Documente Academic
Documente Profesional
Documente Cultură
3.Foaming
Chemical reactions begin after the pouring of the slurry. Bubbles appear evenly in the mould structure.
The bubbles emerging at the time will determine the performance of AAC panels.
4.Cutting
After the structure gains its early strength foaming and waiting, cut with piano wires and get the needed
length, width, and thickness of the panels.
5.Autoclave Treatment
Use autoclaves to treat AAC panels and make them hardened in high-temperature and high-pressure
steams.
6.Post-Processing
Decorative patterns will be made on the surfaces of the autoclaved panels that have been treated in
autoclaves, according to the customer’s requirements.
7.Quality Inspection
All panels will undergo strict quality inspection in order that their good quality is ensured.
8.Delivery
Only products strictly inspected can be delivered.
Features of the AAC panels and AAC Blocks
Heat Insulation A lot of micro and small air holes that are inside of
the AAC panel form a static air layer in the material and make the rate of
heat transmission of only 0.11W/m.K.
The function of heat insulation and preservation of the AAC panel is 10 time of
common concrete. The function
of heat preservation of AAC panel at 125mm thickness is same as 370mm wall of soil-
block.
Load-bearing The AAC panel can bear wind load, snow load and
dynamic load.
There are following types of the AAC panels:
Outside wall panel
Inner wall panel
Roof panel
Floor panel
The steel ribs inside of AAC panel are arranged by CAD
according to loading situation, that the capacity of loading is obtained.
In general, the loads of building are:
Constant load (incl. self weight and floors)
Living load
Snow load
Wind load
The effect of earthquake