Documente Academic
Documente Profesional
Documente Cultură
Original
September 11, 2013
Part Number
990001-067
IMPORTANT SAFETY INFORMATION FOR
PERSONS PERFORMING MAINTENANCE
This Illustrated Parts Manual provides information that pertains to replacement parts for
the equipment manufactured by Kimble. In performing maintenance on the vehicle,
review and thoroughly understand the recommended and required maintenance proce-
dures in component manuals, including but not limited to, parts books, owners manuals,
operator’s manuals, maintenance manuals and/or service manuals.
Finally review and understand any applicable maintenance procedures and safety
practices recommended by Truck Manufacturers Association® (www.truckmfgs.org),
before beginning maintenance work.
Original Kimble parts are designed to meet exacting requirements for each particular
application. Imitation parts are not the same as Kimble original parts and in some cases,
in addition to not lasting as long, they can cause safety hazards. Kimble parts are engi-
neered with safety and longevity, imitations may expose associates to injury or worse.
Each Kimble Mixer is built uniquely to our customer’s requirements. Illustrations and part
listings in this manual may vary from your mixer assembly. When ordering parts for your
Kimble mixer, having your Mixer Body Assembly number (located on front pedestal) will
be helpful to our service department. If ordering a large component there may be a
model and serial number on that component as well. This will ensure your replacement
parts are correctly identified.
EFFECTIVITY PAGE
SECTION 1 –
CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
1-1 Chassis Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
1-2 Sub-Frame Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
1-3 Rear Crossmember Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
1-4 Fender Front End Cap Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-8
1-5 Fender Rear End Cap Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-10
1-6 Fender Support Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12
1-7 Fender Skin Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-14
1-8 Trailer Body Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-16
1-9 Trailer Axle Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-18
1-10 Trailer Fender Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-20
1-11 Trailer Pivot Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-22
1-12 Bucket Rack Assembly - Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-24
1-13 Step Assembly - Single Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-26
1-14 Step Assembly - Double Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-28
SECTION 2 –
FRONT PEDESTAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
2-1 Front Pedestal Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
SECTION 3 –
REAR PEDESTAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
3-1 Rear Pedestal Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
3-2 Rear Pedestal Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
3-3 Charge Hopper Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
3-4 Collector Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
3-5 Chute Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-10
3-6 Chute Pivot Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
3-7 Chute Rack Assembly - Vertical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-14
3-8 Chute Rack Assembly - Horizontal Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
3-9 Spare Chute Options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-18
3-10 Roller Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-20
3-11 Trailer Latch Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-22
3-12 Drum Debouncer Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-24
3-13 Ladder Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-26
3-14 Platform Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-28
SECTION 4 –
DRUMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
4-1 Drum Options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
SECTION 5 –
WATER SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
5-1 Water System Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2
5-2 Rear Pedestal Water Distribution Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4
5-3 Water Tank Assembly - Cross Mount 100 Gallon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
5-4 Water Tank Assembly - Cross Mount 150 Gallon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
5-5 Water Tank Assembly - Cross Mount 150 Gallon - Add Mix . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10
5-6 Water Tank Assembly - Side Mount 150 Gallon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12
5-7 Selection Vavle Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14
5-8 Outlet Valve Assembly - Side Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-16
SECTION 6 –
HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1
6-1 Drum Drive Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
6-2 Comp Pump Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
6-3 Axle Control Box Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6
6-4 Chute Valve Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-8
6-5 Trailer Valve Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-10
6-6 Hydraulic Reservoir Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-12
6-7 Hydraulic Cooler Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-14
6-8 Trailer Cylinder Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-16
6-9 Trailer Latch Cylinder Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-18
6-10 Chute Cylinder Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-20
6-11 Charge Hopper Cylinder Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-22
6-12 Chute Brake Cylinder Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-24
SECTION 7 –
CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
7-1 Water Tank Air Pressure Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
