 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
80 1.00 1.00 1.07 1.15 1.24 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
70 1.00 1.00 1.00 1.03 1.12 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5207-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
93
®
G3512 TA Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 25
Exhaust Manifold WATER COOLED Methane Number at Conditions Shown 80
Combustion System Type CATALYST Rated Altitude (ft) 5000
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7822 8255 8993
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1107 879 637
Air Mass Flow (Wet) lb/hr 4908 3898 2822
Compressor Out Pressure in. HG (abs) 60.2 55.3 42.9
Compressor Out Temperature °F 258 235 173
Inlet Manifold Pressure in. HG (abs) 52.5 43.3 32.5
Inlet Manifold Temperature (10) °F 139 136 136
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 892 837 790
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3102 2361 1648
Exhaust Gas Mass Flow (Wet) lb/hr 5214 4141 2998
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.43 1.52 1.60 1.69 1.78 1.87 1.87 1.87 1.87 1.87 1.87 1.87 1.87
AIR INLET TEMP.
120 1.33 1.41 1.50 1.58 1.67 1.76 1.76 1.76 1.76 1.76 1.76 1.76 1.76
110 1.22 1.30 1.39 1.47 1.56 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64
100 1.12 1.20 1.28 1.36 1.45 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53
90 1.01 1.09 1.17 1.25 1.33 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42
80 1.00 1.00 1.06 1.14 1.22 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
70 1.00 1.00 1.00 1.03 1.11 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5209-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
95
®
G3512 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7501 7894 8506
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1167 890 660
Air Mass Flow (Wet) lb/hr 5172 3947 2924
Compressor Out Pressure in. HG (abs) 58.4 54 43.1
Compressor Out Temperature °F 243 223 166
Inlet Manifold Pressure in. HG (abs) 53.7 43.3 32.2
Inlet Manifold Temperature (10) °F 140 138 137
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 869 838 786
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3195 2386 1694
Exhaust Gas Mass Flow (Wet) lb/hr 5466 4178 3090
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.48 1.57 1.66 1.75 1.85 1.94 1.94 1.94 1.94 1.94 1.94 1.94 1.94
AIR INLET TEMP.
120 1.36 1.45 1.54 1.63 1.73 1.82 1.82 1.82 1.82 1.82 1.82 1.82 1.82
110 1.25 1.33 1.42 1.51 1.60 1.70 1.70 1.70 1.70 1.70 1.70 1.70 1.70
100 1.13 1.22 1.30 1.39 1.48 1.58 1.58 1.58 1.58 1.58 1.58 1.58 1.58
90 1.02 1.10 1.19 1.27 1.36 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
80 1.00 1.00 1.07 1.15 1.24 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
70 1.00 1.00 1.00 1.03 1.12 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5108-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
97
®
G3512 TA Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold WATER COOLED Methane Number at Conditions Shown 80
Combustion System Type CATALYST Rated Altitude (ft) 5000
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7822 8255 8993
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1107 879 637
Air Mass Flow (Wet) lb/hr 4908 3898 2822
Compressor Out Pressure in. HG (abs) 60.2 55.3 42.9
Compressor Out Temperature °F 258 235 173
Inlet Manifold Pressure in. HG (abs) 52.5 43.3 32.5
Inlet Manifold Temperature (10) °F 139 136 136
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 892 837 790
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3102 2361 1648
Exhaust Gas Mass Flow (Wet) lb/hr 5214 4141 2998
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.43 1.52 1.60 1.69 1.78 1.87 1.87 1.87 1.87 1.87 1.87 1.87 1.87
AIR INLET TEMP.
120 1.33 1.41 1.50 1.58 1.67 1.76 1.76 1.76 1.76 1.76 1.76 1.76 1.76
110 1.22 1.30 1.39 1.47 1.56 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64
100 1.12 1.20 1.28 1.36 1.45 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53
90 1.01 1.09 1.17 1.25 1.33 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42
80 1.00 1.00 1.06 1.14 1.22 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
70 1.00 1.00 1.00 1.03 1.11 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5109-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
99
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7221 7330 8401
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1759 1269 851
Air Mass Flow (Wet) lb/hr 7800 5627 3775
Compressor Out Pressure in. HG (abs) 72.9 60.5 47.8
Compressor Out Temperature °F 308 251 191
Inlet Manifold Pressure in. HG (abs) 63.3 48.6 34.7
Inlet Manifold Temperature (10) °F 137 133 132
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 730 741 734
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4234 3091 2066
Exhaust Gas Mass Flow (Wet) lb/hr 8087 5850 3934
G3512
Noise - Exhaust @ 1.5 m 111 dB(A)
130 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
AIR INLET TEMP.
120 0.99 0.96 0.92 0.89 0.86 0.83 0.79 0.77 0.74 0.71 0.68 0.66 0.63
110 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
100 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
90 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
80 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
70 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69
60 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.33 1.39 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
AIR INLET TEMP.
120 1.25 1.31 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
110 1.17 1.23 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
100 1.09 1.15 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
90 1.01 1.07 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
80 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM0745-02 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
101
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7212 7401 7934
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1668 1261 844
Air Mass Flow (Wet) lb/hr 7395 5591 3744
Compressor Out Pressure in. HG (abs) 71.8 60.3 45.6
Compressor Out Temperature °F 309 261 185
Inlet Manifold Pressure in. HG (abs) 63.8 48.6 34
Inlet Manifold Temperature (10) °F 145 144 146
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 768 788 792
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4149 3191 2148
Exhaust Gas Mass Flow (Wet) lb/hr 7680 5813 3902
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
AIR INLET TEMP.
120 0.99 0.96 0.92 0.89 0.86 0.83 0.79 0.77 0.74 0.71 0.68 0.66 0.63
110 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
100 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
90 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
80 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
70 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69
60 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.32 1.39 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
AIR INLET TEMP.
120 1.24 1.31 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36
110 1.17 1.23 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
100 1.09 1.15 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
90 1.01 1.07 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
80 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5110-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
103
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7221 7330 8401
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1759 1269 851
Air Mass Flow (Wet) lb/hr 7800 5627 3775
Compressor Out Pressure in. HG (abs) 72.9 60.5 47.8
Compressor Out Temperature °F 314 253 191
Inlet Manifold Pressure in. HG (abs) 63.3 48.6 34.7
Inlet Manifold Temperature (10) °F 137 133 132
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 730 741 734
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4235 3091 2066
Exhaust Gas Mass Flow (Wet) lb/hr 8088 5850 3935
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.73 0.70 0.67 0.65 0.62 0.60
AIR INLET TEMP.
120 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66 0.63 0.61
110 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
100 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.74 0.71 0.68 0.66 0.63
90 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
80 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
70 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
60 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.97 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.32 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
AIR INLET TEMP.
120 1.24 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
110 1.16 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
100 1.09 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5112-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
105
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7212 7401 7934
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1668 1261 844
Air Mass Flow (Wet) lb/hr 7395 5591 3744
Compressor Out Pressure in. HG (abs) 71.8 60.3 45.6
Compressor Out Temperature °F 315 263 185
Inlet Manifold Pressure in. HG (abs) 63.8 48.6 34
Inlet Manifold Temperature (10) °F 145 144 146
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 768 788 792
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4149 3191 2148
Exhaust Gas Mass Flow (Wet) lb/hr 7680 5813 3902
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.73 0.70 0.67 0.65 0.62 0.60
AIR INLET TEMP.
120 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66 0.63 0.61
110 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
100 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.74 0.71 0.68 0.66 0.63
90 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
80 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
70 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
60 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.97 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.31 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
AIR INLET TEMP.
120 1.24 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
110 1.16 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
100 1.08 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5111-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
107
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7407 7599 8087
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1813 1323 882
Air Mass Flow (Wet) lb/hr 8038 5867 3909
Compressor Out Pressure in. HG (abs) 71.8 63.8 46.4
Compressor Out Temperature °F 317 277 199
Inlet Manifold Pressure in. HG (abs) 63.9 48.7 33.6
Inlet Manifold Temperature (10) °F 113 111 110
Timing (11) °BTDC 35 35 35
Exhaust Stack Temperature °F 799 790 790
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4625 3359 2244
Exhaust Gas Mass Flow (Wet) lb/hr 8354 6110 4082
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
AIR INLET TEMP.
120 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
110 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
100 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
90 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
80 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72
70 1.00 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.26 1.31 1.37 1.42 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
AIR INLET TEMP.
120 1.20 1.25 1.30 1.35 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
110 1.13 1.18 1.24 1.29 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
100 1.07 1.12 1.17 1.22 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
90 1.01 1.05 1.10 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
80 1.00 1.00 1.04 1.09 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
70 1.00 1.00 1.00 1.02 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5169-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
109
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6993 8006 8441
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1782 1314 885
Air Mass Flow (Wet) lb/hr 7902 5825 3925
Compressor Out Pressure in. HG (abs) 70.5 60.7 46
Compressor Out Temperature °F 294 249 177
Inlet Manifold Pressure in. HG (abs) 62.3 47.5 33.8
Inlet Manifold Temperature (10) °F 109 106 106
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 720 730 732
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4253 3183 2153
Exhaust Gas Mass Flow (Wet) lb/hr 8198 6080 4107
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
AIR INLET TEMP.
120 0.99 0.96 0.92 0.89 0.86 0.83 0.79 0.77 0.74 0.71 0.68 0.66 0.63
110 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
100 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
90 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
80 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
70 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69
60 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.29 1.34 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
120 1.22 1.27 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
110 1.15 1.20 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
100 1.08 1.13 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
90 1.01 1.06 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
80 1.00 1.00 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5173-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
111
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6993 8006 8441
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1782 1314 885
Air Mass Flow (Wet) lb/hr 7902 5825 3925
Compressor Out Pressure in. HG (abs) 70.5 60.7 46
Compressor Out Temperature °F 294 249 177
Inlet Manifold Pressure in. HG (abs) 62.3 47.5 33.8
Inlet Manifold Temperature (10) °F 109 106 106
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 720 730 732
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4253 3183 2153
Exhaust Gas Mass Flow (Wet) lb/hr 8198 6080 4107
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.73 0.70 0.67 0.65 0.62 0.60
AIR INLET TEMP.
120 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66 0.63 0.61
110 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
100 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.74 0.71 0.68 0.66 0.63
90 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
80 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
70 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
60 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.97 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.29 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
AIR INLET TEMP.
120 1.22 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
110 1.15 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
100 1.08 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
90 1.01 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5115-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
113
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7409 7551 8093
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1803 1293 875
Air Mass Flow (Wet) lb/hr 7994 5735 3881
Compressor Out Pressure in. HG (abs) 72.9 63.9 47.2
Compressor Out Temperature °F 320 283 194
Inlet Manifold Pressure in. HG (abs) 64.8 48.7 33.9
Inlet Manifold Temperature (10) °F 120 120 121
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °F 833 824 817
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4726 3375 2268
Exhaust Gas Mass Flow (Wet) lb/hr 8310 5976 4038
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
AIR INLET TEMP.
120 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
110 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
100 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
90 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
80 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72
70 1.00 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.26 1.31 1.36 1.42 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
AIR INLET TEMP.
120 1.20 1.25 1.30 1.35 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
110 1.13 1.18 1.23 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
100 1.07 1.12 1.17 1.22 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
90 1.01 1.05 1.10 1.15 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
80 1.00 1.00 1.04 1.09 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
70 1.00 1.00 1.00 1.02 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5113-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
115
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6961 7189 7714
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1754 1297 869
Air Mass Flow (Wet) lb/hr 7778 5750 3854
Compressor Out Pressure in. HG (abs) 75.1 61.4 44.9
Compressor Out Temperature °F 321 264 189
Inlet Manifold Pressure in. HG (abs) 64 48.4 33.6
Inlet Manifold Temperature (10) °F 113 114 116
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 752 781 784
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4304 3263 2199
Exhaust Gas Mass Flow (Wet) lb/hr 8074 5979 4018
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
AIR INLET TEMP.
120 0.99 0.96 0.92 0.89 0.86 0.83 0.79 0.77 0.74 0.71 0.68 0.66 0.63
110 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
100 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
90 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
80 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
70 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69
60 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.26 1.31 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35
AIR INLET TEMP.
120 1.20 1.25 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
110 1.13 1.18 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
100 1.07 1.12 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
90 1.01 1.05 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
80 1.00 1.00 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5114-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
117
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6961 7189 7714
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1754 1297 869
Air Mass Flow (Wet) lb/hr 7778 5750 3854
Compressor Out Pressure in. HG (abs) 75.1 61.4 44.9
Compressor Out Temperature °F 328 268 189
Inlet Manifold Pressure in. HG (abs) 64 48.4 33.6
Inlet Manifold Temperature (10) °F 113 114 116
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 752 781 784
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4304 3263 2199
Exhaust Gas Mass Flow (Wet) lb/hr 8074 5979 4018
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.73 0.70 0.67 0.65 0.62 0.60
AIR INLET TEMP.
120 0.96 0.92 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68 0.66 0.63 0.61
110 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.70 0.67 0.64 0.62
100 0.99 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.74 0.71 0.68 0.66 0.63
90 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67 0.64
80 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
70 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.67
60 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.97 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.25 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
AIR INLET TEMP.
120 1.19 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
110 1.13 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
100 1.07 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
90 1.01 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5116-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
119
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7610 7739 8259
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2214 1601 1113
Air Mass Flow (Wet) lb/hr 9820 7099 4937
Compressor Out Pressure in. HG (abs) 78.7 69 50.1
Compressor Out Temperature °F 325 293 211
Inlet Manifold Pressure in. HG (abs) 67.6 49.6 35.5
Inlet Manifold Temperature (10) °F 137 132 127
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °F 874 869 869
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5985 4318 3006
Exhaust Gas Mass Flow (Wet) lb/hr 10197 7387 5142
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.31 1.36 1.42 1.48 1.54 1.60 1.60 1.60 1.60 1.60 1.60 1.60 1.60
AIR INLET TEMP.
120 1.23 1.29 1.35 1.40 1.46 1.52 1.52 1.52 1.52 1.52 1.52 1.52 1.52
110 1.16 1.21 1.27 1.33 1.38 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
100 1.09 1.14 1.19 1.25 1.31 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36
90 1.01 1.06 1.12 1.17 1.23 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
80 1.00 1.00 1.04 1.10 1.15 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
70 1.00 1.00 1.00 1.02 1.07 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
60 1.00 1.00 1.00 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5171-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
121
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7676 7808 8254
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2230 1609 1117
Air Mass Flow (Wet) lb/hr 9887 7136 4953
Compressor Out Pressure in. HG (abs) 78.8 69 50.1
Compressor Out Temperature °F 324 293 211
Inlet Manifold Pressure in. HG (abs) 69 50.1 35.6
Inlet Manifold Temperature (10) °F 144 137 130
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °F 898 887 881
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6132 4397 3042
Exhaust Gas Mass Flow (Wet) lb/hr 10264 7424 5159
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.31 1.37 1.43 1.49 1.55 1.61 1.61 1.61 1.61 1.61 1.61 1.61 1.61
AIR INLET TEMP.
120 1.24 1.29 1.35 1.41 1.47 1.53 1.53 1.53 1.53 1.53 1.53 1.53 1.53
110 1.16 1.22 1.27 1.33 1.39 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
100 1.09 1.14 1.20 1.25 1.31 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
90 1.01 1.07 1.12 1.18 1.23 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
80 1.00 1.00 1.04 1.10 1.15 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
70 1.00 1.00 1.00 1.02 1.07 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
60 1.00 1.00 1.00 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5122-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
123
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7479 7820 8354
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2000 1555 1013
Air Mass Flow (Wet) lb/hr 8868 6895 4492
Compressor Out Pressure in. HG (abs) 71 62.1 48.3
Compressor Out Temperature °F 293 252 195
Inlet Manifold Pressure in. HG (abs) 62.9 49.9 34.7
Inlet Manifold Temperature (10) °F 143 139 135
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °F 872 878 888
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5414 4233 2794
Exhaust Gas Mass Flow (Wet) lb/hr 9242 7192 4711
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
AIR INLET TEMP.
120 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.77 0.75 0.72 0.69
110 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
100 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
90 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
80 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74
70 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78 0.75
60 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.35 1.42 1.48 1.55 1.62 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64
AIR INLET TEMP.
120 1.27 1.33 1.40 1.46 1.53 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55
110 1.18 1.25 1.31 1.38 1.44 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46
100 1.10 1.16 1.22 1.29 1.35 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
90 1.01 1.07 1.14 1.20 1.26 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
80 1.00 1.00 1.05 1.11 1.17 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
70 1.00 1.00 1.00 1.02 1.08 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
60 1.00 1.00 1.00 1.00 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5123-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
125
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7573 7763 8293
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2033 1580 1030
Air Mass Flow (Wet) lb/hr 9014 7008 4566
Compressor Out Pressure in. HG (abs) 71.7 62.6 48.6
Compressor Out Temperature °F 293 252 195
Inlet Manifold Pressure in. HG (abs) 63.6 50.3 34.8
Inlet Manifold Temperature (10) °F 150 146 142
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °F 889 896 906
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5567 4353 2873
Exhaust Gas Mass Flow (Wet) lb/hr 9383 7301 4782
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
AIR INLET TEMP.
