Documente Academic
Documente Profesional
Documente Cultură
Trouble Codes
Posted on January 18, 2013 by admin — No Comments ↓
Malfunction Indicator Lamp (MIL) also called Check-Engine Light (CEL) comes on to
indicate engine related
faults. DLC or OBDII plug shown above is used to access Diagnostic Trouble Code (DTC).
Note: If this port is not available simply ground Pin E29 (SCS) direct on the ECU to
read the CEL
DLC – Locate the OBDII Data Link Connector (DLC) under the RSX/EP3 driver’s side
dash.
IMPORTANT: Make sure you are connecting only the correct terminals as shown,
otherwise you risk
Turn the ignition key to the ON (II) position, but do not start the engine. Carefully observe
the CEL
and reference the DTC Trouble code chart below to chart below to resolve issue.
Service
Manual
Page
Reference
CEL
Flash OBDII DC5 EP3
Code DTC RSX Civic Description
Engine Control
Module (ECM) /
Powertrain Control
Module (PCM)
11- 11- Internal Circuit
– P1607 104 96 Malfunction
Manifold Absolute
Pressure (MAP)
11- 11- Sensor Circuit Low
3 P0107 61 52 Voltage
Manifold Absolute
Pressure (MAP)
11- 11- Sensor Circuit High
3 P0108 62 53 Voltage
Crankshaft Position
11- 11- (CKP) Sensor No
4 P0335 87 78 Signal
Crankshaft Position
(CKP) Sensor
11- 11- Intermittent
4 P0336 87 78 Interruption
Manifold Absolute
Pressure (MAP)
Sensor Signal
11- 11- Lower Than
5 P1128 63 54 Expected
Manifold Absolute
Pressure (MAP)
Sensor Signal
11- 11- Higher Than
5 P1129 63 54 Expected
Engine Coolant
Temperature (ECT)
11- 11- Sensor Circuit Low
6 P0117 66 58 Voltage
Engine Coolant
Temperature (ECT)
11- 11- Sensor Circuit High
6 P0118 67 59 Voltage
Throttle Position
11- 11- (TP) Sensor Circuit
7 P0122 68 60 Low Voltage
Throttle Position
11- 11- (TP) Sensor Circuit
7 P0123 71 62 High Voltage
Throttle Position
(TP) Sensor Signal
11- 11- Lower Than
7 P1121 72 63 Expected
Throttle Position
(TP) Sensor Signal
11- 11- Higher Than
7 P1122 72 63 Expected
Intake Air
Temperature (IAT)
11- 11- Sensor Circuit Low
10 P0112 64 55 Voltage
Intake Air
Temperature (IAT)
11- 11- Sensor Circuit High
10 P0113 65 56 Voltage
Barometric
Pressure (BARO)
Sensor
11- 11- Range/Performance
13 P1106 92 83 Problem
Barometric
Pressure (BARO)
11- 11- Sensor Circuit Low
13 P1107 92 83 Voltage
Barometric
Pressure (BARO)
11- 11- Sensor Circuit High
13 P1108 92 83 Voltage
Vehicle Speed
11- 11- Sensor (VSS)
17 P0500 89 80 Circuit Malfunction
Electrical Load
11- 11- Detector (ELD)
20 P1297 100 92 Circuit Low Voltage
Electrical Load
11- 11- Detector (ELD)
20 P1298 101 93 Circuit High Voltage
Engine Control
Module (ECM) /
Powertrain Control
Module (PCM)
Power Source
11- 11- Circuit Unexpected
34 P0563 90 81 Voltage
Serial
22- 22- Communication
39 P0600 175 172 Link Malfunction
Variable Valve
Timing Control
(VTC) Oil Control
11- 11- Solenoid Valve
56 P0010 126 118 Malfunction
Variable Valve
Timing Control
11- 11- (VTC) System
56 P0011 127 119 Malfunction
Camshaft Position
11- 11- (CMP) Sensor No
57 P0340 129 121 Signal
Variable Valve
11- 11- Timing Control
57 P0341 130 122 (VTC) Phase Gap
Camshaft Position
(CMP) Sensor
11- 11- Intermittent
57 P0344 129 121 Interruption
Secondary Heated
Oxygen Sensor
(Secondary HO2S)
11- 11- (Sensor 2) Circuit
63 P0137 74 65 Low Voltage
Secondary Heated
Oxygen Sensor
(Secondary HO2S)
11- 11- (Sensor 2) Circuit
63 P0138 75 66 High Voltage
Secondary Heated
Oxygen Sensor
(Secondary HO2S)
11- 11- (Sensor 2) Slow
63 P0139 76 67 Response
Secondary Heated
Oxygen Sensor
(Secondary HO2S)
11- 11- (Sensor 2) Heater
65 P0141 77 68 Circuit Malfunction
Catalyst System
11- 11- Efficiency Below
67 P0420 186 167 Threshold
Automatic
Transaxle System
Malfunction
(refer to the A/T
P0700 DTC
P07xx Troubleshooting
70 P17xx 14-8 Index)
Engine Coolant
Temperature (ECT)
Sensor
11- 11- Range/Performance
86 P0116 66 57 Problem
Evaporative
Emission (EVAP)
Control System
11- 11- Leakage (Fuel Tank
90 P1456 193 175 System)
Evaporative
Emission (EVAP)
Control System
11- 11- Leakage (EVAP
90 P1457 196 180 Canister System)
Intake Manifold
Runner Control
(IMRC) System
11- Malfunction (Low
106 P1077 173 rpm)
Intake Manifold
Runner Control
(IMRC) System
11- Malfunction (High
106 P1078 175 rpm)
Intake Manifold
Runner Control
(IMRC) Valve
11- Position Sensor
107 P0662 172 Circuit High Voltage
Positive Crankcase
11- Ventilation (PCV)
109 P1505 168 Air Leakage