7-2 Add Mix Water Tank Air Pressure Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
7-3 Auxiliary Axle Air Pressure Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6
7-4 Main Hydraulic Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8
7-5 Hydraulic Valve Installation - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-10
7-6 Hydraulic Valve Installation - Bridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-12
7-7 Chute Hydraulic Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-14
7-8 Chute Hydraulic Circuit - Steel Lines Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
7-9 Chute Brake Hydraulic Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-18
7-10 Chute Brake Hydraulic Circuit - Steel Lines Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-20
7-11 Trailer Hydraulic Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-22
7-12 Trailer Latch Circuit - Steel Lines Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-24
7-13 Charge Hopper Hydraulic Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-26
7-14 Slump Gauge Hydraulic Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-28
7-15 Hose Protector Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-30
7-16 Hydraulic Schematic - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-32
SECTION 8 –
ELECTRICAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
8-1 Cab Console Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
8-2 Display Monitor Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
8-3 Joystick Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
8-4 Cab Keypad Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
8-5 Pedestal Keypad Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10
8-6 Rear Vision Camera Installation - Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-12
8-7 Work Light Installation - Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-14
8-8 Electrical Panel Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-16
8-9 Fuse Panel Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-18
8-10 Battery Cable Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-20
8-11 Frame Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-22
8-12 Cab Console Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-24
8-13 Rear Pedestal Keypad Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-26
8-14 Work Light Wiring - Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-28
8-15 Tail Light Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-30
8-16 Trailer Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-32
SECTION 9 –
DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-1
9-1 Decal Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2
5
10
12
3
7
6
9
PM0170 4
11
16
14 18
103
13
18
12
OPTIONAL WIDE BUMPER
15 16
19
2
4
7
2 104
9
8 10
101
7
5
11
102
22
21
21
22
20
3
PM0010
17
1
104 Ref ASSY, REAR CROSSMEMBER K2200C, (see Figure 1-3 for details)
14 7
9
8
2 6 9
12 10
1
13
1 2
3 OM0030
3 4
15 10 14
11
15
5
9 6 1
3
5
6
10
11
12
13
8
7
5
7
LEFT SIDE
PM0120
RIGHT SIDE
7
11
8
9 4
10
8
2
12
2 1
13
16
3 15
8
10
8
6
14
LEFT SIDE
PM0130
RIGHT SIDE
9
10
10
7
1 6
2
9 3
6
11 5
7
6
4
6
5
102
103
104
104
101
103
105
PM0140
107
106
3
PM0150
2
6 5
15
VIEW WITH
TRAILER UP
101
7
7
5
12
13
2
1
13 8
14 6
9
9
16 3 11 10
102
1
13
103
6
10
11
PM0045
13
17
101 Ref REAR CROSSMEMBER ASSY, (see Figure 1-3 for details)
102 Ref TRAILER AXLE, (see Figure 1-9 for details)
103 Ref TRAILER HARNESS, (see Figure 8-16 for details)
201
202
AB
T
S KI
PM0100
2
3
11
8 22
19
12 11 1
16 4
18
11 5
12
13 11 10
14
15
LEFT SIDE
9
22
3
17
7
20
1
PM0050
RIGHT SIDE
PM0080
PM0160
8
6
7
2
5
7
1
PM0990
3
PM1000
14
15
9
8
10
10
11
101
102
6
22 3
21
4 2
7
21
20
5
PM0320
101 Ref HYDRAULIC RETURN FILTER ASSY, (see Figure 7-4 for details)
102 Ref ELECTRICAL PANEL ASSY, (see Figure 8-8 for details)
16
13
3
18
12
4
14 5 11
18
17
6
9
14
10
8
1
PM0180
14 1
15 12
13
11
101
10
2
3
15
9
16
PM0190
6
7
14
21 15
16
13
10
102 12
8 1
11
6
15
14 20
23 24 7
24 22 19
6
5 17
4
17
18
2
3
101
PM0200
101 Ref CHARGE HOPPER CYLINDER ASSY, (see Figure 6-11 for details)
102 Ref PLATFORM SUPPORT, (see Figure 3-14 for details)
11
12
13
14
15
10
8
7
9
1
8
7
7
6
7
6
2
3
3
5
PM0210 4
1
7
2
6
3
1
8
9 4
10
11
5
PM0220
14
13
13
12
101 15
3
2
2
4
102 16
15
101
15
14
103 5
6 13
7A
7
7B
7B
7
7A
10
11
PM0230
12
4
3
6
5
9 4
PM0250
4
6
3
2
4
1 6
5 6
7 8
6
7 8
9
1
PM0280
PM0960
11
10
9
8
12
7
3
2
7
1
7
2
3
7
101 12
8
9
4 6
5
13
PM0260
102
2
3
1
11
101
10 5
9
8 7
7 6
PM0270
101 Ref TRAILER LATCH CYLINDER, (see Figure 6-9 for details)
PM0290
10
4 1
2
20 1
3
18
19
15
17 16
16 14
13 21
12
8
6
23 7 4 1
25 6
3 2 25
24
1 2
5 1
3
1
4 26
9
1 28
3 4
1
22 26 27
20
18
19
17 15
16
16 14
11
PM0310
9 8
7
10
12
11
1 4
3 101
4
3
6
3
2
2
5 PM0300
101
102
103
104
PM0920
DRUM OPTIONS
101 D110-00755 Opt DRUM, KIMBLE 11 YD TMMB, 3/16 SHELL, 43.5" DISCH, 1 MW, SPLTRS
102 D110-00756 Opt DRUM, KIMBLE 11 YD TMMB, 1/4 SHELL, 43.5" DISCH, 1 MW, SPLTRS
103 D105-00757 Opt DRUM, KIMBLE 10.5 YD TMMB, 3/16 SHELL, 43.5" DISCH, 1 MW, SPLTRS
104 D105-00758 Opt DRUM, KIMBLE 10.5 YD TMMB, 1/4 SHELL, 43.5" DISCH, 1 MW, SPLTRS
101
7 8
7 5
6
2
2
1 102
2
3
9
2 PM0451
19 20 2
18 19
3
LOCATED ON
PLATFORM
5
21 8 10
9
11
15
14
12
14
3 13
LOCATED ON 9
LADDER SUPPORT 16
8 PM0400
6
17 11
1
1A
21
17 2
22
18 20
19
23
13
8
11
12
10
9
16 102 7
15
13
8
25
14 101
24 4
5
7
PM0430
3
6
101 Ref SELECTION VALVE ASSY, (see Figure 5-7 for details)
102 Ref OUTLET VALVE ASSY, (see Figure 5-8 for details)
1
1A
2
38
39 37
36
40 35
41
32 33
17
18
17 33
16
15 9
30
14
27
30
24 29
28
22
23
21 26
25 27
102 7
20
26
19
17 17
18
16 101
14 15
3
9
8
10
11
10
12
13 5
7
PM0380
11 6 4
101 Ref SELECTION VALVE ASSY, (see Figure 5-7 for details)
102 Ref OUTLET VALVE ASSY, (see Figure 5-8 for details)
Figure 5-5 Water Tank Assembly - Cross Mount 150 Gallon - Add Mix
1
1A
36
31
38
35 33
37 40
41 39
2
32
31
33 34
30
23 29
23
21 26
3
20 24
101
42
28
20
7
23 27 21 10
8 101
9
5
25 15 6
23 4
22
11 12
13
8
9 14
10 13
12 17
11 12 16 12
13 10
TO REAR
14 PEDESTAL
WATER
PM0610 10 DISTRIBUTION
13
12 9
18
19
Figure 5-5 Water Tank Assembly - Cross Mount 150 Gallon - Add Mix
Item Part Number Qty. Description Rev.
