Documente Academic
Documente Profesional
Documente Cultură
INTRODUCTION
P N P Transistor
N P N Transistor
Figure 1. Construction and circuit symbol for PNP and NPN transistors.
If, in the case of an NPN transistor, a positive voltage is applied to the collector (and the emitter
connected to the negative terminal to complete the circuit) no current will flow unless a small
current is allowed to flow through the base to the emitter. (For older types of transistor a small
leakage current, uncontrolled by the IB, but dependent on the temperature, flows between the emitter
and collector). The amount of collector current depends almost entirely on the amount of base
current and the first part of the experiment is concerned with determining the extent of this
dependence by plotting a set of curves known as the collector characteristics. The collector
characteristics are a family of curves showing the collector current flowing as a function of collector
voltage for various values of base current as shown in Figure 2. From the collector characteristics
the current amplification of the transistor may be determined.
Figure 2. Characteristic curves for a transistor
The symbol h refers to what are known as "hybrid parameters", of which there are four to describe
most of the circuit properties of a transistor at low frequencies. The F identifies the h-parameter as
the Forward Current Amplification Factor and the E refers to circuit operation with the Emitter
common to both the input and output circuits surrounding the transistor, as shown in Figure 3.
A small current IB in the input circuit will control a larger current and
IC = hFE IB (2)
In most applications, such as amplifiers or radios, an alternating (AC) signal current is amplified.
An alternating current flows in both forward and reverse directions but transistor action occurs only
for current flowing in one direction through the transistor. This is achieved by adding a D.C. bias to
the signal. The forward half-cycles of the A.C. signal add to the bias current and the reverse half-
cycles subtract from it. To measure the amplification produced by the transistor for A.C. signals we
use
Δ IC (X)
h fe =
Δ IB (X)
(3)
at a constant VCE as shown in Figure 4.