Documente Academic
Documente Profesional
Documente Cultură
Table of Contents
Experiment Description.................................................................................................................. 1
Experiment Description.............................................................................................................. 1
Version Introduction................................................................................................................... 1
Experiment Objectives............................................................................................................... 1
Experiment Tasks....................................................................................................................... 1
Relevant Materials..................................................................................................................... 1
Chapter 1 Manual Aggregation Experiment Guide.......................................................................2
1.1 Networking and Service Description....................................................................................2
1.2 Command Line List.............................................................................................................. 2
1.3 Configuration flow................................................................................................................ 2
1.4 Configuration procedure....................................................................................................... 3
1.5 Result Verification................................................................................................................ 3
1.6 Configuration Reference...................................................................................................... 4
Chapter 2 Static LACP Aggregation Experiment Guide...............................................................6
2.1 Networking and Service Description....................................................................................6
2.2 Command Line List.............................................................................................................. 6
2.3 Configuration flow................................................................................................................ 7
2.4 Configuration procedure....................................................................................................... 7
2.5 Result Verification................................................................................................................ 7
2.6 Configuration Reference...................................................................................................... 9
Chapter 3 Dynamical LACP Aggregation Experiment Guide....................................................10
3.1 Networking and Service Introduction:.................................................................................10
3.2 Command Line List............................................................................................................ 10
3.3 Configuration flow.............................................................................................................. 10
3.4 Configuration procedure..................................................................................................... 10
3.5 Result Verification............................................................................................................... 11
3.6 Configuration Reference.................................................................................................... 12
Experiment Description
Experiment Description
This experiment guide introduces the configuration methods and configuration
procedure of the Ethernet link aggregation on S3900 serials LANswitches. It is
designed to help you understand the configuration methods and configuration
procedure of the Ethernet link aggregation.
Version Introduction
This guide is applicable to VRP versions 3.10
Experiment Objectives
Understand configuration procedures of different mode of Ethernet link
aggregation
Get familiar with the configuration commands of different mode of Ethernet link
aggregation
Experiment Tasks
Configure Ethernet link aggregation manually
Configure static LACP Ethernet link aggregation
Configure dynamical LACP Ethernet link aggregation
Relevant Materials
S3900 Operation Manual
S3900 Command Manual
Table 1.1
Operation commands
Create an
aggregation group
Add an Ethernet
port into the
aggregation group
Figure 1.2
------------------------------------------------------------------------------
Ethernet1/0/1:
Selected AggID: 1
Local:
Remote:
G -- Defaulted, H -- Expired
Aggregation Description:
Local:
--------------------------------------------------------------------------------
Ethernet1/0/1 S 32768 1 {}
Ethernet1/0/2 S 32768 1 {}
Ethernet1/0/3 S 32768 1 {}
Ethernet1/0/4 S 32768 1 {}
Remote:
--------------------------------------------------------------------------------
Ethernet1/0/1 0 0 0 0x0,0000-0000-0000 {}
Ethernet1/0/2 0 0 0 0x0,0000-0000-0000 {}
Ethernet1/0/3 0 0 0 0x0,0000-0000-0000 {}
Ethernet1/0/4 0 0 0 0x0,0000-0000-0000 {}
I. Configuration of SWA
[SWA]link-aggregation group 1 mode manual
[SWA]interface Ethernet 1/0/1
[SWA-Ethernet1/0/1]port link-aggregation group 1
[SWA-Ethernet1/0/1]quit
[SWA]interface Ethernet 1/0/2
[SWA-Ethernet1/0/2]port link-aggregation group 1
[SWA-Ethernet1/0/2]quit
[SWA]interface Ethernet 1/0/3
[SWA-Ethernet1/0/3]port link-aggregation group 1
[SWA-Ethernet1/0/3]quit
[SWA]interface Ethernet 1/0/4
[SWA-Ethernet1/0/4]port link-aggregation group 1
[SWA-Ethernet1/0/4]quit
Figure 1.3
Operation Commands
Create an
aggregation group
Add an Ethernet
port into the
aggregation group
Figure 1.4
------------------------------------------------------------------------------
--
Ethernet1/0/1:
Selected AggID: 1
Local:
Remote:
G -- Defaulted, H -- Expired
Aggregation Description:
Local:
------------------------------------------------------------------------------
--
Remote:
------------------------------------------------------------------------------
--
I. Configuration of SWA
[SWA]link-aggregation group 1 mode static
[SWA]interface Ethernet 1/0/1
[SWA-Ethernet1/0/1]port link-aggregation group 1
[SWA-Ethernet1/0/1]quit
[SWA]interface Ethernet 1/0/2
[SWA-Ethernet1/0/2]port link-aggregation group 1
[SWA-Ethernet1/0/2]quit
[SWA]interface Ethernet 1/0/3
[SWA-Ethernet1/0/3]port link-aggregation group 1
[SWA-Ethernet1/0/3]quit
[SWA]interface Ethernet 1/0/4
[SWA-Ethernet1/0/4]port link-aggregation group 1
[SWA-Ethernet1/0/4]quit
Figure 1.5
Table 5.1
Operation Commands
Enable LACP on the pert
lacp enable
Enable LACP
Figure 1.6
------------------------------------------------------------------------------
--
Ethernet1/0/1:
Selected AggID: 1
Local:
Remote:
G -- Defaulted, H -- Expired
Aggregation Description:
Local:
--------------------------------------------------------------------------------
Remote:
--------------------------------------------------------------------------------