1 300202-204 2 STRAP, 24" DIA WATER TANK, (includes item 1A)
1A M72-00128-00 4 ft STRAPS, RUBBER PROTECTIVE, WATER TANK
2 S17-000R0-00 1 TANK, WATER, 150 G 24" DIA X MT ALUM 7" FL ADMIX135/15G KMC
3 300209-007 2 ISOLATOR STRIP
4 500034-051 1 WELDMENT, DS 24" DIA WATER TANK MOUNT
5 200180-758 4 HEX FLG HD CAP SCR, 3/4-16 X 2 LG, GR 8, ZINC PL
6 200001-114 4 NUT, HEX FLG, 3/4-16, STOVER, GR G, ZINC PL
7 1” X 1/2” ADAPTER, MALE PIPE
8 C94-F5075-00 2 VALVE, BOILER DRAIN, 1/2 NPT X 3/4 GH
9 C84-T1100-50 3 FITTING, BLK PIPE, T, 1" X 1/2" X 1"
10 C84-N0100-00 4 FITTING, BLK PIPE, NIPPLE, 1" X CLOSE
11 C94-00100-00 2 VALVE, BALL, 1"
12 C84-J0100-00 5 FITTING, HOSE BARB, 1" MP-1" HOSE, STEEL
13 C54-56150-00 4 CLAMP, HOSE, 7/8-1 1/2 X 9/16
14 C81-W98BL-00 12 ft HOSE, WATER, BLACK, 1", NO ENDS
15 C84-N0100-04 1 FITTING, BLK PIPE, NIPPLE, 1 X 4"
16 C94-10100-00 1 VALVE, CHECK, 1 IPS SWING
17 C84-T0100-00 1 FITTING, BLK PIPE, T, 1"
18 C84-N0050-00 1 1/2” ADAPTER, MALE PIPE
19 C94-00050-00 1 VALVE, BALL, 1/2", FULL FLOW
20 C99-00323-00 1 BALL, FLOAT, GAUGE, RED
21 C99-44024-00 1 TUBE, ACRYLIC, 5/8 OD X 3/8 ID X 6' LONG SECTION, CLEAR
22 C29-25137-56 2 BOLT, U, 1/4-20x1 3/8x2 1/4, SS
23 C94-W0010-00 2 VALVE, WATER GAUGE, (2 per box)
24 C95-00135-24 1 GAUGE, STRIP, WATER, 135 GAL 24" DIA
25 S17-00250-00 1 BRACKET, SIGHT GAUGE, WATER TANK, CROSS, 24" DIA
26 C95-00015-24 1 GUAGE, STRIP, 15 GAL 24" DIA
27 C31-02501-86 4 WASHER, 1/4, FW, SS
28 C41-02510-86 4 NUT, 1/4-20, H, SS
29 200025-006 1 ADAPTER, STR, NIPPLE, REDUCER, 1/2 NPT X 1/4 NPT
30 200032-105 1 ADAPTER, TEE, 1/4 FEMALE NPT, BRASS
31 C95-00100-21 2 GAUGE, 100PSI, 2", 1/4NPT BOTTOM TAP
32 200018-006 1 ADAPTER, ELBOW, 90 DEG, 1/4 NPT X -8 AB TUBE, BRASS
33 A13-00111-00 2 VALVE, 1/2" PRESSURE RELIEF
34 C84-N0200-00 1 FITTING, BLK PIPE, NIPPLE, 2 X CLOSE
35 C94-10200-00 1 VALVE, GATE, 2” IPS
36 1 ADD MIX FILL ADAPTER, PVC
37 200039-024 8 HEX HD CAP SCR, 5/16-18 X 1-1/2 LG, GR 8, YL ZINC PL
38 200108-002 8 WSHR, FLAT, 5/16, 18-8 STNL STL
39 200018-008 1 ADAPTER, ELBOW, 90 DEG, 1/2 NPT X -8 AB TUBE, BRASS
40 200011-001 1 ADAPTER, BUSHING, 1/2 NPT X 1/4 FEMALE NPT
41 S17-50830-01 1 FLAPPER, 7", WATER TANK
42 500034-052 1 WELDMENT, PS 24" DIA WATER TANK MOUNT
101 Ref SELECTION VALVE ASSY, (see Figure 5-7 for details)
32
101 4 1
26 1A
25 31 6
27 30 7
29 4
28
23 24
1 24
14
15
14
13
22 12 5 PM0390
21
18 9 4
6
16 4
21
20
17 7
18 8
17
19
10
14
XX
11
15
14
13
12
9
101 Ref SELECTION VALVE ASSY, (see Figure 5-7 for details)
8
9
2
7
3
6
5
4
6 PM0410
5
4
PM0420
1
101
OPTIONAL RH DRIVE
1
10
7A 2
11
2
8
9 3
4
5
6
PM0330
9 8
6A
17
102 14
16
7
15
8
4
2 18
101
8A 11
9
3
1
PM0530 12
7 18 6
13 5
10
101 Ref PTO MOUNTING PLATE, (see Figure 1-2 for details)
102 Ref PTO SHAFT, (contact Kimble with MBA number for replacement)
8
11
10
5
4
20
21
21 19
6
5
5
25
4
25
13
24
15
2 23
26
26
18 22
17
3
12
5
15 4
17 5
14 16 4 PM0540
13
8 2
3
12
11
5
4
10 9
6
8
7
13
A B
PM0460
PROPORTIONAL BLOCK
SOLENOID VALVE PLATE
8 4A 9
4A
7
5
4
AT
RS08-01
AP 2
3500 psi B
2 WK10L-01 1
1 2
3 Up
DR10-01
1250 psi
3 1
3
2
Dn
DW10SC-01
3 1
P 2 1 WK10L-01 1 2
3 A
3
800 psi
PSV1-10
T 1
PP
14
12
13
11
2
10 15
9 16
3
7
4
6 5
7
8 PM0350
18
PM0340
4
5
101
PM0060
300180-147A
2
1
101
102
PM0500
11
13
13
12
1
10
9
7
4
6 12
8
5 13
2 13
11
3
4
101 PM0240
102
3
1
101
102
PM0510
5 3
3
PM0520
101
102
3
2
2
101
2
EXHAUST
103
PM0800
EXPLOSION HAZARD
Contents under pressure. Altering water
tank components will result in death or
serious injury.
Do NOT tamper with regulator or relief 104
valve. Maximum 75 PSI.
Peligro de explosión
Contenido bajo presión. La alteración de agua componentes
del tanque puede provocar la muerte o lesiones graves.
NO manipule el regulador o el alivio válvula. Máxima 75 PSI.
300180-149
101 Ref SELECTION VALVE ASSY, (see Figure 5-7 for details)
102 Ref CHASSIS AIR SUPPLY
103 Ref WATER TANK ASSY, (see Section 5 for details)
104 Ref WATER TANK SAFETY DECAL, (see Figure 9-1 for details)
102
3
2
101
WATER 2
TANK
2
EXHAUST
101
ADD
MIX
103
2 2
PM0810
EXHAUST
EXPLOSION HAZARD
Contents under pressure. Altering water
tank components will result in death or
serious injury.
Do NOT tamper with regulator or relief
valve. Maximum 75 PSI. 104
Peligro de explosión
Contenido bajo presión. La alteración de agua componentes
del tanque puede provocar la muerte o lesiones graves.
NO manipule el regulador o el alivio válvula. Máxima 75 PSI.
