Sunteți pe pagina 1din 10

!!!!!!!!

Valid for Audi A4 B8

Disclaimer: All the changes below will be done on your own risk!!!

Do not change anything if you do not know exactly what you are doing!!!

I assume no responsibility on any changes that you might do or have done!!!

!!!!!!!!!!

Disable After-wipe of windscreen wipers

Disable amber corner lights

Disable amber side markers

Disable Key warning (keyless models)

Disable LED 'wink' on turn signal

Disable "Lights are on" warning

Disable NAV & Phone warning messages while entering data at speed

Disable Seatbelt Chime

Enable Adaptive brake lights

Enable Ambient Interior Lighting Control

Enable Automatic Gear selection shown in DIS

Enable Automatic Hill Hold Assist 'lite'

Enable Auxiliary ventilation

Enable Battery meter

Enable DIS with Efficiency Program

Enable Double Disarm Beep

Enable DRL Selectable via MMI

Enable DRL

Enable Euro parking lights that turn on signal at night

Enable fog lamp to come on for the same side as that turn signal

Enable Front Turn Signals as Parking lights

Enable Gauge Test/Needle Sweep

Enable Hidden menu in MMI

Enable Import CDs to MMI's HD

Enable Independent Fogs control with high beams


Enable Lap Timer

Enable LEDs remain bright for parking lights

Enable Rear Tail Lights on with DRLs

Enable Release Parking Brake without putting foot on Brake

Enable Release Parking Brake without putting seatbelt

Enable Remote Operation windows&sunroof

Enable Reverse mirror tilt

Enable Speed through MMI

Enable TPMS

Enable VIM on MMI

Set Audi parking system - Switch OFF Speed

Set Custom ADS settings

Set Headlight washer - cycles

Set Headlight washer - duration

Adjust Consumption in DIS

Adjust LED Brightness

Audi A4/S4 B8

VCDS (VAG-COM) codes

Disable After-wipe of windscreen wipers

[09 – Cent. Elect.] [Coding - 07] -> [Dropdown] -> "x ** 8K1 955 119 ** WWS xxxx" -> Long Coding
Helper -> Byte 1

Bit 3 - Remove check mark (1 = active)

________________________________________

Disable amber corner lights

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 10

Submodule 0

Bit 3 - Set to 0 to disable amber side markers (U.S. vehicles)


________________________________________

Disable Key warning (keyless models)

[46 – Central Conv.] [Coding - 07] -> Long Coding Helper -> Byte 9

Bit 7 set to 0 (Uncheck)

________________________________________

Disable LED 'wink' on turn signal

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 3

Bit 2 - LEDs remain at full brightness with parking lights (1 = active)

Bit 7 - Turn off LED-strip DRLs with indicators (1 = active)

________________________________________

Disable "Lights are on" Warning

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 5

Bit 3 - Set to 0 to disable "lights are on" warning when you open the door.

________________________________________

Disable NAV & Phone warning messages while entering data at speed

[5F - Information Electr.] -> Adaptation -> Set channel 2 & 3 to 250

________________________________________

Disable Seatbelt Chime

[17 - Instruments] [Coding - 07] -> Long Coding Helper -> Byte 0

Bit 2-4 – Seat Belt Warning inactive

________________________________________

Enable Adaptive brake lights

[46 - Comfort System] [Coding - 07] -> Long Coding Helper -> Byte 8

Bit 0 – Emergency Brake Flashing via Turn Lights active (1 = active)

Bit 1 – Emergency Brake Flashing via Brake Lights active (1 = active)

________________________________________

Enable Ambient Interior Lighting Control

[Hidden menu] [car] [carmenuoperation] [interior light] Set to 5

[Hidden menu] [car] [cardevicelist] [interior light] Enable

Reset MMI
________________________________________

Enable Automatic Gear selection shown in DIS

[02 – Auto Trans] [Adaptation – 10]

Select “Single Gear Display” from top channel drop down menu

Select “D on/S on” from New value drop down menu

________________________________________

Enable Automatic Hill Hold Assist ‘lite’

[03 - ABS brakes][Security Access - 16] (Enter code presented by program)

[Coding – 07] -> Long Coding Helper -> Byte 1

Bit 6 set to 1 to enable hill hold assist.