120 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.77 0.75 0.72 0.69
110 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
100 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
90 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
80 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74
70 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78 0.75
60 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.35 1.42 1.48 1.55 1.62 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64
AIR INLET TEMP.
120 1.27 1.33 1.40 1.46 1.53 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55
110 1.18 1.25 1.31 1.37 1.44 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46
100 1.10 1.16 1.22 1.29 1.35 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
90 1.01 1.07 1.14 1.20 1.26 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
80 1.00 1.00 1.05 1.11 1.17 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
70 1.00 1.00 1.00 1.02 1.08 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
60 1.00 1.00 1.00 1.00 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5121-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
127
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7479 7820 8354
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2000 1555 1013
Air Mass Flow (Wet) lb/hr 8868 6895 4492
Compressor Out Pressure in. HG (abs) 71 62.1 48.3
Compressor Out Temperature °F 304 256 196
Inlet Manifold Pressure in. HG (abs) 62.9 49.9 34.7
Inlet Manifold Temperature (10) °F 143 139 135
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °F 872 878 888
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5414 4233 2794
Exhaust Gas Mass Flow (Wet) lb/hr 9242 7192 4711
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
AIR INLET TEMP.
120 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.66
110 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68
100 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69
90 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
80 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
70 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74
(°F) 50 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.33 1.40 1.46 1.53 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55
AIR INLET TEMP.
120 1.25 1.31 1.38 1.44 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46
110 1.17 1.23 1.30 1.36 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
100 1.09 1.15 1.21 1.28 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
90 1.01 1.07 1.13 1.19 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
80 1.00 1.00 1.05 1.11 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
70 1.00 1.00 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5126-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
129
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7573 7763 8293
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2033 1580 1030
Air Mass Flow (Wet) lb/hr 9014 7008 4566
Compressor Out Pressure in. HG (abs) 71.7 62.6 48.6
Compressor Out Temperature °F 302 260 200
Inlet Manifold Pressure in. HG (abs) 63.6 50.3 34.8
Inlet Manifold Temperature (10) °F 150 146 142
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °F 889 896 906
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5567 4353 2873
Exhaust Gas Mass Flow (Wet) lb/hr 9383 7301 4782
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
AIR INLET TEMP.
120 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.66
110 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68
100 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69
90 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
80 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
70 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74
(°F) 50 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.34 1.40 1.46 1.53 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55
AIR INLET TEMP.
120 1.25 1.32 1.38 1.45 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47 1.47
110 1.17 1.23 1.30 1.36 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
100 1.09 1.15 1.21 1.28 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
90 1.01 1.07 1.13 1.19 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
80 1.00 1.00 1.05 1.11 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
70 1.00 1.00 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5125-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
131
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7460 7535 8075
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2289 1662 1130
Air Mass Flow (Wet) lb/hr 10150 7368 5009
Compressor Out Pressure in. HG (abs) 79.1 70 50.9
Compressor Out Temperature °F 329 300 215
Inlet Manifold Pressure in. HG (abs) 67.5 50.5 35
Inlet Manifold Temperature (10) °F 110 104 92
Timing (11) °BTDC 35 35 35
Exhaust Stack Temperature °F 869 858 865
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6162 4444 3044
Exhaust Gas Mass Flow (Wet) lb/hr 10542 7665 5222
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.26 1.31 1.36 1.41 1.46 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51
AIR INLET TEMP.
120 1.20 1.24 1.29 1.34 1.39 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
110 1.13 1.18 1.23 1.28 1.33 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
100 1.07 1.12 1.16 1.21 1.26 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
90 1.01 1.05 1.10 1.15 1.19 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
80 1.00 1.00 1.04 1.08 1.13 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
70 1.00 1.00 1.00 1.02 1.06 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
60 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5170-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
133
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7562 7640 8069
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2305 1670 1134
Air Mass Flow (Wet) lb/hr 10220 7406 5026
Compressor Out Pressure in. HG (abs) 79.2 70.1 51
Compressor Out Temperature °F 329 300 215
Inlet Manifold Pressure in. HG (abs) 68.9 51.1 35.1
Inlet Manifold Temperature (10) °F 116 107 94
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °F 893 876 877
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6313 4525 3081
Exhaust Gas Mass Flow (Wet) lb/hr 10612 7703 5239
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.26 1.31 1.36 1.41 1.46 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51
AIR INLET TEMP.
120 1.20 1.25 1.30 1.35 1.40 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
110 1.14 1.18 1.23 1.28 1.33 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
100 1.07 1.12 1.17 1.21 1.26 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
90 1.01 1.05 1.10 1.15 1.20 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
80 1.00 1.00 1.04 1.08 1.13 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
70 1.00 1.00 1.00 1.02 1.06 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
60 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5132-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
135
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7280 7720 8126
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2110 1658 1052
Air Mass Flow (Wet) lb/hr 9355 7353 4665
Compressor Out Pressure in. HG (abs) 72.2 68.6 49.6
Compressor Out Temperature °F 297 274 196
Inlet Manifold Pressure in. HG (abs) 63.8 50.7 33.1
Inlet Manifold Temperature (10) °F 111 108 107
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 853 847 871
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5627 4409 2860
Exhaust Gas Mass Flow (Wet) lb/hr 9746 7667 4887
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
AIR INLET TEMP.
120 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.77 0.75 0.72 0.69
110 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
100 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
90 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
80 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74
70 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78 0.75
60 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.28 1.34 1.39 1.44 1.50 1.52 1.52 1.52 1.52 1.52 1.52 1.52 1.52
AIR INLET TEMP.
120 1.22 1.27 1.32 1.37 1.43 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
110 1.15 1.20 1.25 1.30 1.36 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
100 1.08 1.13 1.18 1.23 1.28 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
90 1.01 1.06 1.11 1.16 1.21 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
80 1.00 1.00 1.04 1.09 1.14 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
70 1.00 1.00 1.00 1.02 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
60 1.00 1.00 1.00 1.00 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5131-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
137
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7372 7664 8067
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2144 1685 1070
Air Mass Flow (Wet) lb/hr 9509 7474 4742
Compressor Out Pressure in. HG (abs) 72.9 69.2 49.9
Compressor Out Temperature °F 297 274 196
Inlet Manifold Pressure in. HG (abs) 64.5 51.1 33.2
Inlet Manifold Temperature (10) °F 116 113 112
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 870 864 888
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5786 4533 2941
Exhaust Gas Mass Flow (Wet) lb/hr 9894 7783 4960
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.70 0.68
AIR INLET TEMP.
120 1.00 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.77 0.75 0.72 0.69
110 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
100 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
90 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
80 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74
70 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78 0.75
60 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.78
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.28 1.34 1.39 1.44 1.50 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51
AIR INLET TEMP.
120 1.22 1.27 1.32 1.37 1.43 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
110 1.15 1.20 1.25 1.30 1.35 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
100 1.08 1.13 1.18 1.23 1.28 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
90 1.01 1.06 1.11 1.16 1.21 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
80 1.00 1.00 1.04 1.09 1.14 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
70 1.00 1.00 1.00 1.02 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
60 1.00 1.00 1.00 1.00 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5130-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
139
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7280 7720 8126
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2110 1658 1052
Air Mass Flow (Wet) lb/hr 9355 7353 4665
Compressor Out Pressure in. HG (abs) 72.2 68.6 49.6
Compressor Out Temperature °F 308 279 198
Inlet Manifold Pressure in. HG (abs) 63.8 50.7 33.1
Inlet Manifold Temperature (10) °F 111 108 107
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 853 847 871
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5627 4409 2860
Exhaust Gas Mass Flow (Wet) lb/hr 9746 7667 4887
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
AIR INLET TEMP.
120 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.66
110 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68
100 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69
90 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
80 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
70 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74
(°F) 50 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.27 1.32 1.38 1.43 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
AIR INLET TEMP.
120 1.20 1.26 1.31 1.36 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
110 1.14 1.19 1.24 1.29 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
100 1.07 1.12 1.17 1.22 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
90 1.01 1.06 1.11 1.16 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
80 1.00 1.00 1.04 1.09 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
70 1.00 1.00 1.00 1.02 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5210-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
141
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7372 7664 8067
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2144 1685 1070
Air Mass Flow (Wet) lb/hr 9509 7474 4742
Compressor Out Pressure in. HG (abs) 72.9 69.2 49.9
Compressor Out Temperature °F 307 283 202
Inlet Manifold Pressure in. HG (abs) 64.5 51.1 33.2
Inlet Manifold Temperature (10) °F 116 113 112
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °F 870 864 888
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5786 4533 2941
Exhaust Gas Mass Flow (Wet) lb/hr 9894 7783 4960
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 1.00 0.99 0.95 0.92 0.89 0.85 0.82 0.79 0.76 0.73 0.71 0.68 0.65
AIR INLET TEMP.
120 1.00 1.00 0.97 0.94 0.90 0.87 0.84 0.81 0.78 0.75 0.72 0.69 0.66
110 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68
100 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69
90 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70
80 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.71
70 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73
60 1.00 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74
(°F) 50 1.00 1.00 1.00 1.00 1.00 0.99 0.95 0.92 0.88 0.85 0.82 0.79 0.76
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.27 1.32 1.38 1.43 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
AIR INLET TEMP.
120 1.21 1.26 1.31 1.36 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
110 1.14 1.19 1.24 1.29 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
100 1.07 1.12 1.17 1.22 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
90 1.01 1.06 1.11 1.16 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
80 1.00 1.00 1.04 1.09 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
70 1.00 1.00 1.00 1.02 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5139-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
143
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7162 7397 7857
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2176 1660 1142
Air Mass Flow (Wet) lb/hr 9649 7360 5064
Compressor Out Pressure in. HG (abs) 74.2 59.7 45.6
Compressor Out Temperature °F 293 239 177
Inlet Manifold Pressure in. HG (abs) 71.5 54.1 37.1
Inlet Manifold Temperature (10) °F 134 132 130
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 988 990 980
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6373 4871 3331
Exhaust Gas Mass Flow (Wet) lb/hr 10007 7635 5259
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.36 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
120 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
110 1.19 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
100 1.10 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.02 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1977-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
145
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6913 7192 7735
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2027 1551 1088
Air Mass Flow (Wet) lb/hr 8987 6877 4823
Compressor Out Pressure in. HG (abs) 69.2 57.5 44.4
Compressor Out Temperature °F 275 229 173
Inlet Manifold Pressure in. HG (abs) 67 50.9 35.7
Inlet Manifold Temperature (10) °F 134 132 130
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °F 997 998 991
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5983 4582 3200
Exhaust Gas Mass Flow (Wet) lb/hr 9334 7146 5015
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.40 1.47 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
AIR INLET TEMP.
120 1.30 1.37 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
110 1.21 1.28 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
100 1.11 1.18 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
90 1.02 1.08 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1980-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
147
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7282 7513 8032
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2211 1682 1181
Air Mass Flow (Wet) lb/hr 9806 7458 5238
Compressor Out Pressure in. HG (abs) 76.3 62.4 47.2
Compressor Out Temperature °F 303 251 189
Inlet Manifold Pressure in. HG (abs) 74.2 55.9 38.8
Inlet Manifold Temperature (10) °F 134 132 130
Timing (11) °BTDC 19 19 19
Exhaust Stack Temperature °F 1029 1027 1026
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6662 5063 3553
Exhaust Gas Mass Flow (Wet) lb/hr 10172 7738 5437
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.35 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
120 1.27 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
110 1.18 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
100 1.10 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.02 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1989-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
149
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7055 7320 7852
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2063 1582 1123
Air Mass Flow (Wet) lb/hr 9149 7017 4979
Compressor Out Pressure in. HG (abs) 72 59.5 45.7
Compressor Out Temperature °F 288 240 181
Inlet Manifold Pressure in. HG (abs) 69.4 52.5 36.7
Inlet Manifold Temperature (10) °F 133 132 130
Timing (11) °BTDC 19 19 19
Exhaust Stack Temperature °F 1040 1039 1035
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6271 4805 3402
Exhaust Gas Mass Flow (Wet) lb/hr 9503 7290 5174
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.37 1.44 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
AIR INLET TEMP.
120 1.28 1.35 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36
110 1.20 1.26 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
100 1.11 1.17 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
90 1.02 1.08 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1992-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
151
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6953 7234 7741
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2196 1677 1161
Air Mass Flow (Wet) lb/hr 9737 7436 5147
Compressor Out Pressure in. HG (abs) 70.6 57.8 45
Compressor Out Temperature °F 291 238 177
Inlet Manifold Pressure in. HG (abs) 67.9 52.5 36.8
Inlet Manifold Temperature (10) °F 134 132 130
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 954 964 963
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6275 4831 3343
Exhaust Gas Mass Flow (Wet) lb/hr 10093 7711 5343
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.36 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
AIR INLET TEMP.
120 1.27 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
110 1.19 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
100 1.10 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1953-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
153
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6712 7034 7621
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2045 1575 1103
Air Mass Flow (Wet) lb/hr 9068 6983 4890
Compressor Out Pressure in. HG (abs) 65.9 55.7 43.7
Compressor Out Temperature °F 273 228 172
Inlet Manifold Pressure in. HG (abs) 63.9 49.5 35.4
Inlet Manifold Temperature (10) °F 134 132 130
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 963 972 973
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5889 4567 3205
Exhaust Gas Mass Flow (Wet) lb/hr 9411 7252 5083
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.40 1.47 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
AIR INLET TEMP.
120 1.30 1.37 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
110 1.21 1.28 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
100 1.11 1.18 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
90 1.01 1.08 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1956-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
155
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7070 7347 7913
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2182 1696 1187
Air Mass Flow (Wet) lb/hr 9675 7521 5261
Compressor Out Pressure in. HG (abs) 72.4 60.4 46.4
Compressor Out Temperature °F 302 249 188
Inlet Manifold Pressure in. HG (abs) 70.4 54.1 38.4
Inlet Manifold Temperature (10) °F 134 132 130
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °F 993 1000 1008
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6411 5010 3524
Exhaust Gas Mass Flow (Wet) lb/hr 10030 7800 5460
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.35 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
120 1.26 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
110 1.18 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
100 1.10 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1965-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
157
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6849 7159 7736
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2036 1567 1116
Air Mass Flow (Wet) lb/hr 9027 6947 4946
Compressor Out Pressure in. HG (abs) 68.5 57.6 45
Compressor Out Temperature °F 286 239 181
Inlet Manifold Pressure in. HG (abs) 66 51 36.3
Inlet Manifold Temperature (10) °F 133 132 130
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °F 1004 1011 1017
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6034 4668 3337
Exhaust Gas Mass Flow (Wet) lb/hr 9370 7213 5138
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.37 1.44 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
AIR INLET TEMP.
120 1.28 1.35 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36
110 1.19 1.26 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
100 1.10 1.17 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
90 1.01 1.08 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1968-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
159
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6728 7074 7590
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2248 1701 1197
Air Mass Flow (Wet) lb/hr 9967 7541 5309
Compressor Out Pressure in. HG (abs) 71.5 58.3 45.6
Compressor Out Temperature °F 294 239 180
Inlet Manifold Pressure in. HG (abs) 67.9 52.7 37.3
Inlet Manifold Temperature (10) °F 100 94 91
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 919 934 934
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6267 4794 3377
Exhaust Gas Mass Flow (Wet) lb/hr 10330 7821 5509
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.29 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
AIR INLET TEMP.
120 1.22 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
110 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
100 1.08 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
90 1.01 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1952-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
161
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6557 6813 7354
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2139 1653 1139
Air Mass Flow (Wet) lb/hr 9486 7328 5051
Compressor Out Pressure in. HG (abs) 67 56.2 43.9
Compressor Out Temperature °F 276 228 172
Inlet Manifold Pressure in. HG (abs) 64.2 49.9 35.3
Inlet Manifold Temperature (10) °F 99 93 91
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 925 934 941
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5994 4663 3234
Exhaust Gas Mass Flow (Wet) lb/hr 9842 7606 5248
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.32 1.37 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
120 1.24 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
110 1.16 1.22 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
100 1.09 1.14 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
90 1.01 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1955-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
163
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6923 7111 7601
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2325 1775 1235
Air Mass Flow (Wet) lb/hr 10311 7871 5477
Compressor Out Pressure in. HG (abs) 72.4 60.4 46.2
Compressor Out Temperature °F 305 252 190
Inlet Manifold Pressure in. HG (abs) 70.8 54.2 38.2
Inlet Manifold Temperature (10) °F 100 94 91
Timing (11) °BTDC 21 21 21
Exhaust Stack Temperature °F 957 966 972
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6661 5119 3577
Exhaust Gas Mass Flow (Wet) lb/hr 10686 8160 5681
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
120 1.22 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
110 1.15 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
100 1.08 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
90 1.01 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1964-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
165
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) btu/bhp-hr 6705 6957 7441
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2181 1677 1183
Air Mass Flow (Wet) lb/hr 9671 7435 5245
Compressor Out Pressure in. HG (abs) 69.1 58 45
Compressor Out Temperature °F 288 240 182
Inlet Manifold Pressure in. HG (abs) 66.8 51.5 36.4
Inlet Manifold Temperature (10) °F 99 92 91
Timing (11) °BTDC 21 21 21
Exhaust Stack Temperature °F 964 973 979
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6286 4865 3446
Exhaust Gas Mass Flow (Wet) lb/hr 10034 7717 5446
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.30 1.36 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
AIR INLET TEMP.