300180-149
101 Ref SELECTION VALVE ASSY, (see Figure 5-7 for details)
102 Ref CHASSIS AIR SUPPLY
103 Ref ADD MIX WATER TANK ASSY, (see Figure 5-5 for details)
104 Ref WATER TANK SAFETY DECAL, (see Figure 9-1 for details)
12
9
10
1
101
12 11
2
12
2
EXHAUST
12 3
2
12
2
102
12
LIFT
104 5
2 2
13
102 2
6
LIFT 2
4 12
105 12
2 12
2
2
PM0890
2 12
4
12 103
DOWN
103
DOWN
15
14
101 13
106
102
16
12
21
20
7 19
105 2
17 11
18
3
1
2
9
10
3 4
5 103
6 8
PM0882 7
101 Ref DRUM DRIVE MOTOR ASSY, (see Figure 6-1 for details)
102 Ref COMP PUMP ASSY, (see Figure 6-2 for details)
103 Ref HYDRAULIC RESERVOIR, (see Figure 6-6 for details)
105 Ref TRAILER VALVE OR CHUTE VALVE (depends upon axle configuration)
106 Ref HYDRAULIC COOLER, (see Figure 6-7 for details)
6
7
14
15
13
10 1
12 13
9
E
UT
12A CHAKE 11 1
BR
16
2
GE
AR R
CH PPE
HO
13 9 8
11A 2
5
CH
VAUTE
LV
E
101 3
PM0480
101 Ref CHUTE VALVE ASSY, (see Figure 6-4 for details)
35
12
13
17 27
18 5
23 26 27
35
22
34 E
UT
26A CHAKE 5
19 BR 25
36
20 10
GE
AR R
1 CH PPE
HO
27 22 21
8
4
2 7
5 6 25A 10
5
3
9A
9
11
6
10 15 15
14
33
16
CH
15 14 VAUTE
LV
E
101 14
11
14
30 14
29 T
VARAIL
LV ER
E 102
32 PM0471
31 29
28
101 Ref CHUTE VALVE ASSY, (see Figure 6-4 for details)
102 Ref TRAILER VALVE ASSY, (see Figure 6-5 for details)
(A)
101
(B) 1
4
1 5
2
4
5
(3)
(1)
2 102
PM0820
(2)
101 Ref CHUTE VALVE ASSY, (see Figure 6-4 for details)
102 Ref CHUTE CYLINDER, (see Figure 6-10 for details)
4
5
(A) 1 2
101
6
(B)
(3)
1 1 4
7 5 (1)
102
6 6 2
(2)
1
7
11 6 3
10
PM0930
12
8
103
101 Ref CHUTE VALVE ASSY, (see Figure 6-4 for details)
102 Ref CHUTE CYLINDER, (see Figure 6-10 for details)
103 Ref SUB-FRAME BRACKET, (see Figure 1-2 for details)
101
(1)
102
3
4
PM0830
101 Ref CHUTE BRAKE SOLENOID ASSY, (see Section 6 for details)
102 Ref CHUTE BRAKE CYLINDER, (see Figure 6-12 for details)
6
102
(1)
7
101
12 6
11
8
13 3
4
9 2
103
PM0940
10
101 Ref CHUTE BRAKE SOLENOID ASSY, (see Section 6 for details)
102 Ref CHUTE BRAKE CYLINDER, (see Figure 6-12 for details)
103 Ref SUB-FRAME BRACKET, (see Figure 1-2 for details)
103
101
(L) 3
(A)
(B)
1
102
2
PM0840
101 Ref TRAILER VALVE ASSY, (see Figure 6-5 for details)
102 Ref TRAILER CYLINDER, (see Figure 6-8 for details)
103 Ref TRAILER LATCH CYLINDER, (see Figure 6-9 for details)
101
(L)
3
8
102
7
9 2
5
103
PM0950 4
6
101 Ref TRAILER VALVE ASSY, (see Figure 6-5 for details)
102 Ref TRAILER LATCH CYLINDER, (see Figure 6-9 for details)
103 Ref SUB-FRAME BRACKET, (see Figure 1-2 for details)
101
(2)
(4)
2 (4)
10
9 (2)
7
5
8
8 10
(3)
6 (1)
10
102 11
12
3
4
1 1
PM0850
3
4
102 Ref CHARGE HOPPER SOLENOID VALVE ASSY, (see Section 6 for details)
103 Ref CHARGE HOPPER CYLINDER, (see Figure 6-10 for details)
8 101
7
6
5
3 4
1
PM0860
9
101 Ref DRUM DRIVE MOTOR, (see Figure 6-1 for details)
PM0980
PM0870
NOTES:
PB0840
PM0560
NOTES:
PB0840
101
5
2 9
6
4
10
6
3
8
7
8
PM0650
101 Ref CAB CONSOLE HARNESS, (see Figure 8-12 for details)
1
2
3
3
4
2
5
1
0
1
3
PM0660
PROGRAMMING REQUIRED!
PLEASE INCLUDE MBA NUMBER WITH ORDER.
EACH DISPLAY MODULE IS PROGRAMMED
UNIQUELY PER CUSTOMER REQUIREMENT.