________________________________________

Enable Auxiliary ventilation

[5F - Information Electr.] [Coding - 07] -> Long Coding Helper -> Byte 6

Bit 1 – Set to 1

[Hidden menu] [car] [cardevicelist] [Auxiliary heating] Enable

[08 - Auto HVAC] [Coding - 07] -> Long Coding Helper -> Byte 1

Bit 3 – Set to 1

Bit 4 – Set to 1

________________________________________

Enable Battery meter

[Hidden menu] [car] [cardevextdevicelist] [Battery] Enable

[Hidden menu] [car] [carmenuoperation] [Battery] Set to 5

Reset MMI

or

[56 - Radio] -> Adaption -> Channel 39, add 16 to your value

________________________________________

Enable DIS with Efficiency Program for MY2010+ (Not a complete Program without the Start/Stop
System)

[17 - Instruments] [Adaptation - 10] -> Channel 77

change 0 to 255
________________________________________

Enable Double Disarm Beep

[46 - Central Conv.] [Adaptation - 10] -> Channel 63

Add 4

________________________________________

Enable DRL Selectable via MMI

[09 – Cent. Elect.] -> [Coding – 07] -> Long Coding Helper -> Byte 3

Bit 5 set to 1

________________________________________

Enable DRL

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 2

Bit 1 = DRL via Front Side markers

Bit 2 = DRL via High Beams

Bit 3 = DRL via Fogs

Bit 4 = DRL via LEDs

Bit 6 = DRL via Side markers

Bit 7 = DRL via Tail lights

________________________________________

Enable Euro parking lights that turn on signal at night

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 9

Bit 0 - Set to 1

________________________________________

Enable fog lamp to come on for the same side as that turn signal

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 4

Bit 0 - Check the box or change :Bit 0 set to 1

________________________________________

Enable Front Turn Signals as Parking lights

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 10

Bit 0- Check the box or change :Bit 0 to 1

Once the change has been made you can enable the front turn signals as DRL's by making the
following change:

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 2
Bit 6 - Check the box or change :Bit 0 set to 1

________________________________________

Enable Gauge Test/Needle Sweep

[17 - Instruments] [Coding - 07] -> Long Coding Helper -> Byte 1

Bit 0 - Check the box for "Gauge Test/Needle Sweep active"

________________________________________

Enable Headlights on all the time

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 4

Bit 5 - Check the box or change :(Bit 5 Set to 1)

________________________________________

Enable Hidden menu in MMI

[5F - Information Electr.]

[Adaptation - 10] -> Channel 6

change 0 to 1

Use this hidden menu at your own risk.

Caution: Keep away from the "Bootloader"

________________________________________

Enable Import CDs to MMI's HD

[Hidden menu]

Main/Diagnose/Settings

Import Media

Set to 4 of 4 "Copy/Ripping"

________________________________________

Enable Independent Fogs control with high beams

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 4

Bit 1 – (Front) Uncheck the box or change :Bit 1 to 0

Bit 2 – (Rear) Uncheck the box or change :Bit 2 to 0

________________________________________

Enable Lap Timer

[17 - Instruments] [Coding - 07] -> Long Coding Helper -> Byte 1

Bit 3 - Check the box for "Lap Timer active"


______________________________________

Enable Remote Operation Windows and Sunroof

[46 - Cent. Conv.] [Coding - 07] -> [Long Coding Helper] Byte 2

Bit 2 - Set to 1

______________________________________

Enable Rear Tail Lights on with DRLs

[09 – Cent. Elect.] [Coding - 07] -> Long Coding Helper -> Byte 2

Bit 7 - DRL's via Tail Lets Active (1 = Active)

_____________________________________

Enable Release Parking Brake without putting foot on Brake

[53 - Parking Brake][Security Access - 16] (Enter code presented by program)

[Adaptation - 10] -> Channel 4 Set to 0

________________________________________

Enable Release Parking Brake without putting seatbelt

[53 - Parking Brake][Security Access - 16] (Enter code presented by program)

[Adaptation - 10] -> Channel 7 Set to 0

________________________________________

Enable Reverse mirror tilt

[52 Door Elect, Pass.] -> [Coding - 07] -> [Long Coding Helper] -> Byte 4

Bit 4 and Bit 2 set to 1

Bit 3 set to 1

________________________________________

Enable Speed through MMI

[56 - Radio] [Adaptation - 10] -> Channel 02, Set to 1

Does not work if NAV equiped

________________________________________

Enable TPMS

* You need the 1AT ABS unit – check your stickers (1AS does not work)

