Documente Academic
Documente Profesional
Documente Cultură
Assignment 1
Subject: Analog Electronics Semester 4th
Department: Electrical Engineering
Last Date of submission: 11 April 2019 (Before 1:30 pm) Dated:08 April 2019.
Q1. The value of β for a transistor is 100. If the value of emitter current is 10 mA. Then determine the
values of collector and base currents.
Q2. The value of α for a BJT is 0.95. Find the value of β. Also find value of α, if β changes to 100.
Q3. For an NPN transistor the IE =10 mA and β = 100 . Determine IC and IB.
Q4. For the circuit shown determine the operating point. Assume β=100 , RB=530k,Rc=2k,Vcc=6V (Fig 1).
VCC
RB RC
RC
AC
Figure 1 Figure 2
Q5. For the circuit with β=75. Determine IB, IC,VCE. Given Rc=800,Rb=200K, Vcc is 20V. (Figure 1).
Q6. For the circuit with β=100. Determine RB,VC(between collector and ground). Given Rc=0.3K, Vcc is
12V. (Figure 1).
Q7. Determine Region of operation for a BJT with ICmax=7mA,VCEmax=17v and PCmax=40mW assume
appropriate characteristics.
Q8. The common-emitter current gain of the transistor shown in figure (a) is β=75. The voltage VBE in on
(d) (e)
Q11. .For the transistor in the circuit of figure (d), β=100. Calculate Q point.
Q12. Determine the region of operation for the transistor shown in figure (e).
(f) (g) (h)
Q13. For the circuit shown in figure (f) if the β=60. Calculate VECQ
Q14. For the network of Figure (g)
a. Determine re.
b. Find Zi (with ro =∞Ω).
c. Calculate Zo (with ro =∞Ω).
d. Determine Av (with ro =∞Ω).
Q15. 10. Calculate IB, IC, VCE, VC, VE, VB, VBC (refer figure h)
Q16. In the circuit shown in figure (i), voltage VE= 4V, Calculate β and α for the circuit.
Q17. The circuit shown in figure (j) has a Q-point of (2A, 12V) when β= 60 calculate the value of RC and RB
Q18. For the circuit in fig. figure (k), if β=60, calculate the value of VECQ
Note:
Students are free to discuss the problems faced in solving the test sheet during lunch
break/free classes.
The assignment has to be strictly submitted on time. Any submission after the deadline time
will not be accepted.
The assignment is to be submitted on plane sheets stapled together without any file cover.
In case the deadline date is not a working day, then the next working day with same time
stamp would be considered as last date for submission.