120 1.23 1.28 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
110 1.16 1.21 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
100 1.08 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1967-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
167
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6728 7074 7590
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2248 1701 1197
Air Mass Flow (Wet) lb/hr 9967 7541 5309
Compressor Out Pressure in. HG (abs) 71.5 58.3 45.6
Compressor Out Temperature °F 294 239 180
Inlet Manifold Pressure in. HG (abs) 67.9 52.7 37.3
Inlet Manifold Temperature (10) °F 100 94 91
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 919 934 934
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6267 4794 3377
Exhaust Gas Mass Flow (Wet) lb/hr 10330 7821 5509
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.29 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
AIR INLET TEMP.
120 1.22 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
110 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
100 1.08 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
90 1.01 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1954-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
169
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 210 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6557 6813 7354
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2139 1653 1139
Air Mass Flow (Wet) lb/hr 9486 7328 5051
Compressor Out Pressure in. HG (abs) 67 56.2 43.9
Compressor Out Temperature °F 276 228 172
Inlet Manifold Pressure in. HG (abs) 64.2 49.9 35.3
Inlet Manifold Temperature (10) °F 99 93 91
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °F 925 934 941
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 5994 4663 3234
Exhaust Gas Mass Flow (Wet) lb/hr 9842 7606 5248
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.32 1.37 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
120 1.24 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
110 1.16 1.22 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
100 1.09 1.14 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
90 1.01 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1957-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
171
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 657
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6923 7111 7601
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2325 1775 1235
Air Mass Flow (Wet) lb/hr 10311 7871 5477
Compressor Out Pressure in. HG (abs) 72.4 60.4 46.2
Compressor Out Temperature °F 305 252 190
Inlet Manifold Pressure in. HG (abs) 70.8 54.2 38.2
Inlet Manifold Temperature (10) °F 100 94 91
Timing (11) °BTDC 21 21 21
Exhaust Stack Temperature °F 957 966 972
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6661 5119 3577
Exhaust Gas Mass Flow (Wet) lb/hr 10686 8160 5681
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.93 0.90 0.87 0.84 0.80 0.78 0.75 0.72 0.69 0.67 0.64 0.62 0.59
AIR INLET TEMP.
120 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
110 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
100 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
90 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
80 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
70 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
60 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67
(°F) 50 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
120 1.22 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
110 1.15 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
100 1.08 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
90 1.01 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1966-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
173
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°F) 260 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (psig) 1.5
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (ft) 1149
at 77°F Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6705 6957 7441
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 2181 1677 1183
Air Mass Flow (Wet) lb/hr 9671 7435 5245
Compressor Out Pressure in. HG (abs) 69.1 58 45
Compressor Out Temperature °F 288 240 182
Inlet Manifold Pressure in. HG (abs) 66.8 51.5 36.4
Inlet Manifold Temperature (10) °F 99 92 91
Timing (11) °BTDC 21 21 21
Exhaust Stack Temperature °F 964 973 979
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 6286 4865 3446
Exhaust Gas Mass Flow (Wet) lb/hr 10034 7717 5446
G3512
Noise - Exhaust @ 1.5 m 111 dBA
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.30 1.36 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37 1.37
AIR INLET TEMP.
120 1.23 1.28 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
110 1.16 1.21 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
100 1.08 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
90 1.01 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM1969-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
175
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7406 7854 8739
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 850 649 467
Air Mass Flow (Wet) lb/hr 3770 2875 2068
Compressor Out Pressure in. HG (abs) 60.9 53.6 43.4
Compressor Out Temperature °F 252 228 172
Inlet Manifold Pressure in. HG (abs) 58.9 48.3 35.9
Inlet Manifold Temperature (10) °F 136 138 136
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 862 810 757
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 2312 1697 1173
Exhaust Gas Mass Flow (Wet) lb/hr 3977 3039 2190
G3508
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.44 1.52 1.60 1.69 1.77 1.86 1.86 1.86 1.86 1.86 1.86 1.86 1.86
AIR INLET TEMP.
120 1.33 1.41 1.49 1.58 1.66 1.75 1.75 1.75 1.75 1.75 1.75 1.75 1.75
110 1.23 1.31 1.39 1.47 1.55 1.63 1.63 1.63 1.63 1.63 1.63 1.63 1.63
100 1.12 1.20 1.28 1.36 1.44 1.52 1.52 1.52 1.52 1.52 1.52 1.52 1.52
90 1.02 1.09 1.17 1.25 1.33 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
80 1.00 1.00 1.06 1.14 1.22 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
70 1.00 1.00 1.00 1.03 1.11 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
60 1.00 1.00 1.00 1.00 1.00 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5205-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
177
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7605 8056 9056
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 766 571 440
Air Mass Flow (Wet) lb/hr 3396 2531 1949
Compressor Out Pressure in. HG (abs) 56.1 53 43.9
Compressor Out Temperature °F 233 222 175
Inlet Manifold Pressure in. HG (abs) 55 44.8 34.7
Inlet Manifold Temperature (10) °F 133 133 136
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 914 833 768
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 2179 1535 1121
Exhaust Gas Mass Flow (Wet) lb/hr 3606 2699 2075
G3508
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.46 1.55 1.64 1.73 1.82 1.91 1.91 1.91 1.91 1.91 1.91 1.91 1.91
AIR INLET TEMP.
120 1.35 1.44 1.52 1.61 1.70 1.79 1.79 1.79 1.79 1.79 1.79 1.79 1.79
110 1.24 1.32 1.41 1.50 1.58 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68
100 1.13 1.21 1.29 1.38 1.47 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56
90 1.02 1.10 1.18 1.26 1.35 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
80 1.00 1.00 1.06 1.15 1.23 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
70 1.00 1.00 1.00 1.03 1.11 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5105-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
179
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7406 7854 8739
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 850 649 467
Air Mass Flow (Wet) lb/hr 3770 2875 2068
Compressor Out Pressure in. HG (abs) 60.9 53.6 43.4
Compressor Out Temperature °F 252 228 172
Inlet Manifold Pressure in. HG (abs) 58.9 48.3 35.9
Inlet Manifold Temperature (10) °F 136 138 136
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 862 810 757
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 2312 1697 1173
Exhaust Gas Mass Flow (Wet) lb/hr 3977 3039 2190
G3508
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.44 1.52 1.60 1.69 1.77 1.86 1.86 1.86 1.86 1.86 1.86 1.86 1.86
AIR INLET TEMP.
120 1.33 1.41 1.49 1.58 1.66 1.75 1.75 1.75 1.75 1.75 1.75 1.75 1.75
110 1.23 1.31 1.39 1.47 1.55 1.63 1.63 1.63 1.63 1.63 1.63 1.63 1.63
100 1.12 1.20 1.28 1.36 1.44 1.52 1.52 1.52 1.52 1.52 1.52 1.52 1.52
90 1.02 1.09 1.17 1.25 1.33 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
80 1.00 1.00 1.06 1.14 1.22 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
70 1.00 1.00 1.00 1.03 1.11 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
60 1.00 1.00 1.00 1.00 1.00 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5107-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
181
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 7605 8056 9056
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 766 571 440
Air Mass Flow (Wet) lb/hr 3396 2531 1949
Compressor Out Pressure in. HG (abs) 56.1 53 43.9
Compressor Out Temperature °F 233 222 175
Inlet Manifold Pressure in. HG (abs) 55 44.8 34.7
Inlet Manifold Temperature (10) °F 133 133 136
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °F 914 833 768
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 2179 1535 1121
Exhaust Gas Mass Flow (Wet) lb/hr 3606 2699 2075
G3508
130 1.00 1.00 1.00 0.98 0.94 0.91 0.88 0.84 0.81 0.78 0.75 0.72 0.70
AIR INLET TEMP.
120 1.00 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71
110 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75 0.72
100 1.00 1.00 1.00 1.00 1.00 0.96 0.92 0.89 0.86 0.82 0.79 0.76 0.73
90 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.91 0.87 0.84 0.81 0.78 0.75
80 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79 0.76
70 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.81 0.77
60 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.92 0.89 0.85 0.82 0.79
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.94 0.90 0.87 0.84 0.80
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.46 1.55 1.64 1.73 1.82 1.91 1.91 1.91 1.91 1.91 1.91 1.91 1.91
AIR INLET TEMP.
120 1.35 1.44 1.52 1.61 1.70 1.79 1.79 1.79 1.79 1.79 1.79 1.79 1.79
110 1.24 1.32 1.41 1.50 1.58 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68
100 1.13 1.21 1.29 1.38 1.47 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56
90 1.02 1.10 1.18 1.26 1.35 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
80 1.00 1.00 1.06 1.15 1.23 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
70 1.00 1.00 1.00 1.03 1.11 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
60 1.00 1.00 1.00 1.00 1.00 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5106-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
183
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6911 7231 7755
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1444 1103 765
Air Mass Flow (Wet) lb/hr 6404 4892 3392
Compressor Out Pressure in. HG (abs) 72.7 62.4 46.9
Compressor Out Temperature °F 305 259 191
Inlet Manifold Pressure in. HG (abs) 67.2 51.8 37
Inlet Manifold Temperature (10) °F 141 138 134
Timing (11) °BTDC 16 16 16
Exhaust Stack Temperature °F 918 948 970
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 4017 3139 2213
Exhaust Gas Mass Flow (Wet) lb/hr 6630 5068 3518
G3508
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.70 1.83 1.85 1.85 1.85 1.85 1.85 1.85 1.85 1.85 1.85 1.85 1.85
AIR INLET TEMP.
120 1.53 1.66 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68
110 1.36 1.49 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51
100 1.19 1.32 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
90 1.02 1.15 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5231-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
185
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6747 7063 7639
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1360 1042 729
Air Mass Flow (Wet) lb/hr 6030 4622 3233
Compressor Out Pressure in. HG (abs) 68.4 59.9 45.6
Compressor Out Temperature °F 290 251 187
Inlet Manifold Pressure in. HG (abs) 63.5 49.4 35.7
Inlet Manifold Temperature (10) °F 141 138 134
Timing (11) °BTDC 16 16 16
Exhaust Stack Temperature °F 932 959 986
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3827 2992 2135
Exhaust Gas Mass Flow (Wet) lb/hr 6251 4793 3356
G3508
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.76 1.90 1.99 1.99 1.99 1.99 1.99 1.99 1.99 1.99 1.99 1.99 1.99
AIR INLET TEMP.
120 1.57 1.71 1.81 1.81 1.81 1.81 1.81 1.81 1.81 1.81 1.81 1.81 1.81
110 1.39 1.53 1.62 1.62 1.62 1.62 1.62 1.62 1.62 1.62 1.62 1.62 1.62
100 1.21 1.34 1.43 1.43 1.43 1.43 1.43 1.43 1.43 1.43 1.43 1.43 1.43
90 1.02 1.16 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
80 1.00 1.00 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5232-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
187
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6668 6935 7438
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1505 1147 800
Air Mass Flow (Wet) lb/hr 6674 5086 3546
Compressor Out Pressure in. HG (abs) 73.6 62.6 47.4
Compressor Out Temperature °F 308 255 189
Inlet Manifold Pressure in. HG (abs) 67.8 52.1 37.3
Inlet Manifold Temperature (10) °F 105 100 94
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 847 876 889
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3972 3095 2180
Exhaust Gas Mass Flow (Wet) lb/hr 6907 5266 3674
G3508
130 0.95 0.92 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.63 0.60
AIR INLET TEMP.
120 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.74 0.72 0.69 0.66 0.64 0.61
110 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
100 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
90 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
80 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
70 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
60 1.00 1.00 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.68
(°F) 50 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.78 0.75 0.73 0.70
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.57 1.67 1.69 1.69 1.69 1.69 1.69 1.69 1.69 1.69 1.69 1.69 1.69
AIR INLET TEMP.
120 1.43 1.54 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55 1.55
110 1.29 1.40 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
100 1.16 1.26 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
90 1.02 1.12 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
80 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5233-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
189
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) Btu/bhp-hr 6480 6790 7278
G3508
Air Flow (Wet, @ 77°F, 28.8 in Hg) SCFM 1431 1095 760
Air Mass Flow (Wet) lb/hr 6344 4855 3371
Compressor Out Pressure in. HG (abs) 70 60.4 45.8
Compressor Out Temperature °F 291 246 182
Inlet Manifold Pressure in. HG (abs) 64.6 50 35.7
Inlet Manifold Temperature (10) °F 105 100 94
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °F 847 887 896
Exhaust Gas Flow (Wet, @ stack temperature, 29.7 in Hg) CFM 3778 2981 2085
Exhaust Gas Mass Flow (Wet) lb/hr 6570 5031 3497
G3508
130 0.97 0.93 0.90 0.87 0.83 0.80 0.77 0.75 0.72 0.69 0.66 0.64 0.61
AIR INLET TEMP.
120 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.68 0.65 0.62
110 1.00 0.96 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66 0.64
100 1.00 0.98 0.95 0.91 0.88 0.85 0.82 0.79 0.76 0.73 0.70 0.67 0.65
90 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.69 0.66
80 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.73 0.70 0.67
70 1.00 1.00 1.00 0.96 0.93 0.89 0.86 0.83 0.80 0.77 0.74 0.71 0.68
60 1.00 1.00 1.00 0.98 0.95 0.91 0.88 0.85 0.81 0.78 0.75 0.72 0.70
(°F) 50 1.00 1.00 1.00 1.00 0.97 0.93 0.90 0.86 0.83 0.80 0.77 0.74 0.71
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
130 1.61 1.72 1.79 1.79 1.79 1.79 1.79 1.79 1.79 1.79 1.79 1.79 1.79
AIR INLET TEMP.
120 1.46 1.57 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64 1.64
110 1.31 1.42 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49
100 1.17 1.27 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
90 1.02 1.13 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
80 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
70 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
60 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°F) 50 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 1000 2000 3000 4000 5000 6000 7000 8000 9000 10000 11000 12000
ALTITUDE (FEET ABOVE SEA LEVEL)
DM5234-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
191
Notes
192
Metric
Units
Section
193
194
G35
G3516 High Speed Jacket
Jacket Water
Water System
System Performance
Performance TM
TM9732-00
m of
H2O
16
15
14
13
12
External Restriction
11
10
2
B A
1
0
700 800 900 1000 1100 1200 1300 1400 1500 1600 1700 1800 1900 2000 L/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9729 JW Pump
L/min -----------------------Meter of Water ---------------------
800 10.8 Drive Ratio 1.33:1
900 8.9
1000 7.0 For high speed (1301 - 1800 rpm) ratings
1100 14.5 5.1
1200 12.3 3.3
1300 10.1 1.4 Curves indicate maximum allowable external resistance.
1400 7.9 Do not project curves.
1500 5.7
1600 3.5
1700 1.2
195
G35
G3516 Low Speed Jacket
Jacket Water
Water System
System Performance
Performance TM
TM9733-00
m of
H2O
16
15
14
13
12
External Restriction
11
10
2
B A
1
0
700 800 900 1000 1100 1200 1300 1400 1500 1600 1700 1800 1900 2000 L/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9729 JW Pump
L/min -----------------------Meter of Water ---------------------
900 8.9 Drive Ratio 2:1
1000 7.0
1100 14.5 5.1 For low speed (1300 rpm and below) ratings
1200 12.3 3.3
1300 10.1 1.4
1400 7.9 Curves indicate maximum allowable external resistance.
1500 5.7 Do not project curves.
1600 3.5
1700 1.2
196
G35
G3512 High Speed Jacket
Jacket Water
Water System
System Performance
Performance TM
DM0569-00
m of
H2O
16
15
14
13
12
External Restriction
11
10
1
B A
0
600 800 1000 1200 1400 1600 1800 2000 L/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9729 JW Pump
L/min -----------------------Meter of Water ---------------------
500 12.9 Drive Ratio 1.33:1
600 16.7 11.4
700 15.2 9.9 For high speed (1301-1800 rpm) ratings
800 13.6 8.4
900 12.0 6.9
1000 10.5 5.4 Curves indicate maximum allowable external resistance.
1100 8.9 3.9 Do not project curves.
1200 7.3 2.5
1300 5.8 1.0
1400 4.2
1500 2.6
1600 1.1
197
G35
G3512 Low Speed Jacket
Jacket Water
Water System
System Performance
Performance TM
DM0570-00
ft of
H2O
60
55
50
45
40
External Restriction
35
30
25
20
15
10
5
A
B
0
80 100 120 140 160 180 200 220 240 260 280 300 320 340 360 380 400 420 440 g/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 1W9954 AW Pump
Pump Speed rpm 2400 2000
Drive Ratio 2:1
External Flow -----------------------External Resistance--------------
L/min -----------------------Meter of Water --------------------- For low speed (1300 rpm and below) ratings
500 9.2
600 14.5 7.8
700 13.0 6.4 Curves indicate maximum allowable external resistance.
800 11.5 5.0 Do not project curves.
