Documente Academic
Documente Profesional
Documente Cultură
895 MPa
30ksi
Steel reinforcement grade Fy
Allowable = 0.5 * Fy
fc
Allowable tensile stress
In your hand calculation, the stress of reinforcement is obtained from the concre
In my opinion, the stress of reinforcement should be calculated as follows:
In your hand calculation, the stress of reinforcement is obtained from the concre
In my opinion, the stress of reinforcement should be calculated as follows:
Step 1. Determine the tensile force in the concrete.
Step 2. Determine the total area of reinforcement in the tensile zone.
Step 3. Calculate the stress of reinforcement by dividing the tensile force by the total area
What do you think about this?
206.8425 Mpa
41.368
0 Mpa
ained from the concrete stress using the modulus ratio, which, I think, is not correct.
ated as follows:
force by the total area of reinforcement.
kN
kNm
kNm
N/mm2
N/mm2
N/mm2
N/mm2
mm2
N Part1 only - Section Properties
mm2 360967 mm^2
N/mm2 226385.1 mm^2
201480.5 mm^2
7.31E+09 mm^4
5.22E+10 mm^4
5.08E+09 mm^4
279.4 mm
279.4 mm
628.054 mm
514.946 mm
0 mm^2
0 mm^2
3503.705 mm
0 mm
279.4 mm
514.9458 mm
-203.2 mm
628.0542 mm
203.2 mm
628.0542 mm
279.4 mm
-514.9458 mm
-279.4 mm
-514.9458 mm