Documente Academic
Documente Profesional
Documente Cultură
D FLIP FLOP USING IC7474 and JK MASTER SLAVE FLIP FLOP IC7473
CIRCUIT :
pin diagram:
TRUTH TABLE :
PROCEDURE :
CIRCUIT :
pin diagram:
TRUTH TABLE:
PROCEDURE :
TRUTH TABLE:
PROCEDURE:
1. Make connections as per circuit diagram.
2. Connect pin no 16 to +5V DC and pin no 8 To GND.
3. Connect pin no 2,3,4 to switches on the trainer kit which acts like cascaded inputs A<B, A=B, A>B.
4. Make A<B, A>B = 0 and make A=B=1.
5. Connect inputs A's and B's to logic switches and give the inputs as shown in the truth table. .
6. Connect the outputs 5,6,7 to LEDs on the trainer kits and see the outputs..
7. Verify the outputs according to the truth table.
TRUTH TABLE:
PROCEDURE:
1. Make connections as per circuit diagram.
2. Connect pin no 16 to +5V DC and pin no 8 To GND.
3. Connect pin no 4,5,6 to switches on the trainer kit which acts like cascaded inputs G2A,G2B and
G1.
4. Make G2A = G2B=0 and make G1=1.
5. Connect inputs pin nos 1,2,3 which acts like A,B,C to logic switches and give the inputs as shown in
the truth table.
6. Observe the outputs 7,9,10,11,12,13,14,15 Which are connected to LEDS on the trainer kit to leds
on the trainer kits and see the outputs..
7. Verify the outputs according to the truth table.
AIM: To verify the Fuctionality table of 8X1 MUX (IC 74LS151))and 2X4 DEMUX (IC 74LS155)
CIRCUIT :
TRUTH TABLE OF IC 74LS151:
RESULTS: The Fuction table of 8X1 MUX (IC 74LS151) and 2X4 DEMUX (IC 74LS155).
5. DECADE COUNTER (IC74LS90)
5 0 0 0 0 0 1 0 1
6 0 0 0 0 0 1 1 0
7 0 0 0 0 0 1 1 1
8 0 0 0 0 1 0 0 0
9 0 0 0 0 1 0 0 1
10 0 0 0 0 0 0 0 0
PROCEDURE :
AIM: To verify the truth table of PARALLEL ACCESS SHIFT REGISTER (IC 74LS195)
TRUTH TABLE:
CIRCUIT:
PROCEDURE:
a)Parallel load mode: Apply clear =H ,. shift/load`=L and ABCD=abcd then upon the application
of clock signal register content QaQbQcQd=abcd.
c)Hold or No change mode: Unless the clock edge is applied register will hold the previous data
loaded.
d) Shift mode/serial input mode: when clear=H,shift/load=H register will be loaded with serial input
depending on signals J and K`.