0 evaluări0% au considerat acest document util (0 voturi)
119 vizualizări2 pagini
The document provides instructions for performing a soldier pile retention mode analysis in Wallap. It includes defining soil properties as both drained and undrained, soil strata depths, groundwater level, wall and pile properties, anchors, loads, stages of analysis including surcharge, excavation and anchor installation, factors of safety calculations, and beam model options. The analysis will model sequential excavation stages, installing anchors from the bottom up, and changing soil properties from undrained to drained conditions to calculate lateral stability factors of safety.
Descriere originală:
Titlu original
SOLDIER PILE RETENTION MODE ANALYSIS IN WALLAP.docx
The document provides instructions for performing a soldier pile retention mode analysis in Wallap. It includes defining soil properties as both drained and undrained, soil strata depths, groundwater level, wall and pile properties, anchors, loads, stages of analysis including surcharge, excavation and anchor installation, factors of safety calculations, and beam model options. The analysis will model sequential excavation stages, installing anchors from the bottom up, and changing soil properties from undrained to drained conditions to calculate lateral stability factors of safety.
The document provides instructions for performing a soldier pile retention mode analysis in Wallap. It includes defining soil properties as both drained and undrained, soil strata depths, groundwater level, wall and pile properties, anchors, loads, stages of analysis including surcharge, excavation and anchor installation, factors of safety calculations, and beam model options. The analysis will model sequential excavation stages, installing anchors from the bottom up, and changing soil properties from undrained to drained conditions to calculate lateral stability factors of safety.
Define soil strata – always choose layer depth from pile top. Define initial ground water level. No need to create pore water profile, unless required. Define Wall/ pile – Soldier pile width = pile diameter; Passive mobilization factor = 3; F.E length would be automatically set by program; Young modulus of wall = 2 x 107kPa; Moment of inertia per unit length of wall = moment of inertia of pile/spacing; Define a Yield Moment = No. Define anchors – tension allowed; slab represented as anchors in long term (tension allowed). Define Loads – define any horizontal load or moment in addition to the soil pressure. Define Surcharge from boundary. Define stages – reset lateral displacement to zero after applying surcharge; In ULS change soil from undrained conditions to drained condition (Ko will not be reset). o SLS Apply Surcharge Reset displacement to zero Excavate to 500 mm below anchor level. Install anchors Excavate in stages up to bulk excavation level Analyse o ULS Apply Surcharge Reset displacement to zero Excavate to 500 mm below anchor level. Install anchors Excavate in stages up to bulk excavation level Install slabs from bottom to top Remove anchors Change soil parameters from undrained to drained Analyse Define FOS – Strength factor method (Limit state bot designated); FOS for computing wall depth = 1; Minimum equivalent fluid density = 5 kN/m3; Maximum depth of water filled tension crack = 0 (unless required); Calculate active/passive limit pressures by wedge stability = No. Define BM options – Subgrade reaction model; Open tension crack analysis = No; Soil arching = No; Non-linear modulus parameter = retention height. FOS of lateral stability should be ≥ 1.5 (provided at the top of results page)