1
5
ttle
ro Up
Th
wn
Do
2
3
PM0670
PM0680
101 5
1
6
8
3 4
PM0690
5
1
7
9
6 1
9
8
PM0700
1 2
8
9
9
4
7
6 3
PM0970
5
10
7
1
17
15
14
3
9
101
10
5
2
13 8
11
15
16
9
6
PM0710
11
12
101 Ref FUSE PANEL ASSY, (see Figure 8-9 for details)
1
2
5
6
3
4
PM0720
K2200C Series
FUSE
RELAY PANEL
Figure 8-10 Battery Cable Installation
PM0790
1
990001-067
ELECTRICAL
MATES TO
MATES TO PENDANT
CHUTE CENTER CABLE
PROX SWITCH
SPARE
MATES TO MATES TO
HOPPER TRAILER
PROX SWITCH PROX SWITCH
MATES TO
WORK LIGHT GROUND MATES TO
HARNESS STUD BACK-UP ALARM
MATES TO
STROBE LIGHTS
GROUND
STUD
MATES TO
HYDRAULIC TEMP
TRANSDUCER
MATES TO
POWER MODULE
C GROUND
STUD
MATES TO
POWER MODULE 1
D
Y5
MATES TO
DRUM PUMP
MATES TO
75 AMP RELAY
MATES TO
DRUM DRIVE
QUAD SENSOR
MATES TO
MATES TO SLUMP GAUGE
CHASSIS TRANSDUCER
INTERFACE
PM0730
MATES TO
CONSOLE
SP1
J1
K1
K2
MATES TO
DISPLAY
M1
MONITOR
U1
TERMINATING
RESISTOR MATES TO
CONSOLE
TERMINATING
RESISTOR
Y1-3
Y3-3
Y2-3
Y3 Y2 Y1
1
Y3-1
Y2-1
Y2-2
Y3-2
Y1-2
Y1-1
CB1
A1
BC
MATES TO PM0910
FRAME
MATES TO MATES TO HARNESS
ALARM BACK UP
CAMERA
TERMINATING
Y6-3
Y6
RESISTOR
1
MATES TO MATES TO
PENDANT REAR PED
EXTENSION KEYPAD
MATES TO MATES TO
FRAME PENDANT
HARNESS BOX
2 PM0740
MATES TO
FRAME
HARNESS
PM0750
TO RIGHT
FENDER MARKER
MATE TO
SIDE MARKER
PIGTAIL HARNESS
OPTIONAL REAR
MATES TO CROSSMEMBER
LICENSE LIGHTS
LIGHT
MATE TO
CHARGE
HOPPER 1
LIGHTS
MATES TO
CHASSIS
INTERFACE
MATES TO
TRAILER AXLE
HARNESS
(if equipped)
MATE TO
SIDE MARKER
PIGTAIL HARNESS
MATES TO BACKUP LIGHT
MATES TO STOP/TURN/TAIL LIGHT
PM0770
TO LEFT
FENDER MARKER
MATES TO MATES TO
RIGHT TRAILER LEFT TRAILER
LIGHT LIGHT
MATES TO MATES TO
RIGHT TRAILER LEFT TRAILER
MARKER MARKER
PM0780
MATES TO
TAIL LIGHT
HARNESS
3
13
Daños en el equipo Daños en el equipo Peligro de quemaduras
Rampa extendida flip durante el transporte puede causar Inadecuadamente almacenados rampas de repuesto puede Temperaturas de aceite pueden superar los 120 ° F.
serios daños al equipo para vehículo o propiedad. producir daños materiales o lesiones. Póngase en contacto con la piel puede provocar quemaduras.
No tocar el aceite caliente o componentes. Permitir vehículo
Chute flip siempre segura con la seguridad En forma segura extensiones chute en el bastidor de se enfríe antes de darle mantenimiento o utilizar protección
cadena antes del transporte. almacenamiento. Fije la cadena o el gancho. personal adecuado.
300180-136 300180-140 300180-184
14
Dé la vuelta a riesgo! Peligro de caídas
Este vehículo tiene un alto centro de gravedad que hará que Peligro de muerte La caída de la plataforma podría resultar en muerte o lesiones
se molesta, especialmente en las curvas de la derecha. graves.
Lea y siga toda la seguridad instrucciones antes de entrar Nunca se apoye ni se suba en plataforma barandilla. No se
Tenga precaución y reducir la velocidad cuando curvas de tambor.
negociación para evitar graves lesiones o muerte. suba en la escalera o de pie en la plataforma mientras camión
El incumplimiento dará lugar muerte o lesiones graves. está en movimiento.
300180-143 300180-146
300180-144
ROTATING PARTS
HIGH PRESSURE NITROGEN Contact with rotating shafts will cause EXPLOSION HAZARD
death or serious injury.
Do NOT disassemble cylinder! Failure to Do NOT enter under chassis unless Contents under pressure. Altering water
follow proper maintenance procedure engine is stopped and lock out tank components will result in death or
will result in death or serious injury. procedure is followed. serious injury.
Consult Kimble Mixer before servicing
cylinder. 5 Do NOT work on PTO when engine is
running.
10 Do NOT tamper with regulator or relief
valve. Maximum 75 PSI. 15
PM0621
CRUSH HAZARD
Operation of chute can crush and
PINCH POINT CRUSH HAZARD
cause serious damage. Charge hopper will come down with Trailer axle movement can crush
loss of hydraulic power or if truck is person close to operation and cause
Do NOT pull chute over yourself or shut down. Failure to avoid could result death or serious injury.
others. Do NOT stand under chute. in death or serious injury.
Check chutes, hoses and hardware
before operating. Replace damaged Keep all limbs clear of area. 22 Clear area of people before raising
or lowering trailer axle. 28
parts. 17
Pinch punto Peligro de aplastamiento
Peligro de aplastamiento Tolva de carga se reducirá con pérdida de potencia hidráulica Movimiento puede aplastar a remolque de eje persona
Operación de rampa pueden aplastar y causar daños graves. o si es camión cerrar. Si no se evita podría resultar la muerte cercana a la operación y la causa muerte o lesiones graves.
NO tire el colector sobre ti mismo o otros. No se pare debajo o lesiones graves. Despejar el área de personas antes de levantar o bajar el eje
del canal. Compruebe conductos, mangueras y herrajes Mantenga todos los miembros alejada del área. del remolque.
antes de operar. Reemplace dañado partes. 300180-156 300180-161
300180-157
300180-160 300180-158
EQUIPMENT DAMAGE
Welding can cause catastrophic failure
of electronic wiring, bearings of
major components, and be hazardous
to your health. Do NOT repair without
qualification. Damage not covered by
24 VOID OF WARRANTY
warranty. KIMBLE IS NOT RESPONSIBLE FOR DAMAGE
Weld procedures must be performed TO PAINT, HYDRAULIC CYLINDERS, OR
by qualified personnel only. Connect 300180-050 INDIRECT DAMAGE FROM THE USE OF ACID
ground leads only to exact metal
components being repaired. 19 BASED CLEANERS.
30
Daños en el equipo Vacío de garantía
La soldadura puede provocar un fallo catastrófico de
cableado electrónico, los cojinetes de componentes 25 Kimble no se hace responsable por daños a la pintura, cilindros
hidráulicos, o daño indirecto del uso de productos de limpieza a
principales, y ser peligrosa para su salud. No repare sin 300180-076
cualificación. Los daños no cubiertos por garantía. base de ácido.
300180-152
Procedimientos de soldadura debe realizarse por personal
cualificado. conectar suelo sólo conduce al metal exacto
componentes siendo reparado.
