Documente Academic
Documente Profesional
Documente Cultură
2. Mainframe System
NONE
3. OPEN System
HDS Confidential 1 of 7
2 When installing a CHA, an MP of another CHA was
blocked
Phenomena When installing a CHA on a DKC with micro-program
version lower than V04 loaded,
an MP of another CHA was blocked, where many CHK2
occurred and the number of CHK2 occurrences exceeded
the threshold.
Severity (High, Medium, Low) Medium
Conditions of Occurrence The problem occurs when all the following conditions are
met.
(1) The version of micro-program in DKC is earlier than 60-
04-04-00/00.
(2) The version of micro-program written in FM of CHA to
be installed is 60-04-04-00/00 or higher.
(3) During installation of a CHA (CMF, CHT, CHE), the
CHA is inserted before the SVP message [ONL0869i]
"Please install the units in the system before starting this
process. If installation has been completed, select [OK]."
appears.
In detail, there are two cases in (3).
3-1) The CHA is inserted after the micro-program transfer
from SVP to SM is initiated. (micro-program in SM is
unavailable)
3-2) The type of CHA that should be installed on the DKC
is not inserted. (Micro-program version of SM doesn't
support that of the installed CHA)
Affected Products/Version DKCMAIN: Lower than 60-04-04-00/00
Fixed Product/Version DKCMAIN: 60-05-15-00/00
Category Open
Changed Part DKCMAIN
- Rebalanced pool.
(1) There is, at least, one pool volume whose capacity is
more than 700 GB.
Affected Products/Version DKCMAIN: 60-02-04-00/00 and higher
Fixed Product/Version DKCMAIN: 60-05-15-00/00
Category Dynamic Provisioning
Changed Part DKCMAIN
HDS Confidential 2 of 7
4 Pool missing during pool recovery
Phenomena A pool disappeared from the window during pool recovery.
* Pool volumes, which the disappeared pool used, remained
in use.
Severity (High, Medium, Low) Medium
Conditions of Occurrence The problem may occur when SI initialize is executed after
either of the following occurs or is performed.
(1) An error message [3005-58491] (Communication
timeout error) occurs during pool recovery.
(2) SVP is rebooted during pool recovery.
Affected Products/Version DKCMAIN: 60-02-04-00/00 and higher
Fixed Product/Version DKCMAIN: 60-05-15-00/00
Category Dynamic Provisioning
Changed Part DKCMAIN
9 Occurrence of SSB=AE63
Phenomena When a write operation was performed on an un-copied area
of FC, SSB=AE63 might occur. (This is just a matter of log
output)
Severity (High, Medium, Low) Low
Conditions of Occurrence The problem may occur when all the following conditions
are met.
(1) FCv2 is used.
(2) A write operation is performed on an un-copied area of
FC.
Affected Products/Version DKCMAIN: All
Fixed Product/Version DKCMAIN: 60-05-15-00/00
Category Flash Copy version2
Changed Part DKCMAIN
HDS Confidential 4 of 7
1. Read I/O operation from host to target volume (T-VOL) of a
Flash Copy Version2 (FCv2) pair
2. Write I/O operation from a host to a source volume(S-VOL) of
an FCv2 pair in a configuration where the S-VOL and T-VOL are
defined in different CLPR
3. Configuration where volume is shared by FCv2 T-VOL and a
True Copy (TC) primary volume (P-VOL) is created
4. Configuration where volume is shared by FCv2 T-VOL and a
Universal Replicator (UR) P-VOL is created
5. Configuration where volume is shared by FCv2 source volume
and a TC secondary volume is created
Severity (High, Medium, Low) High
Conditions of Occurrence - Phenomenon 1 Failure may occur with the following met.
A. All current RAID600 micro-program versions
B. FCv2 configuration
C. Read I/O operation from host to T-VOL of an FCv2 pair
- Phenomenon 2 Failure may occur with the following met.
A. All current RAID600 micro-program versions
B. FCv2 configuration
C. Write I/O operation from host to S-VOL in configuration where
S-VOL and T-VOL are defined in different CLPR
-Phenomenon 3 Failure may occur with the following met.
A. RAID600 code versions 60-02-25-00/00 and higher
B. Volume is shared by an FCv2 T-VOL and a TC P-VOL
C. The following which trigger copy of TC pair in (B)
(i) FCv2 pair, with configuration (B), is created while TC pair is in
Duplex or Duplex Pending status
(ii) TC pair, with configuration (B), is created
(iii) TC pair re-sync is executed with configuration (B)
-Phenomenon 4 Failure may occur with the following met.
A. RAID600 code versions 60-05-06-00/00 and higher
B. Volume is shared by an FCv2 T-VOL and a UR P-VOL
C. The following which trigger copy of UR pair in (B)
(i) An FCv2 pair, with configuration (B), is created while the UR
pair is Duplex or Duplex Pending status
(ii) UR pair, with configuration (B), is created
(iii) UR pair re-sync is executed with configuration (B)
-Phenomenon 5 Failure may occur with the following met
A. All current RAID600 micro-program versions
B. Volume is shared by FCv2 T-VOL and TC 2nd VOL
C. Configuration where the FCv2 S-VOL and T-VOL are defined
in the different CLPR
D. Any of the following operations which trigger the copy of the
above configuration (B) is executed
(i) An FCv2 pair, with configuration (B), is created while the TC
pair is in Duplex or Duplex Pending status
(ii) A TC pair, with configuration (B), is created
(iii) TC pair re-sync is executed with configuration (B).
Affected Products/Version DKCMAIN: All
Fixed Product/Version DKCMAIN: 60-05-15-00/00
Category Flash Copy Version 2, True Copy for z/OS, Universal Replicator
for z/OS
Changed Part DKCMAIN
HDS Confidential 5 of 7
DP-VOL which was being used by SI/CoW, the licensed
capacity in-use of SI/CoW was not consistent with the
actually used capacity. There were cases of inconsistency
that the used capacity was larger or smaller.
Severity (High, Medium, Low) Medium
Conditions of Occurrence The problem may occur when sets of the following
conditions (1) to (3) or (4) to (6) are respectively met.
(1) RAID600: 60-02-25-00/00 and higher.
(2) Migration from an SI P-VOL or S-VOL is executed
using Volume Migration.
(3) The above migration is either (a) or (b) below.
(a) From a normal LDEV to an HDP LDEV
(b) From an HDP LDEV to a normal LDEV
HDS Confidential 6 of 7
Conditions of Occurrence Problem may occur with the following conditions met.
(1) 60-02-48-00/00 and higher
(2) Open Volumes
(3) TC or UR pair with P-VOL and S-VOL are HDP-VOL
(4) During the operation in (3), the usage rate of a pool
associated with the S-VOL is lower than the value of 20%
reduced from the threshold. * Usage rate is lower than the
value of 20% reduced from the lower one between the
variable threshold (5 to 95%) and the fixed threshold (80%).
(5) Any of the following
- After the pair in (3) is deleted, a TC pair is created using
the previous S-VOL as the P-VOL
- In the UR-TC cascading configuration, a TC pair is created
using the UR S-VOL as the TC P-VOL
- Takeover and Re-sync are performed for TC pair in (3)
Affected Products/Version DKCMAIN: 60-02-48-00/00 and higher
Fixed Product/Version DKCMAIN: 60-05-15-00/00
Category Dynamic Provisioning, True Copy for Open, Universal
Replicator for Open
Changed Part DKCMAIN
HDS Confidential 7 of 7