900 10.0 3.7
1000 8.6 2.3
1100 7.1 0.9
1200 5.6
1300 4.1
1400 2.6
1500 1.2
198
G35
G3508 High Speed Jacket
Jacket Water
Water System
System Performance
Performance TM
TM3095-03
m of
H2O
External Restriction
11
10
1 B
A
0
500 600 700 800 900 1000 1100 1200 1300 1400 1500 L/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9726 JW Pump
L/min -----------------------Meter of Water ---------------------
600 10.6 Drive Ratio 1.33 to 1
700 8.8
800 6.9 For high speed (1301-1800 rpm) ratings
900 11.4 5.1
1000 9.3 3.3
1100 7.1 1.5 Curves indicate maximum allowable external resistance.
1200 4.9 Do not project curves.
1300 2.7
1320 2.3
1360 1.4
1400 0.5
199
G35
G3508 Low Speed Jacket
Jacket Water
Water System
System Performance
Performance TM
TM3089-03
m of
H2O
External Restriction
11
10
2
B
1
A
0
500 600 700 800 900 1000 1100 1200 1300 1400 1500 L/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 Engine equipped with water cooled exhaust manifolds or with dry
Pump Speed rpm 2400 2000 exhaust manifolds and JW aftercooler.
External Flow -----------------------External Resistance-------------- 2W9726 JW Pump
L/min -----------------------Meter of Water ---------------------
700 8.7 Drive Ratio 2.0 to 1
800 6.9
900 11.4 5.1 For low speed (1300 rpm and below) ratings
1000 9.3 3.3
1100 7.1 1.5
1200 4.9 Curves indicate maximum allowable external resistance.
1300 2.7 Do not project curves.
1400 0.6
200
G35
G3500 High Speed Auxiliary
Auxiliary Water
Water System
System Performance
Performance TM
DM0571-00
m of
H2O
8
External Restriction
3
A
B
1
0
200 250 300 350 400 450 500 550 600 L/min
Curve Data
Curve Label A B
Engine Speed rpm 1800 1500 1W9954 AW Pump
Pump Speed rpm 2400 2000
Drive Ratio 1.33:1
External Flow -----------------------External Resistance--------------
L/min -----------------------Meter of Water --------------------- For high speed (1301-1800 rpm) ratings
300 6.2
320 5.2
340 4.3 Curves indicate maximum allowable external resistance.
350 3.8 Do not project curves.
360 8.9 3.3
370 8.4 2.8
380 7.8 2.4
390 7.3 1.9
400 6.8 1.4
410 6.2
420 5.7
430 5.2
440 4.6
450 4.1
460 3.5
470 3.0
201
G35 Auxiliary Water System Performance TM
G3500 Low Speed Auxiliary Water System Performance DM0572-00
m of
H2O
10
9
External Restriction
4
A
3
B
1
0
150 200 250 300 350 400 450 500 550 L/min
Curve Data
Curve Label A B
Engine Speed rpm 1200 1000 1W9954 AW Pump
Pump Speed rpm 2400 2000
Drive Ratio 2:1
External Flow -----------------------External Resistance--------------
L/min -----------------------Meter of Water --------------------- For low speed (1300 rpm and below) ratings
300 6.2
320 5.2
330 4.8 Curves indicate maximum allowable external resistance.
350 3.8 Do not project curves.
360 8.9 3.3
370 8.4 2.8
390 7.3 1.9
400 6.8 1.4
420 5.7
430 5.2
450 4.1
460 3.5
470 3.0
202
G3516 Jacket Water Flow vs Pressure Drop
Across Block for Cogen Engine
120
110 Max
Pressure Drop Across Block
100
90
(kPa)
80
70
60
50
Min
40
30
1300 1400 1500 1600 1700 1800 1900 2000 2100
Jacket Water Flow
(liters/min)
100 Max
90
(kPa)
80
70
60
50
40 Min
30
950 1050 1150 1250 1350 1450 1550 1650 1750 1850 1950
Jacket Water Flow
(liters/min)
203
G3508 Jacket Water Flow vs Pressure Drop
Across Block for Cogen Engine
100
90
Pressure Drop Across Block
Max
80
70
(kPa)
60
50
40
30
20
Min
10
500 600 700 800 900 1000 1100 1200 1300 1400 1500
Jacket Water Flow
(liters/min)
204
Notes
205
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.63 11.19 12.28
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 3.09 3.29 3.82
Air Mass Flow (Wet) kg/bkW-hr 3.99 4.25 4.94
Compressor Out Pressure KPAa 208 200 177
Compressor Out Temperature °C 131 115 94
Inlet Manifold Pressure KPAa 199 168 135
Inlet Manifold Temperature (10) °C 57 56 56
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 462 449 423
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 3.37 3.59 4.17
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 4.21 4.49 5.22
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.31 1.37 1.43 1.49 1.56 1.62 1.69 1.69 1.69 1.69 1.69 1.69 1.69
AIR INLET TEMP.
45 1.22 1.28 1.34 1.41 1.47 1.53 1.60 1.60 1.60 1.60 1.60 1.60 1.60
40 1.14 1.20 1.26 1.32 1.38 1.44 1.51 1.52 1.52 1.52 1.52 1.52 1.52
35 1.05 1.11 1.17 1.23 1.29 1.36 1.42 1.43 1.43 1.43 1.43 1.43 1.43
30 1.00 1.03 1.09 1.15 1.21 1.27 1.33 1.34 1.34 1.34 1.34 1.34 1.34
25 1.00 1.00 1.00 1.06 1.12 1.18 1.24 1.25 1.25 1.25 1.25 1.25 1.25
20 1.00 1.00 1.00 1.00 1.03 1.09 1.15 1.16 1.16 1.16 1.16 1.16 1.16
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5144-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
207
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.9 11.43 13.01
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 2.71 2.77 2.91
Air Mass Flow (Wet) kg/bkW-hr 3.5 3.58 3.76
Compressor Out Pressure KPAa 206 196 177
Compressor Out Temperature °C 125 114 98
Inlet Manifold Pressure KPAa 185 156 131
Inlet Manifold Temperature (10) °C 56 56 55
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 489 457 419
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 2.99 3.06 3.22
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 3.73 3.82 4.02
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.35 1.41 1.48 1.55 1.62 1.69 1.77 1.77 1.77 1.77 1.77 1.77 1.77
AIR INLET TEMP.
45 1.25 1.32 1.39 1.45 1.52 1.59 1.67 1.67 1.67 1.67 1.67 1.67 1.67
40 1.16 1.22 1.29 1.36 1.43 1.49 1.56 1.57 1.57 1.57 1.57 1.57 1.57
35 1.06 1.13 1.19 1.26 1.33 1.39 1.46 1.47 1.47 1.47 1.47 1.47 1.47
30 1.00 1.03 1.10 1.16 1.23 1.30 1.36 1.37 1.37 1.37 1.37 1.37 1.37
25 1.00 1.00 1.00 1.07 1.13 1.20 1.26 1.27 1.27 1.27 1.27 1.27 1.27
20 1.00 1.00 1.00 1.00 1.03 1.10 1.16 1.17 1.17 1.17 1.17 1.17 1.17
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5143-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
209
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.63 11.19 12.28
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 3.09 3.29 3.82
Air Mass Flow (Wet) kg/bkW-hr 3.99 4.25 4.94
Compressor Out Pressure KPAa 208 200 177
Compressor Out Temperature °C 131 115 94
Inlet Manifold Pressure KPAa 199 168 135
Inlet Manifold Temperature (10) °C 57 56 56
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 462 449 423
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 3.37 3.59 4.17
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 4.21 4.49 5.22
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.31 1.37 1.43 1.49 1.56 1.62 1.69 1.69 1.69 1.69 1.69 1.69 1.69
AIR INLET TEMP.
45 1.22 1.28 1.34 1.41 1.47 1.53 1.60 1.60 1.60 1.60 1.60 1.60 1.60
40 1.14 1.20 1.26 1.32 1.38 1.44 1.51 1.52 1.52 1.52 1.52 1.52 1.52
35 1.05 1.11 1.17 1.23 1.29 1.36 1.42 1.43 1.43 1.43 1.43 1.43 1.43
30 1.00 1.03 1.09 1.15 1.21 1.27 1.33 1.34 1.34 1.34 1.34 1.34 1.34
25 1.00 1.00 1.00 1.06 1.12 1.18 1.24 1.25 1.25 1.25 1.25 1.25 1.25
20 1.00 1.00 1.00 1.00 1.03 1.09 1.15 1.16 1.16 1.16 1.16 1.16 1.16
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5146-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
211
®
G3516 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.9 11.43 13.01
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 2.71 2.77 2.91
Air Mass Flow (Wet) kg/bkW-hr 3.5 3.58 3.76
Compressor Out Pressure KPAa 206 196 177
Compressor Out Temperature °C 125 114 98
Inlet Manifold Pressure KPAa 185 156 131
Inlet Manifold Temperature (10) °C 56 56 55
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 489 457 419
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 2.97 3.04 3.19
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 3.72 3.8 3.99
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.35 1.41 1.48 1.55 1.62 1.69 1.77 1.77 1.77 1.77 1.77 1.77 1.77
AIR INLET TEMP.
45 1.25 1.32 1.39 1.45 1.52 1.59 1.67 1.67 1.67 1.67 1.67 1.67 1.67
40 1.16 1.22 1.29 1.36 1.43 1.49 1.56 1.57 1.57 1.57 1.57 1.57 1.57
35 1.06 1.13 1.19 1.26 1.33 1.39 1.46 1.47 1.47 1.47 1.47 1.47 1.47
30 1.00 1.03 1.10 1.16 1.23 1.30 1.36 1.37 1.37 1.37 1.37 1.37 1.37
25 1.00 1.00 1.00 1.07 1.13 1.20 1.26 1.27 1.27 1.27 1.27 1.27 1.27
20 1.00 1.00 1.00 1.00 1.03 1.10 1.16 1.17 1.17 1.17 1.17 1.17 1.17
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5145-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
213
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.38 10.67 11.47
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.36 4.31 3.82
Air Mass Flow (Wet) kg/bkW-hr 5.63 5.57 4.93
Compressor Out Pressure KPAa 234 217 155
Compressor Out Temperature °C 142 129 82
Inlet Manifold Pressure KPAa 211 162 102
Inlet Manifold Temperature (10) °C 58 57 59
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °C 450 438 461
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.68 4.64 4.14
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.86 5.8 5.18
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.29 1.35 1.40 1.46 1.51 1.57 1.63 1.63 1.63 1.63 1.63 1.63 1.63
AIR INLET TEMP.
45 1.21 1.27 1.32 1.38 1.43 1.49 1.54 1.55 1.55 1.55 1.55 1.55 1.55
40 1.14 1.19 1.24 1.30 1.35 1.41 1.46 1.47 1.47 1.47 1.47 1.47 1.47
35 1.06 1.11 1.16 1.21 1.27 1.32 1.38 1.38 1.38 1.38 1.38 1.38 1.38
30 1.00 1.03 1.08 1.13 1.19 1.24 1.29 1.30 1.30 1.30 1.30 1.30 1.30
25 1.00 1.00 1.00 1.05 1.10 1.16 1.21 1.22 1.22 1.22 1.22 1.22 1.22
20 1.00 1.00 1.00 1.00 1.02 1.07 1.13 1.13 1.13 1.13 1.13 1.13 1.13
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.05 1.05 1.05 1.05 1.05 1.05
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5148-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
215
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.85 10.1 11.01
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.27 3.97 4.09
Air Mass Flow (Wet) kg/bkW-hr 5.51 5.13 5.29
Compressor Out Pressure KPAa 233 198 150
Compressor Out Temperature °C 153 124 85
Inlet Manifold Pressure KPAa 207 149 104
Inlet Manifold Temperature (10) °C 62 60 59
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 416 433 434
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.58 4.28 4.42
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.72 5.35 5.52
G3516
50 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.73
AIR INLET TEMP.
45 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76 0.74
40 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75
35 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76
30 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
25 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79
20 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80
15 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.27 1.33 1.39 1.44 1.50 1.52 1.52 1.52 1.52 1.52 1.52 1.52 1.52
AIR INLET TEMP.
45 1.20 1.25 1.31 1.37 1.42 1.44 1.44 1.44 1.44 1.44 1.44 1.44 1.44
40 1.12 1.18 1.23 1.29 1.34 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36
35 1.05 1.10 1.15 1.21 1.26 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
30 1.00 1.03 1.08 1.13 1.19 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
25 1.00 1.00 1.00 1.05 1.11 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
20 1.00 1.00 1.00 1.00 1.03 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5147-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
217
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.9 10.15 11.07
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.19 3.9 4.02
Air Mass Flow (Wet) kg/bkW-hr 5.41 5.04 5.19
Compressor Out Pressure KPAa 226 193 147
Compressor Out Temperature °C 134 108 74
Inlet Manifold Pressure KPAa 198 145 104
Inlet Manifold Temperature (10) °C 62 60 59
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 416 433 434
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.49 4.2 4.33
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.61 5.25 5.42
G3516
50 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
AIR INLET TEMP.
45 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
40 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
35 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
30 1.00 1.00 1.00 0.98 0.96 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75
25 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76
20 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77
15 1.00 1.00 1.00 1.00 1.00 0.97 0.95 0.92 0.89 0.86 0.84 0.81 0.78
(°C) 10 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.33 1.39 1.45 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51
AIR INLET TEMP.
45 1.24 1.30 1.36 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42
40 1.15 1.21 1.27 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
35 1.07 1.12 1.18 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
30 1.00 1.03 1.09 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
25 1.00 1.00 1.00 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5149-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
219
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.57 10.79 11.26
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.23 4.22 4.11
Air Mass Flow (Wet) kg/bkW-hr 5.47 5.45 5.31
Compressor Out Pressure KPAa 234 204 151
Compressor Out Temperature °C 139 118 77
Inlet Manifold Pressure KPAa 215 167 116
Inlet Manifold Temperature (10) °C 47 44 41
Timing (11) °BTDC 35 35 35
Exhaust Stack Temperature °C 453 453 452
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.55 4.54 4.43
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.69 5.68 5.54
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.81 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.26 1.31 1.35 1.40 1.45 1.50 1.55 1.55 1.55 1.55 1.55 1.55 1.55
AIR INLET TEMP.
45 1.19 1.24 1.28 1.33 1.38 1.43 1.48 1.48 1.48 1.48 1.48 1.48 1.48
40 1.12 1.17 1.21 1.26 1.31 1.36 1.41 1.41 1.41 1.41 1.41 1.41 1.41
35 1.05 1.10 1.14 1.19 1.24 1.28 1.33 1.33 1.33 1.33 1.33 1.33 1.33
30 1.00 1.03 1.07 1.12 1.16 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26
25 1.00 1.00 1.00 1.05 1.09 1.14 1.18 1.18 1.18 1.18 1.18 1.18 1.18
20 1.00 1.00 1.00 1.00 1.02 1.06 1.11 1.11 1.11 1.11 1.11 1.11 1.11
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5151-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
221
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.97 10.07 10.77
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.21 3.96 4.07
Air Mass Flow (Wet) kg/bkW-hr 5.44 5.11 5.25
Compressor Out Pressure KPAa 235 193 153
Compressor Out Temperature °C 154 129 89
Inlet Manifold Pressure KPAa 217 158 110
Inlet Manifold Temperature (10) °C 47 44 43
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 410 422 425
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.52 4.26 4.38
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.65 5.33 5.48
G3516
50 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.73
AIR INLET TEMP.
45 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76 0.74
40 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75
35 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76
30 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
25 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79
20 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80
15 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.27 1.32 1.37 1.42 1.43 1.43 1.43 1.43 1.43 1.43 1.43 1.43
AIR INLET TEMP.
45 1.17 1.21 1.26 1.30 1.35 1.36 1.36 1.36 1.36 1.36 1.36 1.36 1.36
40 1.10 1.15 1.19 1.24 1.28 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
35 1.04 1.08 1.13 1.17 1.22 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
30 1.00 1.02 1.06 1.11 1.15 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
25 1.00 1.00 1.00 1.04 1.09 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
20 1.00 1.00 1.00 1.00 1.02 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5150-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
223
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.03 10.13 10.83
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.13 3.88 3.99
Air Mass Flow (Wet) kg/bkW-hr 5.34 5.02 5.15
Compressor Out Pressure KPAa 228 188 150
Compressor Out Temperature °C 135 113 77
Inlet Manifold Pressure KPAa 207 153 109
Inlet Manifold Temperature (10) °C 47 44 43
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 410 422 425
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.44 4.18 4.3
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.55 5.23 5.38
G3516
50 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
AIR INLET TEMP.
45 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
40 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
35 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
30 1.00 1.00 1.00 0.98 0.96 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75
25 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76
20 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77
15 1.00 1.00 1.00 1.00 1.00 0.97 0.95 0.92 0.89 0.86 0.84 0.81 0.78
(°C) 10 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.27 1.31 1.36 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
AIR INLET TEMP.