300180-162
PM0630
20 26
300180-188
300180-186
31
1. Lea y siga Reglamento OSHA "1910.146 Espacios Confinados"
procedimiento.
2. Desactivar vehículo, desconectando los cables de la batería. 34
3. El uso apropiado de bloqueo / etiquetado procedimiento.
4. Calce correctamente rodillos de tambor. 300180-187
35
FRESH CONCRETE
Fresh concrete can cause burns and eye
injuries. Wear protective clothing and avoid
skin contact. Wash exposed skin with water.
If concrete gets into eyes, rinse immediately
with water, obtain prompt medical attention.
PM0640
101
101 Ref AXLE LOAD DECAL, (contact Kimble with MBA number for replacement)
Part Number Page Part Number Page Part Number Page Part Number Page
100001-004 ...................... 7-7 200039-066.. 7-17, 7-21, 7-25 200114-193 .................... 8-17 300028-939.................... 8-33
100051-003 ............... 7-3, 7-5 200039-102.... 5-9, 5-13, 5-15 200117-006 .................... 3-13 300028-941.................... 1-15
200001-105 ........... 3-15, 6-23 200039-106........... 6-21, 8-17 200118-307 .................... 6-13 300057-518.................... 5-13
200001-109 .............1-5, 3-25 200039-113.................... 7-27 200119-003 .................... 3-27 300111-311.................... 6-13
200001-110 .................... 1-25 200039-189...................... 3-7 200124-015 ...................... 5-7 300115-024........... 7-11, 7-13
200001-112 ...1-13, 1-21, 3-7, 200039-194.................... 6-23 200127-904 .................... 8-19 300115-058.................... 7-27
3-13, 3-27 200039-241.................... 1-21 200131-006 . 7-17, 7-21, 7-25 300121-207.. 6-13, 7-13, 7-29
200001-114 2-3, 3-5, 5-7, 5-9, 200041-900...... 1-17, 3-5, 3-7 200143-005 ...................... 8-3 300135-030.................... 1-19
5-11 200042-012........... 3-11, 3-27 200145-007 ...........7-11, 7-13 300135-031.................... 1-19
200004-010 .................... 6-21 200042-019...................... 3-9 200145-010 . 6-21, 7-11, 7-13 300157-003.................... 3-13
200004-022 .................... 3-27 200048-002.................... 8-17 200180-304 .................... 3-15 300162-900.................... 1-21
200004-251 .............5-9, 5-13 200049-001.................... 8-17 200180-312 .................... 1-27 300167-003...................... 6-7
200004-309 .................... 3-29 200049-002............. 3-9, 3-11 200180-506 .............1-5, 3-25 300169-231........... 7-11, 7-13
200004-861 ..7-17, 7-21, 7-25 200049-010...................... 3-7 200180-556 .................... 1-25 300169-232.................... 7-13
200006-106 .................... 3-23 200049-011... 5-9, 5-13, 5-15, 200180-656 .................... 3-27 300169-233........... 7-11, 7-13
200006-108 .................... 3-13 7-27 200180-659 .................... 1-13 300169-234........... 7-11, 7-13
200006-108A.................. 3-13 200049-012.................... 6-13 200180-662 ...................... 3-7 300169-235........... 7-11, 7-13
200006-108B.................. 3-13 200050-104.................... 3-13 200180-663 .................... 1-21 300169-236.................... 7-13
200008-001 .................... 8-13 200052-101........... 1-15, 8-11 200180-758 ..... 5-7, 5-9, 5-11 300169-237.................... 7-13
200010-001 .............1-7, 1-17 200052-102........... 8-11, 8-17 200180-762 ...................... 3-5 300169-238.................... 7-13
200011-001 .....5-7, 5-9, 5-11, 200054-002.................... 1-27 200180-764 ...................... 2-3 300169-239.. 7-17, 7-21, 7-25
5-13 200055-001.. 7-17, 7-21, 7-25 200180-768 ...................... 6-3 300175-022.................... 8-11
200011-026 ............... 2-3, 7-9 200055-123...................... 6-3 200181-115 ...........7-11, 7-13 300180-050...................... 9-5
200012-020 ............... 2-3, 7-9 200070-006........... 1-17, 1-21 200181-120 .................... 7-13 300180-076...................... 9-5
200012-110 .................... 5-15 200084-073.................... 8-19 200181-204 .................... 3-11 300180-133...................... 8-7
200016-002 .................... 6-13 200091-011.................... 3-27 200181-304 .............3-9, 3-13 300180-135...................... 9-5
200016-003 .................... 6-13 200096-002.................... 8-17 200181-667 .................... 3-13 300180-136...................... 9-5
200017-013 .................... 5-17 200102-011.................... 8-19 200181-712 .................... 3-13 300180-137...................... 9-5
200017-020 ............... 2-3, 7-9 200102-012.................... 8-19 200181-933 .................... 1-17 300180-138...................... 9-5
200018-002 ...................... 1-7 200102-014.................... 8-19 202510-016 ...........7-15, 7-17 300180-139...................... 9-5
200018-004 ............... 1-7, 7-7 200102-016.................... 8-19 202510-020 .................... 7-27 300180-140...................... 9-5
200018-006 .................... 5-11 200102-031.................... 8-21 202510-030 ...........7-19, 7-21 300180-141...................... 9-5
200018-007 .................... 5-15 200102-104.................... 8-21 202510-034 ...........7-15, 7-17 300180-143...................... 9-5
200018-008 .......1-7, 5-7, 5-9, 200105-006.................... 6-13 202510-085 .................... 7-25 300180-144...................... 9-5
5-11, 5-13 200105-009..... 2-3, 3-13, 6-3, 202510-227 7-15, 7-19, 7-21, 300180-145...................... 9-5
200018-010 ...................... 7-7 6-21 7-27 300180-146...................... 9-5
200019-003 .............6-5, 6-13 200105-010.... 3-9, 3-11, 3-27 202510-250 .................... 7-29 300180-147...................... 9-5
200021-102 .................... 5-15 200105-012............. 3-9, 3-11 202510-268 ...........6-19, 7-23 300180-148...................... 9-5
200022-004 .................... 5-13 200106-015............. 6-7, 7-13 202512-020 .................... 7-27 300180-149...................... 9-5
200025-006 .................... 5-11 200106-016...................... 6-3 202512-048 . 7-17, 7-21, 7-25 300180-151...................... 9-5