[Hidden menu] [car] [cardevicelist] [RDK] Enable

[Hidden menu] [car] [carmenuoperation] [Tires Air Pressure Control] Set to 5


[03 - ABS Brakes]

[Security Access - 16] (probably with login code: 61378)

[Coding - 07] -> Long Coding Helper -> Byte 1

Bit 3 - Tire Pressure Monitoring (PR-7K6) active (1 = active)

The TPMS need to be enabled in the Instrument Cluster:

[17 - Instruments]

[Coding - 07] -> Long Coding Helper -> Byte 4

Bit 0 - Tire Pressure Monitoring (TPMS) installed (1 = active)

Reset MMI

________________________________________

Enable VIM on MMI

[5F - Information Electr.] [Advanced ID - 1A] Note 1st Serial number

[Security Access] Enter Digits 6, 13, 10, 14, 11 of the 1st Serial number

[Adaptation - 10] -> Channel 48

Set to 255

Reset MMI

________________________________________

Set Audi parking system - Switch OFF Speed

[10 - Park/Steer Assist] [Adaptation - 10] -> Channel 23

Set to 20 (max value in km/h)

________________________________________

Set ADS to specific preset Comfort, Auto, Dynamic or Individual

[09 – Cent. Elect.][Security Access - 16]

[Adaptation - 10] -> Channel 63

Set to 01 - Comfort, 02 - Auto, 03 - Dynamic or 04 - Individual

[Adaptation - 10] -> Channel 64

Set to 01 - Comfort, 02 - Auto, 03 - Dynamic or 04 - Individual

[Adaptation - 10] -> Channel 65

Set to 01 - Comfort, 02 - Auto, 03 - Dynamic or 04 - Individual

[Adaptation - 10] -> Channel 66

Set to 01 - Comfort, 02 - Auto, 03 - Dynamic or 04 - Individual


*Note all four channels needs to be set to the same value.

________________________________________

Set Headlight washer - Duration

[09 – Cent. Elect.]

[Security Access - 16] [Adaptation - 10] -> Channel 6

change to e.g. 500

________________________________________

Set Headlight washer - Cycles

[09 – Cent. Elect.]

[Security Access - 16] [Adaptation - 10] -> Channel 26

change to e.g. 10

________________________________________

Adjust Consumption in DIS

[17 - Instruments]

[Adaptation - 10] -> Channel 3

change 100 to xxx (see samples below)

Sample 1 - Calculation based on volume per distance (e.g. l/100km):

DIS: 9,3 l/100 km.

Real: 9,8 l/100 km. (100 * 9,8 / 9,3 = 105,38)

Channel 3 will be changed from 100 to 105

Sample 2 - Calculation based on distance per volume (e.g. MPG):

DIS: 23 MPG.

Real: 24 MPG. (100 * 23 / 24 = 95,83)

Channel 3 will be changed from 100 to 96

________________________________________

Adjust LED brightness

[09 – Cent. Elect.] [Security Access - 16] (enter security code. One of the default codes is- 20113)

[Adaptation - 10] -> Channel 3

Set between 5 and 100


________________________________________

Set Automatic Transmission Start Mode to D or S

[09 - Cent. Elect.] [Security Access - 10]

[Adaptation 10] -> Channel 64 - Stored Value = 218 = Starting mode is always D

Channel 64 - New Value = 00; Starting mode is determined by ADS selection at engine shutdown
(Comfort and Auto=D, Dynamic=S, Individual=whatever you pick)

Channel 64 - New Value = 03; Starting mode is always S regardless of ADS selection at engine
shutdown (opposite of stock)

Channel 64 - New Value = 11; Starting mode is S with all ADS settings at shutdown except Comfort
where it's D

Channel 64 - New Value = 19; Starting mode is S with all ADS settings at shutdown except Auto where
it's D

________________________________________

----------------------------

Hidden menu in MMI Navi Plus (3G): (Only for Navigation equipped cars)

Meniu ascus pt navigatia 3G

[5F - Information Electr.]

[Adaptation - 10] -> Channel 6

change 0 to 1

Use this hidden menu at your own risk.

Caution: Keep away from the "Bootloader".

________________________________________

Adaptive cruise control default distance:

In cars with adaptive cruise control the default distance (1 to 4) can be changed from the CAR menu.
If this menu option is hidden in you car, apparently you can enable it with VAG-COM. From the Auto
distance regulation module 13, Adaptation, Channel 7, change 0 to 1, Save.

_______________________________________

S-ar putea să vă placă și