45 1.20 1.24 1.29 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
40 1.12 1.17 1.22 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
35 1.05 1.10 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
30 1.00 1.03 1.07 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
25 1.00 1.00 1.00 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5152-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
225
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 11.01 11.34 12
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.35 4.31 4.05
Air Mass Flow (Wet) kg/bkW-hr 5.62 5.57 5.24
Compressor Out Pressure KPAa 237 205 153
Compressor Out Temperature °C 152 131 92
Inlet Manifold Pressure KPAa 215 167 120
Inlet Manifold Temperature (10) °C 59 57 54
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 474 472 492
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.68 4.65 4.39
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.85 5.81 5.49
G3516
50 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75 0.73
AIR INLET TEMP.
45 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76 0.74
40 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75
35 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76
30 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
25 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79
20 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80
15 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.26 1.31 1.37 1.42 1.48 1.49 1.49 1.49 1.49 1.49 1.49 1.49 1.49
AIR INLET TEMP.
45 1.19 1.24 1.29 1.35 1.40 1.42 1.42 1.42 1.42 1.42 1.42 1.42 1.42
40 1.12 1.17 1.22 1.27 1.33 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
35 1.05 1.10 1.15 1.20 1.25 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
30 1.00 1.02 1.07 1.12 1.18 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
25 1.00 1.00 1.00 1.05 1.10 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
20 1.00 1.00 1.00 1.00 1.03 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5167-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
227
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 11.17 11.52 12.61
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 3.82 3.48 3.41
Air Mass Flow (Wet) kg/bkW-hr 4.93 4.49 4.4
Compressor Out Pressure KPAa 227 206 155
Compressor Out Temperature °C 143 123 84
Inlet Manifold Pressure KPAa 212 154 106
Inlet Manifold Temperature (10) °C 65 64 65
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 453 463 475
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.45 4.12 4.08
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.57 5.15 5.1
G3516
50 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
AIR INLET TEMP.
45 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
40 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
35 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
30 1.00 1.00 1.00 0.98 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
25 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76
20 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77
15 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.78
(°C) 10 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.29 1.34 1.40 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
45 1.21 1.26 1.32 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
40 1.13 1.18 1.24 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
35 1.05 1.11 1.16 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
30 1.00 1.03 1.08 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
25 1.00 1.00 1.00 1.05 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5153-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
229
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.13 10.43 11.05
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.69 4.76 4.94
Air Mass Flow (Wet) kg/bkW-hr 6.06 6.16 6.39
Compressor Out Pressure KPAa 267 225 166
Compressor Out Temperature °C 153 127 88
Inlet Manifold Pressure KPAa 250 192 133
Inlet Manifold Temperature (10) °C 59 57 55
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 512 515 522
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 5.02 5.1 5.29
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.27 6.37 6.62
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.28 1.33 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35
AIR INLET TEMP.
45 1.21 1.26 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
40 1.13 1.18 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
35 1.06 1.11 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
30 1.00 1.03 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM0988-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
231
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.25 10.5 11.24
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.7 4.71 4.91
Air Mass Flow (Wet) kg/bkW-hr 6.07 6.09 6.35
Compressor Out Pressure KPAa 269 231 168
Compressor Out Temperature °C 158 135 95
Inlet Manifold Pressure KPAa 255 193 133
Inlet Manifold Temperature (10) °C 58 57 55
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 548 550 555
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 5.03 5.05 5.27
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.3 6.31 6.59
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.27 1.31 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
AIR INLET TEMP.
45 1.20 1.24 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.13 1.17 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
35 1.05 1.10 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
30 1.00 1.03 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM0873-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
233
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.79 10.09 10.62
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.4 4.41 4.51
Air Mass Flow (Wet) kg/bkW-hr 5.69 5.7 5.83
Compressor Out Pressure KPAa 263 209 157
Compressor Out Temperature °C 151 119 82
Inlet Manifold Pressure KPAa 237 175 125
Inlet Manifold Temperature (10) °C 61 57 55
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 529 531 537
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.72 4.73 4.84
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.9 5.92 6.06
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.29 1.34 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
45 1.21 1.26 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
40 1.14 1.19 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
35 1.06 1.11 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
30 1.00 1.03 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM0991-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
235
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.86 10.2 10.78
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.45 4.49 4.61
Air Mass Flow (Wet) kg/bkW-hr 5.75 5.8 5.96
Compressor Out Pressure KPAa 258 222 162
Compressor Out Temperature °C 149 127 86
Inlet Manifold Pressure KPAa 240 183 126
Inlet Manifold Temperature (10) °C 57 56 55
Timing (11) °BTDC 19 19 19
Exhaust Stack Temperature °C 556 554 565
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.77 4.81 4.95
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.96 6.02 6.19
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.29 1.34 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
45 1.21 1.26 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
40 1.14 1.18 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
35 1.06 1.11 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
30 1.00 1.03 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM0876-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
237
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.84 10.2 10.88
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.63 4.72 4.91
Air Mass Flow (Wet) kg/bkW-hr 5.98 6.09 6.34
Compressor Out Pressure KPAa 253 218 163
Compressor Out Temperature °C 152 126 87
Inlet Manifold Pressure KPAa 238 186 131
Inlet Manifold Temperature (10) °C 59 57 55
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 494 501 512
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.95 5.04 5.26
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.19 6.31 6.57
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.28 1.33 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35 1.35
AIR INLET TEMP.
45 1.21 1.26 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
40 1.13 1.18 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
35 1.06 1.10 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
30 1.00 1.03 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1228-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
239
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.95 10.27 11.07
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.58 4.66 4.85
Air Mass Flow (Wet) kg/bkW-hr 5.92 6.02 6.27
Compressor Out Pressure KPAa 255 223 165
Compressor Out Temperature °C 157 134 95
Inlet Manifold Pressure KPAa 242 187 132
Inlet Manifold Temperature (10) °C 58 57 55
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 528 535 545
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.9 4.99 5.2
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.13 6.24 6.5
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.27 1.32 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
AIR INLET TEMP.
45 1.19 1.24 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.12 1.17 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
35 1.05 1.10 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12 1.12
30 1.00 1.03 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1240-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
241
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.5 9.87 10.46
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.29 4.33 4.45
Air Mass Flow (Wet) kg/bkW-hr 5.54 5.59 5.75
Compressor Out Pressure KPAa 249 202 154
Compressor Out Temperature °C 150 118 82
Inlet Manifold Pressure KPAa 225 170 123
Inlet Manifold Temperature (10) °C 61 57 55
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 510 517 527
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.6 4.64 4.78
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.75 5.8 5.98
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.29 1.34 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
45 1.21 1.26 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
40 1.13 1.19 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
35 1.06 1.11 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
30 1.00 1.03 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1231-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
243
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.57 9.98 10.62
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.35 4.42 4.58
Air Mass Flow (Wet) kg/bkW-hr 5.61 5.71 5.91
Compressor Out Pressure KPAa 245 215 160
Compressor Out Temperature °C 148 126 86
Inlet Manifold Pressure KPAa 228 178 125
Inlet Manifold Temperature (10) °C 57 56 55
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °C 536 539 555
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.65 4.74 4.91
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.82 5.92 6.14
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.29 1.34 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
45 1.21 1.26 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
40 1.13 1.18 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
35 1.06 1.11 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
30 1.00 1.03 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1243-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
245
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 11.29 11.38 12.15
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.38 4.18 4.37
Air Mass Flow (Wet) kg/bkW-hr 5.66 5.41 5.64
Compressor Out Pressure KPAa 255 226 168
Compressor Out Temperature °C 148 131 92
Inlet Manifold Pressure KPAa 228 170 124
Inlet Manifold Temperature (10) °C 62 59 57
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °C 485 483 483
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.72 4.52 4.72
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.9 5.65 5.9
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.81 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.29 1.34 1.40 1.45 1.50 1.56 1.61 1.61 1.61 1.61 1.61 1.61 1.61
AIR INLET TEMP.
45 1.21 1.27 1.32 1.37 1.42 1.48 1.53 1.53 1.53 1.53 1.53 1.53 1.53
40 1.14 1.19 1.24 1.29 1.34 1.39 1.45 1.45 1.45 1.45 1.45 1.45 1.45
35 1.06 1.11 1.16 1.21 1.26 1.31 1.37 1.37 1.37 1.37 1.37 1.37 1.37
30 1.00 1.03 1.08 1.13 1.18 1.23 1.28 1.28 1.28 1.28 1.28 1.28 1.28
25 1.00 1.00 1.00 1.05 1.10 1.15 1.20 1.20 1.20 1.20 1.20 1.20 1.20
20 1.00 1.00 1.00 1.00 1.02 1.07 1.12 1.12 1.12 1.12 1.12 1.12 1.12
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5156-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
247
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.6 10.84 11.44
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.09 4.06 3.89
Air Mass Flow (Wet) kg/bkW-hr 5.29 5.24 5.02
Compressor Out Pressure KPAa 249 213 156
Compressor Out Temperature °C 157 130 87
Inlet Manifold Pressure KPAa 223 169 114
Inlet Manifold Temperature (10) °C 60 59 59
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 449 451 462
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.41 4.38 4.21
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.51 5.47 5.26
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.81 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.26 1.31 1.36 1.41 1.46 1.51 1.57 1.57 1.57 1.57 1.57 1.57 1.57
AIR INLET TEMP.
45 1.19 1.24 1.29 1.34 1.39 1.44 1.49 1.49 1.49 1.49 1.49 1.49 1.49
40 1.12 1.17 1.21 1.26 1.31 1.37 1.42 1.42 1.42 1.42 1.42 1.42 1.42
35 1.05 1.10 1.14 1.19 1.24 1.29 1.34 1.34 1.34 1.34 1.34 1.34 1.34
30 1.00 1.02 1.07 1.12 1.17 1.22 1.27 1.27 1.27 1.27 1.27 1.27 1.27
25 1.00 1.00 1.00 1.05 1.10 1.14 1.19 1.19 1.19 1.19 1.19 1.19 1.19
20 1.00 1.00 1.00 1.00 1.02 1.07 1.12 1.12 1.12 1.12 1.12 1.12 1.12
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5157-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
249
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.27 10.8 11.51
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.26 4.3 4.1
Air Mass Flow (Wet) kg/bkW-hr 5.51 5.56 5.29
Compressor Out Pressure KPAa 242 226 164
Compressor Out Temperature °C 150 130 89
Inlet Manifold Pressure KPAa 221 170 111
Inlet Manifold Temperature (10) °C 61 56 48
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 453 453 463
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.58 4.63 4.43
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.73 5.79 5.54
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.27 1.32 1.38 1.43 1.48 1.54 1.60 1.60 1.60 1.60 1.60 1.60 1.60
AIR INLET TEMP.
45 1.20 1.25 1.30 1.35 1.41 1.46 1.52 1.52 1.52 1.52 1.52 1.52 1.52
40 1.13 1.18 1.23 1.28 1.33 1.38 1.44 1.44 1.44 1.44 1.44 1.44 1.44
35 1.05 1.10 1.15 1.20 1.25 1.31 1.36 1.36 1.36 1.36 1.36 1.36 1.36
30 1.00 1.03 1.08 1.13 1.18 1.23 1.28 1.29 1.29 1.29 1.29 1.29 1.29
25 1.00 1.00 1.00 1.05 1.10 1.15 1.20 1.21 1.21 1.21 1.21 1.21 1.21
20 1.00 1.00 1.00 1.00 1.02 1.07 1.12 1.13 1.13 1.13 1.13 1.13 1.13
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.05 1.05 1.05 1.05 1.05 1.05
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5158-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
251
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.53 10.06 10.77
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.41 4.59 4.82
Air Mass Flow (Wet) kg/bkW-hr 5.7 5.93 6.22
Compressor Out Pressure KPAa 255 220 165
Compressor Out Temperature °C 154 127 89
Inlet Manifold Pressure KPAa 237 183 131
Inlet Manifold Temperature (10) °C 40 36 34
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 485 492 500
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.72 4.91 5.16
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.9 6.14 6.45
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.27 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
AIR INLET TEMP.
45 1.17 1.21 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
40 1.11 1.15 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
35 1.05 1.09 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5166-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
253
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.67 9.97 10.48
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.49 4.55 4.71
Air Mass Flow (Wet) kg/bkW-hr 5.8 5.88 6.09
Compressor Out Pressure KPAa 261 226 166
Compressor Out Temperature °C 159 132 91
Inlet Manifold Pressure KPAa 245 186 130
Inlet Manifold Temperature (10) °C 41 37 35
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 514 519 533
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.8 4.87 5.05
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.01 6.09 6.31
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.22 1.27 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
AIR INLET TEMP.
45 1.16 1.21 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
40 1.10 1.14 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
35 1.04 1.08 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5161-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
255
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.28 9.72 10.29
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.18 4.26 4.35
Air Mass Flow (Wet) kg/bkW-hr 5.4 5.5 5.62
Compressor Out Pressure KPAa 253 208 158
Compressor Out Temperature °C 152 121 84
Inlet Manifold Pressure KPAa 229 174 123
Inlet Manifold Temperature (10) °C 41 37 34
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 489 501 503
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.48 4.57 4.67
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.6 5.71 5.84
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.17 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.11 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
35 1.05 1.09 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
30 1.00 1.02 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5162-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
257
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.44 9.87 10.53
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.24 4.35 4.54
Air Mass Flow (Wet) kg/bkW-hr 5.48 5.62 5.86
Compressor Out Pressure KPAa 251 218 163
Compressor Out Temperature °C 151 129 91
Inlet Manifold Pressure KPAa 231 178 126
Inlet Manifold Temperature (10) °C 40 36 34
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 521 527 537
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.54 4.66 4.87
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.68 5.83 6.08
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.17 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.11 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
35 1.05 1.09 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
30 1.00 1.02 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5163-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
259
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.53 10.06 10.77
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.41 4.59 4.82
Air Mass Flow (Wet) kg/bkW-hr 5.7 5.93 6.22
Compressor Out Pressure KPAa 255 220 165
Compressor Out Temperature °C 154 127 89
Inlet Manifold Pressure KPAa 237 183 131
Inlet Manifold Temperature (10) °C 40 36 34
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 485 492 500
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.72 4.91 5.16
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.9 6.14 6.45
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.27 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29 1.29
AIR INLET TEMP.
45 1.17 1.21 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
40 1.11 1.15 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
35 1.05 1.09 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1229-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
261
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.67 9.97 10.48
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.49 4.55 4.71
Air Mass Flow (Wet) kg/bkW-hr 5.8 5.88 6.09
Compressor Out Pressure KPAa 261 226 166
Compressor Out Temperature °C 159 132 91
Inlet Manifold Pressure KPAa 245 186 130
Inlet Manifold Temperature (10) °C 41 37 35
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 514 519 533
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.8 4.87 5.05
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.01 6.09 6.31
G3516
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.22 1.27 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
AIR INLET TEMP.
45 1.16 1.21 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
40 1.10 1.14 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
35 1.04 1.08 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1241-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
263
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.28 9.72 10.29
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.18 4.26 4.35
Air Mass Flow (Wet) kg/bkW-hr 5.4 5.5 5.62
Compressor Out Pressure KPAa 253 208 158
Compressor Out Temperature °C 152 121 84
Inlet Manifold Pressure KPAa 229 174 123
Inlet Manifold Temperature (10) °C 41 37 34
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 489 501 503
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.48 4.57 4.67
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.6 5.71 5.84
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.17 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.11 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
35 1.05 1.09 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
30 1.00 1.02 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1232-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
265
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.44 9.87 10.53
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.24 4.35 4.54
Air Mass Flow (Wet) kg/bkW-hr 5.48 5.62 5.86
Compressor Out Pressure KPAa 251 218 163
Compressor Out Temperature °C 151 129 91
Inlet Manifold Pressure KPAa 231 178 126
Inlet Manifold Temperature (10) °C 40 36 34
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 521 527 537
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.54 4.66 4.87
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.68 5.83 6.08
G3516
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.17 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.11 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
35 1.05 1.09 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
30 1.00 1.02 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1244-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
267
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.4 10.59 11.18
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.03 3.96 3.82
Air Mass Flow (Wet) kg/bkW-hr 5.21 5.12 4.93
Compressor Out Pressure KPAa 251 215 159
Compressor Out Temperature °C 158 130 88
Inlet Manifold Pressure KPAa 223 168 114
Inlet Manifold Temperature (10) °C 44 41 40
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 440 441 453
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.34 4.27 4.13
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.43 5.34 5.17
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.81 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.22 1.26 1.30 1.35 1.39 1.43 1.48 1.48 1.48 1.48 1.48 1.48 1.48
AIR INLET TEMP.