200027-013 ............... 5-7, 5-9 200106-019............. 3-9, 3-13 202512-059 ...........7-21, 7-29 300180-152...................... 9-5
200028-003 .................... 5-13 200107-001.................... 8-11 202512-268 .................... 7-27 300180-153...................... 9-5
200028-013 .................... 7-11 200108-001... 5-15, 6-7, 7-11, 205000-052 ...................... 7-9 300180-154...................... 9-5
200029-004 ...................... 5-7 7-13, 7-27 205000-061 ...................... 7-9 300180-155...................... 9-5
200029-102 ...................... 7-7 200108-002..... 5-7, 5-9, 5-11, 205000-186 .................... 7-23 300180-156...................... 9-5
200030-602 ........... 7-11, 7-13 5-13 206300-138 .................... 7-23 300180-157...................... 9-5
200030-901 ............... 6-3, 6-5 200113-023.................... 6-21 207500-016 ...................... 7-9 300180-158...................... 9-5
200031-209 .................... 6-21 200113-113.................... 7-13 207500-045 ...................... 7-9 300180-159...................... 9-5
200031-251 .................... 7-29 200113-131.................... 6-13 207500-067 ...................... 7-9 300180-160...................... 9-5
200032-105 .................... 5-11 200113-402........... 7-11, 7-13 207503-052 ...................... 7-9 300180-161...................... 9-5
200037-004 .................... 8-11 200113-409.................... 7-13 207503-063 ...................... 7-9 300180-162...................... 9-5
200037-006 .................... 6-13 200113-416.................... 7-13 210002-012 ...................... 7-9 300180-163...................... 9-5
200037-007 .................... 1-15 200113-421.................... 7-13 210002-043 ...................... 7-9 300180-164...................... 9-5
200038-001 .................... 8-17 200113-423...................... 6-5 210003-038 ...................... 7-9 300180-165...................... 9-5
200038-003 .............8-5, 8-11 200113-434...................... 6-3 300028-013 .................... 1-15 300180-183...................... 9-5
200039-003 ...................... 2-3 200113-438........... 7-11, 7-13 300028-903 .................... 1-11 300180-184...................... 9-5
200039-024 .....5-7, 5-9, 5-11, 200113-612.................... 6-13 300028-904 ...........1-11, 1-21 300180-185...................... 8-7
5-13 200113-613.................... 6-17 300028-905 ...........1-11, 1-21 300180-186...................... 9-5
200039-028 .............3-7, 3-29 200113-702.................... 6-13 300028-938 .................... 8-31 300180-187...................... 9-5
Part Number Page Part Number Page Part Number Page Part Number Page
300180-188 ...................... 9-5 600136-005 ............ 1-5, 1-23 700533-086 .................... 3-21 900003-597...................... 6-9
300188-016 .................... 6-17 600150-035 ....................8-13 700535-016 .................... 3-23 900003-598...................... 6-9
300188-018 .................... 6-21 680087-005 ......................9-5 900002-795 ...................... 2-3 900003-613.................... 6-21
300191-225-................... 8-21 700066-233 ....................1-27 900003-483 .................... 6-23 A11-00100-00 .... 7-3, 7-5, 7-7
300191-226 .................... 8-21 700066-238 ....................3-27 900003-484 .................... 6-19 A11-00200-00 ................ 5-15
300191-227 .................... 8-21 700080-006 ......................6-7 900003-485 .................... 6-25 A11-00300-00 .................. 7-7
300191-228 .................... 8-21 700080-007 ......................6-7 900003-487 .................... 6-17 A11-00400-00 .................. 1-7
300191-229 .................... 8-21 700080-009 ......................6-7 900003-496 .................... 1-21 A12-10025-00 .................. 7-7
300191-231 .................... 8-21 700121-232 ....................1-27 900003-497 .................... 1-21 A13-00111-00 . 5-7, 5-9, 5-11,
300199-004 .................... 7-31 700121-542 ....................1-13 900003-530 .................... 1-19 5-13
300202-017 ............... 5-7, 5-9 700121-543 ......................1-9 900003-531 .................... 1-19 A13-10100-00 ................ 5-15
300202-021 .................... 5-13 700121-544 ......................1-9 900003-532 .................... 1-19 A21-11026-00 .................. 6-7
300202-204 ......5-7, 5-9, 5-11 700121-545 ....................1-11 900003-533 .................... 1-19 A41-37024-00 ................ 1-17
300209-005 ...................... 3-9 700121-546 ....................1-11 900003-534 .................... 1-19 A41-37032-00 ................ 1-17
300209-006 ...................... 3-9 700128-500 ....................3-15 900003-535 .................... 1-19 A42-01037-00 . 1-7, 1-17, 7-3,
300209-007 ......5-7, 5-9, 5-11 700128-526 ....................8-15 900003-536 .................... 1-19 7-5, 7-7
300221-001 ........... 8-11, 8-13 700128-527 ....................8-13 900003-537 .................... 1-19 A51-M1225-0F ................. 7-7
300221-002 ...................... 8-5 700128-554 ......................2-3 900003-538 .................... 1-19 A51-M3737-MF .............. 1-17
300221-003 ...................... 8-7 700505-161 ....................3-29 900003-539 .................... 1-19 A52-A2525-MF .............. 1-17
300221-004 .................... 8-17 700505-162 ....................3-29 900003-540 .................... 1-19 A52-M2537-MF .............. 1-17
300221-005 .................... 8-17 700505-163 ....................3-29 900003-541 .................... 1-19 A52-M3737-MF ................ 7-7
300221-006 ...................... 8-9 700517-113 ......................2-3 900003-542 .................... 1-19 A54-M3725-MF ................ 7-7
300221-008 ...................... 8-3 700517-114 ......................2-3 900003-543 .................... 1-19 A57-03725-00 ................ 1-17
300221-010 .................... 8-13 700519-052 ......................1-5 900003-544 .................... 1-19 C12-06050-86 6-7, 7-13, 8-15
