Documente Academic
Documente Profesional
Documente Cultură
System requirements:
inLab 3D software (version 3.60 or higher). An MC XL milling unit is required if the
mesostructures are to be milled in-house.
Installation instructions:
Download the file inLab_3D_for_abutments_V3_65.zip from the download section of
the Sirona website (file size: approx. 350 MB).
Unpack the zip file (e.g. with winzip).
Double-click setup.exe and follow the on-screen instructions.
Please note that this version is not fully compatible with inLab 3D V3.60. Initially, the
data will be downloaded to the MC XL milling unit. As from November, this will be
rectified by means of a patch (V3.65) for the existing inLab 3D software.
Restorations which have been designed using V3.10 cannot be opened and milled
using V3.65.
Overview of the most important new features compared with version 3.10:
Modified scanning process
Before performing the scan (e. g. with the aid of the inEos scanner), the titanium
base is screwed into the laboratory model. The enclosed scan body for TiBase
(scanbodies for CAMLOG® must be ordered separately) is then attached.
The scanbodies should be used only once.
October 2009
NEW: Sirona TiBase titanium bases
As from the end of October,
Sirona will begin supplying
titanium bases for four
different implant systems.
October 2009