45 1.16 1.20 1.24 1.28 1.33 1.37 1.42 1.42 1.42 1.42 1.42 1.42 1.42
40 1.10 1.14 1.18 1.22 1.27 1.31 1.35 1.35 1.35 1.35 1.35 1.35 1.35
35 1.04 1.08 1.12 1.16 1.20 1.25 1.29 1.29 1.29 1.29 1.29 1.29 1.29
30 1.00 1.02 1.06 1.10 1.14 1.18 1.23 1.23 1.23 1.23 1.23 1.23 1.23
25 1.00 1.00 1.00 1.04 1.08 1.12 1.16 1.16 1.16 1.16 1.16 1.16 1.16
20 1.00 1.00 1.00 1.00 1.02 1.06 1.10 1.10 1.10 1.10 1.10 1.10 1.10
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5159-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
269
®
G3516 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.11 10.72 11.28
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.19 4.34 4.12
Air Mass Flow (Wet) kg/bkW-hr 5.41 5.61 5.32
Compressor Out Pressure KPAa 247 234 169
Compressor Out Temperature °C 151 137 93
Inlet Manifold Pressure KPAa 223 176 116
Inlet Manifold Temperature (10) °C 44 42 42
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 445 443 456
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.5 4.67 4.45
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.63 5.84 5.56
G3516
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
G3516
Aftercooler Heat Rejection Factors
50 1.23 1.27 1.31 1.35 1.40 1.44 1.49 1.49 1.49 1.49 1.49 1.49 1.49
AIR INLET TEMP.
45 1.17 1.21 1.25 1.29 1.33 1.38 1.42 1.43 1.43 1.43 1.43 1.43 1.43
40 1.10 1.15 1.19 1.23 1.27 1.31 1.36 1.36 1.36 1.36 1.36 1.36 1.36
35 1.04 1.08 1.12 1.17 1.21 1.25 1.29 1.30 1.30 1.30 1.30 1.30 1.30
30 1.00 1.02 1.06 1.10 1.14 1.19 1.23 1.23 1.23 1.23 1.23 1.23 1.23
25 1.00 1.00 1.00 1.04 1.08 1.12 1.16 1.17 1.17 1.17 1.17 1.17 1.17
20 1.00 1.00 1.00 1.00 1.02 1.06 1.10 1.10 1.10 1.10 1.10 1.10 1.10
15 1.00 1.00 1.00 1.00 1.00 1.00 1.03 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5165-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
271
®
G3512 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.61 11.17 12.04
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 3.08 3.13 3.48
Air Mass Flow (Wet) kg/bkW-hr 3.98 4.05 4.5
Compressor Out Pressure KPAa 198 183 146
Compressor Out Temperature °C 117 106 75
Inlet Manifold Pressure KPAa 182 147 109
Inlet Manifold Temperature (10) °C 60 59 59
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 465 448 419
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 3.36 3.43 3.8
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 4.21 4.29 4.76
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.38 1.46 1.53 1.61 1.68 1.76 1.84 1.85 1.85 1.85 1.85 1.85 1.85
AIR INLET TEMP.
45 1.28 1.35 1.43 1.50 1.57 1.65 1.73 1.74 1.74 1.74 1.74 1.74 1.74
40 1.18 1.25 1.32 1.39 1.47 1.54 1.62 1.62 1.62 1.62 1.62 1.62 1.62
35 1.07 1.14 1.21 1.28 1.36 1.43 1.51 1.51 1.51 1.51 1.51 1.51 1.51
30 1.00 1.04 1.11 1.18 1.25 1.32 1.40 1.40 1.40 1.40 1.40 1.40 1.40
25 1.00 1.00 1.00 1.07 1.14 1.21 1.28 1.29 1.29 1.29 1.29 1.29 1.29
20 1.00 1.00 1.00 1.00 1.03 1.10 1.17 1.18 1.18 1.18 1.18 1.18 1.18
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5207-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
273
®
G3512 TA Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 172
Exhaust Manifold WATER COOLED Methane Number at Conditions Shown 80
Combustion System Type CATALYST Rated Altitude (m) 1524
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 11.07 11.68 12.72
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 2.92 3.1 3.36
Air Mass Flow (Wet) kg/bkW-hr 3.78 4 4.34
Compressor Out Pressure KPAa 204 187 145
Compressor Out Temperature °C 126 113 78
Inlet Manifold Pressure KPAa 178 147 110
Inlet Manifold Temperature (10) °C 60 58 58
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 478 447 421
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 3.21 3.4 3.69
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 4.01 4.25 4.61
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.35 1.42 1.49 1.56 1.63 1.70 1.77 1.78 1.78 1.78 1.78 1.78 1.78
AIR INLET TEMP.
45 1.26 1.32 1.39 1.46 1.53 1.60 1.67 1.68 1.68 1.68 1.68 1.68 1.68
40 1.16 1.23 1.29 1.36 1.43 1.50 1.57 1.58 1.58 1.58 1.58 1.58 1.58
35 1.06 1.13 1.20 1.26 1.33 1.40 1.47 1.47 1.47 1.47 1.47 1.47 1.47
30 1.00 1.03 1.10 1.16 1.23 1.30 1.37 1.37 1.37 1.37 1.37 1.37 1.37
25 1.00 1.00 1.00 1.07 1.13 1.20 1.26 1.27 1.27 1.27 1.27 1.27 1.27
20 1.00 1.00 1.00 1.00 1.03 1.10 1.16 1.17 1.17 1.17 1.17 1.17 1.17
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5209-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
275
®
G3512 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.61 11.17 12.04
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 3.08 3.13 3.48
Air Mass Flow (Wet) kg/bkW-hr 3.98 4.05 4.5
Compressor Out Pressure KPAa 198 183 146
Compressor Out Temperature °C 117 106 75
Inlet Manifold Pressure KPAa 182 147 109
Inlet Manifold Temperature (10) °C 60 59 59
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 465 448 419
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 3.36 3.43 3.8
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 4.21 4.29 4.76
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.38 1.46 1.53 1.61 1.68 1.76 1.84 1.85 1.85 1.85 1.85 1.85 1.85
AIR INLET TEMP.
45 1.28 1.35 1.43 1.50 1.57 1.65 1.73 1.74 1.74 1.74 1.74 1.74 1.74
40 1.18 1.25 1.32 1.39 1.47 1.54 1.62 1.62 1.62 1.62 1.62 1.62 1.62
35 1.07 1.14 1.21 1.28 1.36 1.43 1.51 1.51 1.51 1.51 1.51 1.51 1.51
30 1.00 1.04 1.11 1.18 1.25 1.32 1.40 1.40 1.40 1.40 1.40 1.40 1.40
25 1.00 1.00 1.00 1.07 1.14 1.21 1.28 1.29 1.29 1.29 1.29 1.29 1.29
20 1.00 1.00 1.00 1.00 1.03 1.10 1.17 1.18 1.18 1.18 1.18 1.18 1.18
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5108-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
277
®
G3512 TA Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold WATER COOLED Methane Number at Conditions Shown 80
Combustion System Type CATALYST Rated Altitude (m) 1524
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 11.07 11.68 12.72
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 2.92 3.1 3.36
Air Mass Flow (Wet) kg/bkW-hr 3.78 4 4.34
Compressor Out Pressure KPAa 204 187 145
Compressor Out Temperature °C 126 113 78
Inlet Manifold Pressure KPAa 178 147 110
Inlet Manifold Temperature (10) °C 60 58 58
Timing (11) °BTDC 22.5 22.5 22.5
Exhaust Stack Temperature °C 478 447 421
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 3.21 3.4 3.69
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 4.01 4.25 4.61
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.35 1.42 1.49 1.56 1.63 1.70 1.77 1.78 1.78 1.78 1.78 1.78 1.78
AIR INLET TEMP.
45 1.26 1.32 1.39 1.46 1.53 1.60 1.67 1.68 1.68 1.68 1.68 1.68 1.68
40 1.16 1.23 1.29 1.36 1.43 1.50 1.57 1.58 1.58 1.58 1.58 1.58 1.58
35 1.06 1.13 1.20 1.26 1.33 1.40 1.47 1.47 1.47 1.47 1.47 1.47 1.47
30 1.00 1.03 1.10 1.16 1.23 1.30 1.37 1.37 1.37 1.37 1.37 1.37 1.37
25 1.00 1.00 1.00 1.07 1.13 1.20 1.26 1.27 1.27 1.27 1.27 1.27 1.27
20 1.00 1.00 1.00 1.00 1.03 1.10 1.16 1.17 1.17 1.17 1.17 1.17 1.17
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5109-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
279
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.22 10.37 11.89
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.51 4.34 4.37
Air Mass Flow (Wet) kg/bkW-hr 5.83 5.61 5.65
Compressor Out Pressure KPAa 247 205 162
Compressor Out Temperature °C 154 122 88
Inlet Manifold Pressure KPAa 214 165 118
Inlet Manifold Temperature (10) °C 59 56 56
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 388 394 390
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.84 4.67 4.71
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.05 5.83 5.88
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.78 0.75 0.73 0.71 0.68
AIR INLET TEMP.
45 1.00 0.97 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.69
40 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
35 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74 0.72
30 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73
25 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74
20 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
15 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
(°C) 10 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.27 1.32 1.37 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
45 1.19 1.24 1.29 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
40 1.12 1.17 1.22 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
35 1.05 1.10 1.15 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
30 1.00 1.03 1.07 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
25 1.00 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM0745-02 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
281
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.21 10.47 11.23
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.28 4.31 4.33
Air Mass Flow (Wet) kg/bkW-hr 5.53 5.58 5.6
Compressor Out Pressure KPAa 243 204 154
Compressor Out Temperature °C 154 127 85
Inlet Manifold Pressure KPAa 216 165 115
Inlet Manifold Temperature (10) °C 63 62 64
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 409 420 422
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.59 4.64 4.67
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.74 5.8 5.84
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.78 0.75 0.73 0.71 0.68
AIR INLET TEMP.
45 1.00 0.97 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.69
40 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
35 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74 0.72
30 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73
25 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74
20 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
15 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
(°C) 10 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.26 1.31 1.36 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
45 1.19 1.24 1.29 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
40 1.12 1.17 1.22 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
35 1.05 1.10 1.15 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
30 1.00 1.02 1.07 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
25 1.00 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5110-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
283
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.22 10.37 11.89
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.51 4.34 4.37
Air Mass Flow (Wet) kg/bkW-hr 5.83 5.61 5.65
Compressor Out Pressure KPAa 247 205 162
Compressor Out Temperature °C 157 123 88
Inlet Manifold Pressure KPAa 214 165 118
Inlet Manifold Temperature (10) °C 59 56 56
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 388 394 390
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.84 4.67 4.71
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.05 5.83 5.88
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68 0.66
AIR INLET TEMP.
45 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69 0.67
40 0.98 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68
35 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69
30 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.73 0.70
25 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.71
20 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75 0.73
15 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.26 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
AIR INLET TEMP.
45 1.19 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
40 1.12 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
35 1.05 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5112-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
285
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.21 10.47 11.23
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.28 4.31 4.33
Air Mass Flow (Wet) kg/bkW-hr 5.53 5.58 5.6
Compressor Out Pressure KPAa 243 204 154
Compressor Out Temperature °C 157 128 85
Inlet Manifold Pressure KPAa 216 165 115
Inlet Manifold Temperature (10) °C 63 62 64
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 409 420 422
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.59 4.64 4.67
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.74 5.8 5.84
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68 0.66
AIR INLET TEMP.
45 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69 0.67
40 0.98 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68
35 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69
30 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.73 0.70
25 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.71
20 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75 0.73
15 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.25 1.30 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
AIR INLET TEMP.
45 1.18 1.23 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
40 1.11 1.16 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
35 1.05 1.09 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5111-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
287
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.48 10.75 11.44
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.4 4.28 4.28
Air Mass Flow (Wet) kg/bkW-hr 5.68 5.53 5.53
Compressor Out Pressure KPAa 243 216 157
Compressor Out Temperature °C 158 136 93
Inlet Manifold Pressure KPAa 216 165 114
Inlet Manifold Temperature (10) °C 45 44 43
Timing (11) °BTDC 35 35 35
Exhaust Stack Temperature °C 426 421 421
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.72 4.61 4.62
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.91 5.76 5.77
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73
AIR INLET TEMP.
45 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74
40 1.00 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75
35 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76
30 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78
25 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.81 0.79
20 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
15 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.21 1.25 1.30 1.34 1.38 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
45 1.15 1.19 1.24 1.28 1.32 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
40 1.09 1.14 1.18 1.22 1.26 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
35 1.04 1.08 1.12 1.16 1.20 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
30 1.00 1.02 1.06 1.10 1.14 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
25 1.00 1.00 1.00 1.04 1.08 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
20 1.00 1.00 1.00 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5169-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
289
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.9 11.33 11.94
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.32 4.25 4.3
Air Mass Flow (Wet) kg/bkW-hr 5.59 5.49 5.55
Compressor Out Pressure KPAa 239 205 156
Compressor Out Temperature °C 146 121 80
Inlet Manifold Pressure KPAa 211 161 115
Inlet Manifold Temperature (10) °C 43 41 41
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 382 388 389
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.64 4.58 4.64
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.8 5.73 5.81
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.78 0.75 0.73 0.71 0.68
AIR INLET TEMP.
45 1.00 0.97 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.69
40 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
35 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74 0.72
30 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73
25 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74
20 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
15 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
(°C) 10 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.23 1.28 1.32 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
AIR INLET TEMP.
45 1.17 1.21 1.26 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
40 1.11 1.15 1.19 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
35 1.05 1.09 1.13 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
30 1.00 1.02 1.06 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
25 1.00 1.00 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5173-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
291
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.9 11.33 11.94
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.32 4.25 4.3
Air Mass Flow (Wet) kg/bkW-hr 5.59 5.49 5.55
Compressor Out Pressure KPAa 239 205 156
Compressor Out Temperature °C 146 121 80
Inlet Manifold Pressure KPAa 211 161 115
Inlet Manifold Temperature (10) °C 43 41 41
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 382 388 389
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.64 4.58 4.64
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.8 5.73 5.81
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68 0.66
AIR INLET TEMP.
45 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69 0.67
40 0.98 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68
35 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69
30 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.73 0.70
25 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.71
20 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75 0.73
15 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.23 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
AIR INLET TEMP.
45 1.17 1.21 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
40 1.11 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15 1.15
35 1.05 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
30 1.00 1.02 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5115-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
293
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.48 10.68 11.45
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.37 4.18 4.25
Air Mass Flow (Wet) kg/bkW-hr 5.65 5.41 5.49
Compressor Out Pressure KPAa 247 216 160
Compressor Out Temperature °C 160 139 90
Inlet Manifold Pressure KPAa 219 165 115
Inlet Manifold Temperature (10) °C 49 49 50
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °C 445 440 436
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.7 4.51 4.57
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.88 5.63 5.71
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73
AIR INLET TEMP.
45 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74
40 1.00 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75
35 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76
30 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78
25 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.81 0.79
20 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
15 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.21 1.25 1.29 1.34 1.38 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
45 1.15 1.19 1.23 1.28 1.32 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
40 1.09 1.13 1.18 1.22 1.26 1.28 1.28 1.28 1.28 1.28 1.28 1.28 1.28
35 1.04 1.08 1.12 1.16 1.20 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
30 1.00 1.02 1.06 1.10 1.14 1.16 1.16 1.16 1.16 1.16 1.16 1.16 1.16
25 1.00 1.00 1.00 1.04 1.08 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
20 1.00 1.00 1.00 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5113-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
295
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.85 10.17 10.92
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.26 4.2 4.22
Air Mass Flow (Wet) kg/bkW-hr 5.5 5.42 5.45
Compressor Out Pressure KPAa 254 208 152
Compressor Out Temperature °C 160 129 87
Inlet Manifold Pressure KPAa 216 164 114
Inlet Manifold Temperature (10) °C 45 46 47
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 400 416 418
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.57 4.51 4.54
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.71 5.64 5.68
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.78 0.75 0.73 0.71 0.68
AIR INLET TEMP.
45 1.00 0.97 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.69
40 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
35 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74 0.72
30 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73
25 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74
20 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
15 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
(°C) 10 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.21 1.25 1.29 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
AIR INLET TEMP.
45 1.15 1.19 1.23 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
40 1.10 1.13 1.17 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
35 1.04 1.08 1.12 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
30 1.00 1.02 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07 1.07
25 1.00 1.00 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5114-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
297
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.85 10.17 10.92
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.26 4.2 4.22
Air Mass Flow (Wet) kg/bkW-hr 5.5 5.42 5.45
Compressor Out Pressure KPAa 254 208 152
Compressor Out Temperature °C 164 131 87
Inlet Manifold Pressure KPAa 216 164 114
Inlet Manifold Temperature (10) °C 45 46 47
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 400 416 418
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.57 4.51 4.54
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.71 5.64 5.68
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68 0.66
AIR INLET TEMP.
45 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69 0.67
40 0.98 0.95 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.72 0.70 0.68
35 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.74 0.71 0.69
30 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75 0.73 0.70
25 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.71
20 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77 0.75 0.73
15 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.76 0.74
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.20 1.24 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
AIR INLET TEMP.
45 1.15 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19 1.19
40 1.09 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
35 1.04 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
30 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5116-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
299
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.77 10.95 11.69
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.55 4.39 4.58
Air Mass Flow (Wet) kg/bkW-hr 5.88 5.67 5.91
Compressor Out Pressure KPAa 266 233 170
Compressor Out Temperature °C 163 145 100
Inlet Manifold Pressure KPAa 229 168 120
Inlet Manifold Temperature (10) °C 59 56 53
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °C 468 465 465
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.88 4.72 4.92
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.11 5.9 6.16
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.25 1.29 1.34 1.39 1.44 1.48 1.53 1.54 1.54 1.54 1.54 1.54 1.54
AIR INLET TEMP.
