Documente Academic
Documente Profesional
Documente Cultură
Set parameters:
1: Bores number (3-150)
2: Distances between bores
are equal or not
4: Measurement
configuration – number of
sensor position where data
will be taken.
In case of “3 points”
configuration it is
recommended to enter bores
diameters (3: Diam.) it improves result precision. However if diameters are not entered,
result calculation still is possible.
In case of “8 points” – result is calculated with higher precision due to averaging.
5: Set Horizontal or Vertical bores orientation. In case of Vertical – inclinometer will not
work. One should check measurement position manually.
8: Sensor data or manual data enter
Measurement
position data
If sensor position differs from
proper measurement position Bore center
warning start blinking. (If displacement
inclinometer is ON)
Measurement position
indicated on LCD by radial
line. Current receiver (“M”)
inclination is indicated by
blinking line.
Place receiver into
measurement position and
press “Start” to take
readings for current position.
When readings for all
position will be taken bore
center displacement will be calculated.
When all bore planes are
calculated, press “Menu” –
result will display
Press [5] key to switch
table or H, V plot.
Press [8] key to save file.