Documente Academic
Documente Profesional
Documente Cultură
rakibbiswas786@gmail.com ▼
Unit 9 - Week 7 -
DC-DC SWITCHED CONVERTERS
Register for Certification exam
Course outline
Assignment-0
Week 1
Week 2
Week 3
Input-output relationship
Primary configurations
Boost converter
Buck-Boost converter
1) The main reason to use switched mode DC-DC converters rather than linear DC-DC 1 point
converters is ___________
discrete control
high bandwidth
delivers more power to load for a given input power
high reliability
2) In a buck converter circuit, the value of inductance is 1mH, capacitance is 100 uF, load
resistance Ro is 100 ohms. The switching frequency is 25kHz. The input is set at 10V. What is the
voltage ripple (in millivolts) expected across the capacitor if the output voltage is 5V? (Assume all
components to be ideal)
1 point
3) In a buck converter circuit, the value of inductance is 1mH, capacitance is 100 uF, load
resistance Ro is 100 ohms. The switching frequency is 25kHz. The input is set at 10V. For an
output voltage of 5V, what is the expected peak to peak inductor current ripple (in amps) ?
1 point
4) In a buck converter circuit, the value of inductance is 1mH, capacitance is 100 uF. The
switching frequency is 25kHz. The input is set at 10V. For an output voltage of 5V, what is the
maximum value of load resistor (in ohms) that can be connected such that the inductor current is
continuous ?
1 point
5) In a boost converter, the switching frequency is 100kHz. The input supply is at 24V and the
output is at 48V supplying a 10 ohms load. What is the average value of supply current (in amps)
being drawn?
1 point
6) In a buck-boost converter, the switching frequency is 50kHz. The input voltage is 12V and the
output voltage is 24V. The load current is 1A. What is the duty ratio?
1 point
7) In a buck-boost converter, the switching frequency is 50kHz. The input voltage is 12V and the
output voltage is 24V. The load current is 1A. What is the average inductor current (in amps)?
1 point
8) In a buck-boost converter, the switching frequency is 50kHz. The input voltage is 12V and the
output voltage is 24V. The load current is 1A. What is the average input current (in amps)?
1 point
9) For a buck converter supplying 30V load at 5A, a 50V source is used. The converter is being
switched at 100kHz. Calculate the value of the inductor (in uH) if the minimum allowable load is
0.2A.
1 point
10)For a buck converter supplying 30V load at 5A, a 50V source is used. The converter is being
switched at 100kHz. If the output ripple is 5mV, calculate the value of the capacitor (in uF) for a
minimum allowable load of 0.2A.
1 point
You may submit any number of times before the due date. The final submission will be
considered for grading.
Submit Answers
Funded by
Powered by