45 1.18 1.23 1.27 1.32 1.37 1.41 1.46 1.47 1.47 1.47 1.47 1.47 1.47
40 1.11 1.16 1.20 1.25 1.30 1.34 1.39 1.40 1.40 1.40 1.40 1.40 1.40
35 1.05 1.09 1.14 1.18 1.23 1.27 1.32 1.33 1.33 1.33 1.33 1.33 1.33
30 1.00 1.03 1.07 1.11 1.16 1.20 1.25 1.25 1.25 1.25 1.25 1.25 1.25
25 1.00 1.00 1.00 1.04 1.09 1.13 1.18 1.18 1.18 1.18 1.18 1.18 1.18
20 1.00 1.00 1.00 1.00 1.02 1.06 1.11 1.11 1.11 1.11 1.11 1.11 1.11
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5171-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
301
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.86 11.05 11.68
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.58 4.41 4.59
Air Mass Flow (Wet) kg/bkW-hr 5.92 5.7 5.93
Compressor Out Pressure KPAa 266 234 170
Compressor Out Temperature °C 162 145 99
Inlet Manifold Pressure KPAa 234 170 121
Inlet Manifold Temperature (10) °C 62 58 55
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °C 481 475 472
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.92 4.74 4.94
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.15 5.93 6.18
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.25 1.30 1.35 1.39 1.44 1.49 1.54 1.55 1.55 1.55 1.55 1.55 1.55
AIR INLET TEMP.
45 1.18 1.23 1.28 1.32 1.37 1.42 1.47 1.47 1.47 1.47 1.47 1.47 1.47
40 1.12 1.16 1.21 1.25 1.30 1.35 1.40 1.40 1.40 1.40 1.40 1.40 1.40
35 1.05 1.09 1.14 1.18 1.23 1.28 1.32 1.33 1.33 1.33 1.33 1.33 1.33
30 1.00 1.03 1.07 1.11 1.16 1.21 1.25 1.26 1.26 1.26 1.26 1.26 1.26
25 1.00 1.00 1.00 1.04 1.09 1.13 1.18 1.19 1.19 1.19 1.19 1.19 1.19
20 1.00 1.00 1.00 1.00 1.02 1.06 1.11 1.11 1.11 1.11 1.11 1.11 1.11
15 1.00 1.00 1.00 1.00 1.00 1.00 1.04 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5122-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
303
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.58 11.06 11.82
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.11 4.26 4.16
Air Mass Flow (Wet) kg/bkW-hr 5.31 5.51 5.38
Compressor Out Pressure KPAa 240 210 164
Compressor Out Temperature °C 145 122 90
Inlet Manifold Pressure KPAa 213 169 118
Inlet Manifold Temperature (10) °C 62 59 57
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °C 467 470 476
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.43 4.59 4.51
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.54 5.74 5.64
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
40 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77
35 1.00 1.00 1.00 1.00 1.00 0.97 0.95 0.92 0.89 0.86 0.83 0.81 0.78
30 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80
25 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81
20 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.82
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.28 1.34 1.39 1.44 1.50 1.56 1.57 1.57 1.57 1.57 1.57 1.57 1.57
AIR INLET TEMP.
45 1.21 1.26 1.31 1.37 1.42 1.48 1.49 1.49 1.49 1.49 1.49 1.49 1.49
40 1.13 1.18 1.23 1.29 1.34 1.39 1.41 1.41 1.41 1.41 1.41 1.41 1.41
35 1.06 1.11 1.16 1.21 1.26 1.31 1.33 1.33 1.33 1.33 1.33 1.33 1.33
30 1.00 1.03 1.08 1.13 1.18 1.23 1.25 1.25 1.25 1.25 1.25 1.25 1.25
25 1.00 1.00 1.00 1.05 1.10 1.15 1.17 1.17 1.17 1.17 1.17 1.17 1.17
20 1.00 1.00 1.00 1.00 1.02 1.07 1.09 1.09 1.09 1.09 1.09 1.09 1.09
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5123-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
305
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.72 10.98 11.73
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.18 4.33 4.23
Air Mass Flow (Wet) kg/bkW-hr 5.4 5.6 5.47
Compressor Out Pressure KPAa 242 212 165
Compressor Out Temperature °C 145 122 90
Inlet Manifold Pressure KPAa 215 170 118
Inlet Manifold Temperature (10) °C 66 63 61
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °C 476 480 486
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.49 4.66 4.58
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.62 5.83 5.73
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
40 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77
35 1.00 1.00 1.00 1.00 1.00 0.97 0.95 0.92 0.89 0.86 0.83 0.81 0.78
30 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80
25 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81
20 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.82
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.29 1.34 1.39 1.44 1.50 1.55 1.57 1.57 1.57 1.57 1.57 1.57 1.57
AIR INLET TEMP.
45 1.21 1.26 1.31 1.37 1.42 1.47 1.49 1.49 1.49 1.49 1.49 1.49 1.49
40 1.13 1.18 1.23 1.29 1.34 1.39 1.41 1.41 1.41 1.41 1.41 1.41 1.41
35 1.06 1.11 1.16 1.21 1.26 1.31 1.33 1.33 1.33 1.33 1.33 1.33 1.33
30 1.00 1.03 1.08 1.13 1.18 1.23 1.25 1.25 1.25 1.25 1.25 1.25 1.25
25 1.00 1.00 1.00 1.05 1.10 1.15 1.16 1.16 1.16 1.16 1.16 1.16 1.16
20 1.00 1.00 1.00 1.00 1.02 1.07 1.08 1.08 1.08 1.08 1.08 1.08 1.08
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5121-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
307
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.58 11.06 11.82
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.11 4.26 4.16
Air Mass Flow (Wet) kg/bkW-hr 5.31 5.51 5.38
Compressor Out Pressure KPAa 240 210 164
Compressor Out Temperature °C 151 124 91
Inlet Manifold Pressure KPAa 213 169 118
Inlet Manifold Temperature (10) °C 62 59 57
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °C 467 470 476
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.43 4.59 4.51
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.54 5.74 5.64
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
AIR INLET TEMP.
45 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73
40 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74
35 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76
30 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
25 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
20 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79
15 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.27 1.32 1.37 1.42 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
AIR INLET TEMP.
45 1.19 1.25 1.30 1.35 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
40 1.12 1.17 1.22 1.27 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
35 1.05 1.10 1.15 1.20 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
30 1.00 1.03 1.07 1.13 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
25 1.00 1.00 1.00 1.05 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
20 1.00 1.00 1.00 1.00 1.02 1.03 1.03 1.03 1.03 1.03 1.03 1.03 1.03
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5126-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
309
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.72 10.98 11.73
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.18 4.33 4.23
Air Mass Flow (Wet) kg/bkW-hr 5.4 5.6 5.47
Compressor Out Pressure KPAa 242 212 165
Compressor Out Temperature °C 150 126 93
Inlet Manifold Pressure KPAa 215 170 118
Inlet Manifold Temperature (10) °C 66 63 61
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °C 476 480 486
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.49 4.66 4.58
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.62 5.83 5.73
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
AIR INLET TEMP.
45 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73
40 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74
35 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76
30 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
25 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
20 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79
15 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.27 1.32 1.37 1.43 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48 1.48
AIR INLET TEMP.
45 1.20 1.25 1.30 1.35 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
40 1.12 1.17 1.23 1.28 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
35 1.05 1.10 1.15 1.20 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
30 1.00 1.03 1.08 1.13 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
25 1.00 1.00 1.00 1.05 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
20 1.00 1.00 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5125-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
311
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.56 10.66 11.43
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.44 4.3 4.38
Air Mass Flow (Wet) kg/bkW-hr 5.74 5.55 5.66
Compressor Out Pressure KPAa 268 237 173
Compressor Out Temperature °C 165 149 102
Inlet Manifold Pressure KPAa 228 171 119
Inlet Manifold Temperature (10) °C 44 40 34
Timing (11) °BTDC 35 35 35
Exhaust Stack Temperature °C 465 459 463
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.77 4.62 4.72
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.96 5.78 5.9
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.21 1.25 1.29 1.33 1.37 1.41 1.45 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
45 1.15 1.19 1.23 1.27 1.31 1.35 1.39 1.40 1.40 1.40 1.40 1.40 1.40
40 1.10 1.13 1.17 1.21 1.25 1.29 1.33 1.34 1.34 1.34 1.34 1.34 1.34
35 1.04 1.08 1.12 1.15 1.19 1.23 1.27 1.28 1.28 1.28 1.28 1.28 1.28
30 1.00 1.02 1.06 1.10 1.13 1.17 1.21 1.22 1.22 1.22 1.22 1.22 1.22
25 1.00 1.00 1.00 1.04 1.08 1.11 1.15 1.16 1.16 1.16 1.16 1.16 1.16
20 1.00 1.00 1.00 1.00 1.02 1.05 1.09 1.10 1.10 1.10 1.10 1.10 1.10
15 1.00 1.00 1.00 1.00 1.00 1.00 1.03 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5170-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
313
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.7 10.81 11.42
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.47 4.32 4.4
Air Mass Flow (Wet) kg/bkW-hr 5.78 5.58 5.68
Compressor Out Pressure KPAa 268 237 173
Compressor Out Temperature °C 165 149 102
Inlet Manifold Pressure KPAa 233 173 119
Inlet Manifold Temperature (10) °C 46 42 35
Timing (11) °BTDC 33 33 33
Exhaust Stack Temperature °C 478 469 470
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.8 4.64 4.74
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6 5.81 5.92
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.21 1.25 1.29 1.33 1.37 1.41 1.46 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
45 1.15 1.19 1.23 1.27 1.31 1.35 1.40 1.40 1.40 1.40 1.40 1.40 1.40
40 1.10 1.14 1.17 1.21 1.25 1.29 1.34 1.34 1.34 1.34 1.34 1.34 1.34
35 1.04 1.08 1.12 1.16 1.19 1.23 1.27 1.28 1.28 1.28 1.28 1.28 1.28
30 1.00 1.02 1.06 1.10 1.14 1.17 1.21 1.22 1.22 1.22 1.22 1.22 1.22
25 1.00 1.00 1.00 1.04 1.08 1.11 1.15 1.16 1.16 1.16 1.16 1.16 1.16
20 1.00 1.00 1.00 1.00 1.02 1.05 1.09 1.10 1.10 1.10 1.10 1.10 1.10
15 1.00 1.00 1.00 1.00 1.00 1.00 1.03 1.04 1.04 1.04 1.04 1.04 1.04
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5132-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
315
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.3 10.92 11.5
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.09 4.29 4.08
Air Mass Flow (Wet) kg/bkW-hr 5.29 5.54 5.28
Compressor Out Pressure KPAa 244 232 168
Compressor Out Temperature °C 147 134 91
Inlet Manifold Pressure KPAa 216 172 112
Inlet Manifold Temperature (10) °C 44 42 42
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 456 453 466
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.41 4.62 4.42
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.51 5.78 5.53
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
40 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77
35 1.00 1.00 1.00 1.00 1.00 0.97 0.95 0.92 0.89 0.86 0.83 0.81 0.78
30 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80
25 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81
20 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.82
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.23 1.27 1.31 1.36 1.40 1.45 1.46 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
45 1.17 1.21 1.25 1.29 1.34 1.38 1.39 1.39 1.39 1.39 1.39 1.39 1.39
40 1.11 1.15 1.19 1.23 1.27 1.32 1.33 1.33 1.33 1.33 1.33 1.33 1.33
35 1.04 1.09 1.13 1.17 1.21 1.25 1.26 1.26 1.26 1.26 1.26 1.26 1.26
30 1.00 1.02 1.06 1.10 1.15 1.19 1.20 1.20 1.20 1.20 1.20 1.20 1.20
25 1.00 1.00 1.00 1.04 1.08 1.12 1.13 1.13 1.13 1.13 1.13 1.13 1.13
20 1.00 1.00 1.00 1.00 1.02 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5131-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
317
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.43 10.84 11.41
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.16 4.36 4.15
Air Mass Flow (Wet) kg/bkW-hr 5.38 5.63 5.36
Compressor Out Pressure KPAa 247 234 169
Compressor Out Temperature °C 147 134 91
Inlet Manifold Pressure KPAa 218 173 112
Inlet Manifold Temperature (10) °C 47 45 44
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 465 462 476
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.47 4.69 4.49
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.59 5.87 5.61
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
40 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77
35 1.00 1.00 1.00 1.00 1.00 0.97 0.95 0.92 0.89 0.86 0.83 0.81 0.78
30 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80
25 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86 0.84 0.81
20 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.91 0.88 0.85 0.82
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.87 0.84
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.85
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.23 1.27 1.31 1.36 1.40 1.45 1.46 1.46 1.46 1.46 1.46 1.46 1.46
AIR INLET TEMP.
45 1.17 1.21 1.25 1.29 1.34 1.38 1.39 1.39 1.39 1.39 1.39 1.39 1.39
40 1.11 1.15 1.19 1.23 1.27 1.32 1.33 1.33 1.33 1.33 1.33 1.33 1.33
35 1.05 1.09 1.13 1.17 1.21 1.25 1.26 1.26 1.26 1.26 1.26 1.26 1.26
30 1.00 1.02 1.06 1.10 1.15 1.19 1.20 1.20 1.20 1.20 1.20 1.20 1.20
25 1.00 1.00 1.00 1.04 1.08 1.12 1.13 1.13 1.13 1.13 1.13 1.13 1.13
20 1.00 1.00 1.00 1.00 1.02 1.06 1.07 1.07 1.07 1.07 1.07 1.07 1.07
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5130-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
319
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.3 10.92 11.5
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.09 4.29 4.08
Air Mass Flow (Wet) kg/bkW-hr 5.29 5.54 5.28
Compressor Out Pressure KPAa 244 232 168
Compressor Out Temperature °C 153 137 92
Inlet Manifold Pressure KPAa 216 172 112
Inlet Manifold Temperature (10) °C 44 42 42
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 456 453 466
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.41 4.62 4.42
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.51 5.78 5.53
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
AIR INLET TEMP.
45 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73
40 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74
35 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76
30 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
25 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
20 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79
15 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.22 1.26 1.30 1.35 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
45 1.16 1.20 1.24 1.29 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
40 1.10 1.14 1.18 1.22 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
35 1.04 1.08 1.12 1.16 1.20 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
30 1.00 1.02 1.06 1.10 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
25 1.00 1.00 1.00 1.04 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
20 1.00 1.00 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5210-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
321
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.43 10.84 11.41
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.16 4.36 4.15
Air Mass Flow (Wet) kg/bkW-hr 5.38 5.63 5.36
Compressor Out Pressure KPAa 247 234 169
Compressor Out Temperature °C 153 139 95
Inlet Manifold Pressure KPAa 218 173 112
Inlet Manifold Temperature (10) °C 47 45 44
Timing (11) °BTDC 18 18 18
Exhaust Stack Temperature °C 465 462 476
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.47 4.69 4.49
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.59 5.87 5.61
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
AIR INLET TEMP.
45 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73
40 1.00 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74
35 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76
30 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
25 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78
20 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79
15 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.22 1.26 1.30 1.35 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39 1.39
AIR INLET TEMP.
45 1.16 1.20 1.24 1.29 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
40 1.10 1.14 1.18 1.22 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
35 1.04 1.08 1.12 1.16 1.20 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
30 1.00 1.02 1.06 1.10 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
25 1.00 1.00 1.00 1.04 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
20 1.00 1.00 1.00 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5139-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
323
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 200
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.13 10.47 11.12
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.47 4.55 4.69
Air Mass Flow (Wet) kg/bkW-hr 5.78 5.88 6.07
Compressor Out Pressure KPAa 251 202 155
Compressor Out Temperature °C 145 115 81
Inlet Manifold Pressure KPAa 242 183 126
Inlet Manifold Temperature (10) °C 57 56 55
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 531 532 527
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.79 4.88 5.04
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.99 6.1 6.3
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.29 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
AIR INLET TEMP.
