Sunteți pe pagina 1din 2

A)What is a delay line canceller?

Illustrate the concept of blind speeds based on


the frequency response of a single delay line canceller.[2M]
B)Differentiate MTI and pulse Doppler Radar.[1.5M]
C) What is the highest frequency that a radar can be operated if it is required to have a
maximum unambiguous range of 350 km and no blind speeds less than 100 m/s.[1.5M]
A)With the help of a suitable block diagram, discuss the Sequential lobbing type
of tracking technique in a tracking radar system.[2.5M]
B) Derive the impulse response characteristic for a matched filter. [2.5M]
(a) Draw the block diagram of an amplitude comparison mono pulse tracking
radar in azimuth and elevation directions. Explain the functioning of this two
dimensional tracking radar[2.5M]

(b) Define noise figure and obtain the expression for the noise figure of 3
networks in cascade.

(a) Describe the deferent types of feeds used for parabolic reflector

(b) Discuss and compare the characteristics of A-Scope and P-Scope displays.

(a) Draw and explain the frequency response characteristics of an MTI using
range gates and filters.

(b) What are the advantages of non -coherent MTI radar.

(a) Give the basic reasons for poor tracking at low angle.

(b) Compare the tracking techniques

a)Derive the efficiency of Non-matched filters.[2]

(b) Distinguish between the matched and non matched filters[1M]

C) Explain the Branch line Duplexer in the Radar system.[2M]

(a) Explain Various types of radar antennas

(b) Define noise figure and noise temperature of a receiver system.

(a) What is the principle of MTI radar?

(b) Distinguish between MTI radar and pulse Doppler radar. What are the
applications of delay line cancellers?

. (a) Explain the block diagram of amplitude comparison mono pulse radar for
extracting error signals in both elevation and azimuth.

(b) What are the advantages of mono pulse radar over conical scan radar?
(a) Explain the principle and process of correlation detection.

(b) Three network units each of 6 dB noise figure and 10 dB, 6 dB and 3 dB gains
respectively are cascaded calculate the overall noise figure of the system

Write short notes on:

(a) Duplexers. (b) Radar Displays. (c) Radiation Pattern.

(d) Types of Feeds to Radar Antennas

S-ar putea să vă placă și