45 1.22 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.14 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
35 1.06 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1977-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
325
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 350
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.78 10.18 10.94
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.17 4.25 4.47
Air Mass Flow (Wet) kg/bkW-hr 5.38 5.49 5.78
Compressor Out Pressure KPAa 234 195 150
Compressor Out Temperature °C 135 109 78
Inlet Manifold Pressure KPAa 227 172 121
Inlet Manifold Temperature (10) °C 57 55 55
Timing (11) °BTDC 22 22 22
Exhaust Stack Temperature °C 536 537 533
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.47 4.56 4.8
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.59 5.71 6.01
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.32 1.38 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
45 1.24 1.29 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
40 1.15 1.21 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
35 1.07 1.12 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
30 1.00 1.03 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06 1.06
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1980-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
327
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 127 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 200
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.3 10.63 11.36
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.54 4.61 4.85
Air Mass Flow (Wet) kg/bkW-hr 5.87 5.96 6.27
Compressor Out Pressure KPAa 258 211 160
Compressor Out Temperature °C 151 121 87
Inlet Manifold Pressure KPAa 251 189 132
Inlet Manifold Temperature (10) °C 57 56 55
Timing (11) °BTDC 19 19 19
Exhaust Stack Temperature °C 554 553 552
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.87 4.94 5.21
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.09 6.18 6.51
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.21 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
40 1.13 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
35 1.06 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1989-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
329
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 127 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 350
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.98 10.36 11.11
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.24 4.34 4.62
Air Mass Flow (Wet) kg/bkW-hr 5.48 5.6 5.96
Compressor Out Pressure KPAa 244 201 155
Compressor Out Temperature °C 142 116 83
Inlet Manifold Pressure KPAa 235 178 124
Inlet Manifold Temperature (10) °C 56 55 55
Timing (11) °BTDC 19 19 19
Exhaust Stack Temperature °C 560 559 557
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.55 4.66 4.96
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.69 5.82 6.2
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.30 1.36 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
45 1.22 1.27 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
40 1.14 1.19 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
35 1.06 1.11 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
30 1.00 1.03 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1992-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
331
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 200
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.84 10.24 10.95
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.51 4.6 4.77
Air Mass Flow (Wet) kg/bkW-hr 5.83 5.94 6.16
Compressor Out Pressure KPAa 239 196 152
Compressor Out Temperature °C 144 114 80
Inlet Manifold Pressure KPAa 230 178 125
Inlet Manifold Temperature (10) °C 57 56 55
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 512 518 517
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.83 4.92 5.12
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.04 6.16 6.4
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.29 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
AIR INLET TEMP.
45 1.21 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
40 1.14 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
35 1.06 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
30 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1953-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
333
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 350
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.5 9.95 10.78
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.2 4.32 4.53
Air Mass Flow (Wet) kg/bkW-hr 5.43 5.58 5.86
Compressor Out Pressure KPAa 223 189 148
Compressor Out Temperature °C 134 109 78
Inlet Manifold Pressure KPAa 216 168 120
Inlet Manifold Temperature (10) °C 57 55 55
Timing (11) °BTDC 20 20 20
Exhaust Stack Temperature °C 517 522 523
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.51 4.63 4.87
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.64 5.79 6.09
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.32 1.38 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
AIR INLET TEMP.
45 1.23 1.29 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
40 1.15 1.21 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23 1.23
35 1.06 1.12 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
30 1.00 1.03 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1956-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
335
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 127 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 200
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10 10.4 11.2
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.48 4.65 4.88
Air Mass Flow (Wet) kg/bkW-hr 5.79 6.01 6.3
Compressor Out Pressure KPAa 245 204 157
Compressor Out Temperature °C 150 121 87
Inlet Manifold Pressure KPAa 238 183 130
Inlet Manifold Temperature (10) °C 57 56 55
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °C 534 538 542
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.8 4.98 5.23
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.01 6.23 6.54
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.28 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.21 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
40 1.13 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
35 1.06 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09 1.09
30 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1965-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
337
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 127 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 350
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.69 10.13 10.95
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.18 4.29 4.58
Air Mass Flow (Wet) kg/bkW-hr 5.41 5.55 5.92
Compressor Out Pressure KPAa 232 195 152
Compressor Out Temperature °C 141 115 83
Inlet Manifold Pressure KPAa 224 173 123
Inlet Manifold Temperature (10) °C 56 55 55
Timing (11) °BTDC 17 17 17
Exhaust Stack Temperature °C 540 544 547
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.49 4.61 4.92
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.61 5.76 6.15
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.30 1.36 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38 1.38
AIR INLET TEMP.
45 1.22 1.28 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30 1.30
40 1.14 1.19 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22 1.22
35 1.06 1.11 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13 1.13
30 1.00 1.03 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05 1.05
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1968-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
339
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 200
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.52 10.01 10.74
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.36 4.4 4.64
Air Mass Flow (Wet) kg/bkW-hr 5.64 5.68 6
Compressor Out Pressure KPAa 242 198 154
Compressor Out Temperature °C 146 115 82
Inlet Manifold Pressure KPAa 230 178 126
Inlet Manifold Temperature (10) °C 38 35 33
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 493 501 501
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.67 4.71 4.98
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.84 5.89 6.23
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.24 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
AIR INLET TEMP.
45 1.17 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
40 1.11 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
35 1.05 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
30 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1952-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
341
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 350
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.28 9.64 10.4
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.15 4.28 4.42
Air Mass Flow (Wet) kg/bkW-hr 5.36 5.52 5.71
Compressor Out Pressure KPAa 227 190 149
Compressor Out Temperature °C 135 109 78
Inlet Manifold Pressure KPAa 217 169 120
Inlet Manifold Temperature (10) °C 37 34 33
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 496 501 505
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.45 4.58 4.75
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.56 5.73 5.93
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.25 1.30 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.19 1.23 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
40 1.12 1.16 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
35 1.05 1.09 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
30 1.00 1.03 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1955-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
343
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 127 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 200
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.8 10.06 10.75
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.51 4.59 4.79
Air Mass Flow (Wet) kg/bkW-hr 5.83 5.93 6.19
Compressor Out Pressure KPAa 245 204 157
Compressor Out Temperature °C 152 122 88
Inlet Manifold Pressure KPAa 239 184 129
Inlet Manifold Temperature (10) °C 38 35 33
Timing (11) °BTDC 21 21 21
Exhaust Stack Temperature °C 514 519 522
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.83 4.92 5.14
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 6.04 6.15 6.42
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.23 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
AIR INLET TEMP.
45 1.17 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
40 1.11 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
35 1.04 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
30 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1964-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
345
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 127 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 350
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.49 9.84 10.53
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.23 4.34 4.59
Air Mass Flow (Wet) kg/bkW-hr 5.47 5.6 5.93
Compressor Out Pressure KPAa 234 196 152
Compressor Out Temperature °C 142 116 83
Inlet Manifold Pressure KPAa 226 174 123
Inlet Manifold Temperature (10) °C 37 34 33
Timing (11) °BTDC 21 21 21
Exhaust Stack Temperature °C 518 523 526
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.54 4.65 4.92
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.67 5.82 6.16
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.24 1.29 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
AIR INLET TEMP.
45 1.18 1.22 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
40 1.11 1.16 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
35 1.05 1.09 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
30 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1967-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
347
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 200
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.52 10.01 10.74
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.36 4.4 4.64
Air Mass Flow (Wet) kg/bkW-hr 5.64 5.68 6
Compressor Out Pressure KPAa 242 198 154
Compressor Out Temperature °C 146 115 82
Inlet Manifold Pressure KPAa 230 178 126
Inlet Manifold Temperature (10) °C 38 35 33
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 493 501 501
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.67 4.71 4.98
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.84 5.89 6.23
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.24 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
AIR INLET TEMP.
45 1.17 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21 1.21
40 1.11 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
35 1.05 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
30 1.00 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02 1.02
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1954-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
349
®
G3512 LE Gas Generator Set Engine Performance
Jacket Water Outlet Temperature (°C) 99 Air Fuel Ratio Control Required
Ignition System EIS Minimum Fuel Pressure (kPAg) 10
Exhaust Manifold DRY Methane Number at Conditions Shown 80
Combustion System Type LOW EMISSION Rated Altitude (m) 350
at 25°C Design Temperature
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.28 9.64 10.4
Air Flow (Wet, @ 25°C, 96 kPaa) Nm3/bkW-hr 4.15 4.28 4.42
Air Mass Flow (Wet) kg/bkW-hr 5.36 5.52 5.71
Compressor Out Pressure KPAa 227 190 149
Compressor Out Temperature °C 135 109 78
Inlet Manifold Pressure KPAa 217 169 120
Inlet Manifold Temperature (10) °C 37 34 33
Timing (11) °BTDC 24 24 24
Exhaust Stack Temperature °C 496 501 505
Exhaust Gas Flow (Wet, @ stack temperature, 99 kPaa) Nm3/bkW-hr 4.45 4.58 4.75
Exhaust Gas Mass Flow (Wet) kg/bkW-hr 5.56 5.73 5.93
G3512
Noise - Exhaust @ 1.5 m 111 dBA
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.25 1.30 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32 1.32
AIR INLET TEMP.
45 1.19 1.23 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
40 1.12 1.16 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18 1.18
35 1.05 1.09 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
30 1.00 1.03 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1957-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
351
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.8 10.06 10.75
G3512
G3512
50 0.94 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67 0.65
AIR INLET TEMP.
45 0.96 0.93 0.90 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.66
40 0.98 0.95 0.92 0.89 0.86 0.84 0.81 0.79 0.76 0.74 0.72 0.70 0.67
35 0.99 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
30 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.81 0.79 0.77 0.74 0.72 0.70
25 1.00 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71
20 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
15 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
(°C) 10 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.23 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26 1.26
AIR INLET TEMP.
45 1.17 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
40 1.11 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
35 1.04 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
30 1.00 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01 1.01
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1966-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
353
®
G3512 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.49 9.84 10.53
G3512
G3512
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.24 1.29 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31 1.31
AIR INLET TEMP.
45 1.18 1.22 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24 1.24
40 1.11 1.16 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
35 1.05 1.09 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11 1.11
30 1.00 1.02 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04 1.04
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM1969-01 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
355
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.48 11.11 12.36
G3508
G3508
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.35 1.42 1.49 1.55 1.62 1.69 1.76 1.77 1.77 1.77 1.77 1.77 1.77
AIR INLET TEMP.
45 1.26 1.32 1.39 1.46 1.52 1.59 1.66 1.67 1.67 1.67 1.67 1.67 1.67
40 1.16 1.23 1.29 1.36 1.42 1.49 1.56 1.57 1.57 1.57 1.57 1.57 1.57
35 1.07 1.13 1.20 1.26 1.33 1.39 1.46 1.47 1.47 1.47 1.47 1.47 1.47
30 1.00 1.04 1.10 1.16 1.23 1.29 1.36 1.36 1.36 1.36 1.36 1.36 1.36
25 1.00 1.00 1.00 1.06 1.13 1.19 1.26 1.26 1.26 1.26 1.26 1.26 1.26
20 1.00 1.00 1.00 1.00 1.03 1.09 1.15 1.16 1.16 1.16 1.16 1.16 1.16
15 1.00 1.00 1.00 1.00 1.00 1.00 1.05 1.06 1.06 1.06 1.06 1.06 1.06
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5205-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
357
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.76 11.4 12.81
G3508
G3508
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.37 1.44 1.52 1.59 1.66 1.74 1.81 1.82 1.82 1.82 1.82 1.82 1.82
AIR INLET TEMP.
45 1.27 1.34 1.41 1.48 1.56 1.63 1.70 1.71 1.71 1.71 1.71 1.71 1.71
40 1.17 1.24 1.31 1.38 1.45 1.52 1.60 1.60 1.60 1.60 1.60 1.60 1.60
35 1.07 1.14 1.21 1.28 1.35 1.42 1.49 1.50 1.50 1.50 1.50 1.50 1.50
30 1.00 1.04 1.10 1.17 1.24 1.31 1.38 1.39 1.39 1.39 1.39 1.39 1.39
25 1.00 1.00 1.00 1.07 1.14 1.20 1.27 1.28 1.28 1.28 1.28 1.28 1.28
20 1.00 1.00 1.00 1.00 1.03 1.10 1.17 1.17 1.17 1.17 1.17 1.17 1.17
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5105-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
359
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.48 11.11 12.36
G3508
G3508
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.35 1.42 1.49 1.55 1.62 1.69 1.76 1.77 1.77 1.77 1.77 1.77 1.77
AIR INLET TEMP.
45 1.26 1.32 1.39 1.46 1.52 1.59 1.66 1.67 1.67 1.67 1.67 1.67 1.67
40 1.16 1.23 1.29 1.36 1.42 1.49 1.56 1.57 1.57 1.57 1.57 1.57 1.57
35 1.07 1.13 1.20 1.26 1.33 1.39 1.46 1.47 1.47 1.47 1.47 1.47 1.47
30 1.00 1.04 1.10 1.16 1.23 1.29 1.36 1.36 1.36 1.36 1.36 1.36 1.36
25 1.00 1.00 1.00 1.06 1.13 1.19 1.26 1.26 1.26 1.26 1.26 1.26 1.26
20 1.00 1.00 1.00 1.00 1.03 1.09 1.15 1.16 1.16 1.16 1.16 1.16 1.16
15 1.00 1.00 1.00 1.00 1.00 1.00 1.05 1.06 1.06 1.06 1.06 1.06 1.06
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5107-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
361
®
G3508 TA Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 10.76 11.4 12.81
G3508
G3508
50 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77
AIR INLET TEMP.
45 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78
40 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79
35 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80
30 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.84 0.82
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.98 0.95 0.92 0.89 0.86
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.37 1.44 1.52 1.59 1.66 1.74 1.81 1.82 1.82 1.82 1.82 1.82 1.82
AIR INLET TEMP.
45 1.27 1.34 1.41 1.48 1.56 1.63 1.70 1.71 1.71 1.71 1.71 1.71 1.71
40 1.17 1.24 1.31 1.38 1.45 1.52 1.60 1.60 1.60 1.60 1.60 1.60 1.60
35 1.07 1.14 1.21 1.28 1.35 1.42 1.49 1.50 1.50 1.50 1.50 1.50 1.50
30 1.00 1.04 1.10 1.17 1.24 1.31 1.38 1.39 1.39 1.39 1.39 1.39 1.39
25 1.00 1.00 1.00 1.07 1.14 1.20 1.27 1.28 1.28 1.28 1.28 1.28 1.28
20 1.00 1.00 1.00 1.00 1.03 1.10 1.17 1.17 1.17 1.17 1.17 1.17 1.17
15 1.00 1.00 1.00 1.00 1.00 1.00 1.06 1.07 1.07 1.07 1.07 1.07 1.07
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5106-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5900-00 on page 8
363
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.78 10.23 10.97
G3508
G3508
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.57 1.67 1.71 1.71 1.71 1.71 1.71 1.71 1.71 1.71 1.71 1.71 1.71
AIR INLET TEMP.
45 1.41 1.52 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56 1.56
40 1.26 1.36 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41 1.41
35 1.11 1.21 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25 1.25
30 1.00 1.06 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10 1.10
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5231-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
365
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.55 9.99 10.81
G3508
G3508
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.61 1.73 1.84 1.84 1.84 1.84 1.84 1.84 1.84 1.84 1.84 1.84 1.84
AIR INLET TEMP.
45 1.44 1.56 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68 1.68
40 1.28 1.39 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51 1.51
35 1.12 1.23 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34 1.34
30 1.00 1.06 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17 1.17
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5232-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
367
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.44 9.81 10.52
G3508
G3508
50 0.96 0.93 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69 0.67
AIR INLET TEMP.
45 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
40 0.99 0.96 0.94 0.91 0.88 0.85 0.83 0.80 0.78 0.75 0.73 0.71 0.69
35 1.00 0.98 0.95 0.92 0.89 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
30 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71
25 1.00 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72
20 1.00 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73
15 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.79 0.77 0.75
(°C) 10 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.83 0.81 0.78 0.76
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.46 1.54 1.58 1.58 1.58 1.58 1.58 1.58 1.58 1.58 1.58 1.58 1.58
AIR INLET TEMP.
45 1.33 1.42 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45 1.45
40 1.21 1.29 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33 1.33
35 1.09 1.17 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20 1.20
30 1.00 1.05 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08 1.08
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5233-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
369
®
G3508 LE Gas Generator Set Engine Performance
Engine Data
Specific Fuel Consumption (BSFC) (1) MJ/bkW-hr 9.17 9.61 10.3
G3508
G3508
50 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70 0.68
AIR INLET TEMP.
45 0.99 0.97 0.94 0.91 0.88 0.86 0.83 0.80 0.78 0.76 0.73 0.71 0.69
40 1.00 0.98 0.95 0.92 0.90 0.87 0.84 0.82 0.79 0.77 0.74 0.72 0.70
35 1.00 1.00 0.97 0.94 0.91 0.88 0.86 0.83 0.81 0.78 0.76 0.73 0.71
30 1.00 1.00 0.98 0.95 0.93 0.90 0.87 0.84 0.82 0.79 0.77 0.75 0.72
25 1.00 1.00 1.00 0.97 0.94 0.91 0.89 0.86 0.83 0.81 0.78 0.76 0.73
20 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.87 0.85 0.82 0.80 0.77 0.75
15 1.00 1.00 1.00 1.00 0.97 0.94 0.92 0.89 0.86 0.84 0.81 0.78 0.76
(°C) 10 1.00 1.00 1.00 1.00 0.99 0.96 0.93 0.90 0.88 0.85 0.82 0.80 0.77
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
50 1.49 1.58 1.67 1.67 1.67 1.67 1.67 1.67 1.67 1.67 1.67 1.67 1.67
AIR INLET TEMP.
45 1.36 1.45 1.54 1.54 1.54 1.54 1.54 1.54 1.54 1.54 1.54 1.54 1.54
40 1.23 1.31 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40 1.40
35 1.09 1.18 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27 1.27
30 1.00 1.05 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14 1.14
25 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
20 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
15 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
(°C) 10 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00
0 250 500 750 1000 1250 1500 1750 2000 2250 2500 2750 3000
ALTITUDE (METERS ABOVE SEA LEVEL)
DM5234-00 Data is intended to be used with Gas Engine Performance Book Parameters – DM5901-00 on page 9
371
®