300225-001 .................... 8-25 700519-053 ......................1-5 900003-545 .................... 1-19 C12-11075-863-27, 6-7, 7-29,
300225-002 .................... 8-27 700519-054 ......................1-5 900003-546 .................... 1-19 8-7
300225-003 .................... 8-23 700525-069 .............. 2-3, 3-5 900003-547 .................... 1-19 C14-37150-24.................. 3-5
300225-004 .................... 8-27 700526-041 ......................3-7 900003-548 .................... 1-19 C15-98100-80.................. 4-3
300225-005 .................... 8-29 700526-042 ......................3-7 900003-549 .................... 1-19 C21-25075-86.................. 6-7
300225-015 .................... 6-11 700527-038 ......................3-9 900003-550 .................... 1-19 C21-25100-86 3-7, 3-17, 8-13
500022-017 .................... 1-27 700527-039 ......................3-9 900003-551 .................... 1-19 C21-31075-86.................. 2-3
500022-040 .................... 3-27 700527-040 ......................3-9 900003-552 .................... 1-19 C21-31125-86.................. 1-7
500022-041 .................... 3-27 700529-169 ....................3-13 900003-553 .................... 1-19 C21-37100-81.................. 6-5
500022-042 .................... 3-29 700529-170 ....................3-13 900003-554 .................... 1-19 C21-37100-86... 2-3, 3-5, 3-9,
500034-051 ......5-7, 5-9, 5-11 700529-171 ....................3-13 900003-555 .................... 1-19 3-27, 5-5, 5-9,
500034-052 ......5-7, 5-9, 5-11 700529-173 ....................3-11 900003-556 .................... 1-19 6-7, 8-15
500034-053 .................... 6-13 700529-175 ....................3-13 900003-557 .................... 1-19 C21-37125-861-9, 1-11, 1-21,
500045-112 .................... 1-13 700529-179 ....................3-13 900003-558 .................... 1-19 5-3, 5-9, 5-13,
500076-057 ...................... 6-7 700533-024 ......................1-5 900003-559 .................... 1-19 6-7
500076-058 ...................... 6-7 700533-025 ......................1-5 900003-561 .................... 1-19 C21-37150-861-9, 1-11, 1-13,
500076-059 ...................... 6-7 700533-026 ....................3-27 900003-562 .................... 1-19 8-17
500086-006 ...................... 2-3 700533-027 ......................1-7 900003-569 ........... 7-11, 7-13 C21-44125-81.................. 6-5
500086-007 ...................... 3-5 700533-028 ....................1-21 900003-571 .................... 6-11 C21-50150-811-13, 3-27, 6-13
500086-010 .................... 3-25 700533-029 ....................1-21 900003-572 ........... 7-11, 7-13 C21-50150-86 3-15, 3-29, 5-5
500088-017 ...................... 3-7 700533-034 ......................8-3 900003-573 .................... 6-19 C21-50175-81.................. 6-7
500088-018 ...................... 3-7 700533-035 ......................8-3 900003-574 .................... 6-21 C21-50200-81....... 3-15, 6-15
500088-019 ...................... 5-5 700533-036 ......................8-3 900003-575 .................... 6-23 C21-50200-86................ 3-23
500089-007 ...................... 3-9 700533-037 ....................8-17 900003-585 .................... 6-11 C21-50250-81.................. 3-7
500093-022 .................... 3-11 700533-039 ......................3-5 900003-586 ...................... 6-9 C21-50300-81................ 6-25
500097-009 .................... 3-11 700533-050 ......................1-5 900003-587 ...................... 6-9 C21-56250-81.................. 6-5
500097-013 .................... 3-13 700533-051 ......................1-5 900003-588 ...................... 6-9 C21-62150-81.................. 1-7
500097-014 .................... 3-13 700533-061 ......................8-3 900003-589 ...................... 6-9 C21-62200-81.................. 4-3
500097-015 .................... 3-13 700533-062 ....................8-17 900003-590 ...................... 6-9 C21-62225-81.................. 1-9
500097-017 ...................... 5-5 700533-071 ....................6-21 900003-591 ...................... 6-9 C21-62300-81.................. 3-5
500097-021 .................... 1-23 700533-072 ......................5-9 900003-592 ...................... 6-9 C21-62400-81................ 3-17
500097-023 .................... 3-11 700533-079 ....................1-21 900003-593 ...................... 6-9 C21-62518-09.................. 1-5
500099-001 .................... 1-17 700533-080 ....................1-21 900003-594 ...................... 6-9 C21-75250-86................ 3-23
500099-005 ...................... 1-5 700533-084 ......................3-7 900003-595 ...................... 6-9 C21-75350-81................ 6-21
600116-402 .................... 5-17 700533-085 ......................3-7 900003-596 ...................... 6-9 C21-75550-81.................. 2-3
Part Number Page Part Number Page Part Number Page Part Number Page
C21-98550-81 ................ 1-17 C42-03750-861-9, 1-11, 1-13, 5-17, 7-9 H62-B0404-0F ............... 7-29
C22-31150-81 .................. 8-3 1-21, 2-3, 3-5, C94-10100-00 ................ 5-11 H62-B1616-00.................. 7-9
C23-25100-86 ................ 3-27 3-9, 3-29, 5-3, C94-10200-00 ................ 5-11 H62-D0404-00 ..... 6-19, 6-21,
C23-62750-00 .................. 1-5 5-5, 5-9, 5-13, C94-F5075-00 .........5-5, 5-11 6-23, 6-25
C24-12035-80 .................. 6-3 6-7, 8-15, 8-17 C94-N0062-00.................. 5-5 H62-D0604-00 ..... 6-21, 7-11,
C27-75200-82 .................. 1-5 C42-04413-80 .................. 6-5 C94-W0010-00 ........5-7, 5-11 7-13, 7-27
C27-75250-82 .................. 1-5 C42-05010-863-23, 3-27, 3-29 C94-WG0000-00 .....5-9, 5-13 H62-D0608-00 ................. 6-5
C27-75275-82 .................. 1-5 C42-05012-821-13, 3-7, 3-15, C95-00015-24 ................ 5-11 H62-D1010-00 ............... 6-17
C29-25137-56 .........5-7, 5-11 5-5, 6-7 C95-00100-15 .................. 6-7 H62-D1212-00 ................. 6-3
C30-03701-86 1-9, 1-11, 1-13 C42-05013-81 ....... 6-15, 6-25 C95-00100-21 5-7, 5-9, 5-11, H62-E0404-00................ 7-13
C31-02501-86 .3-7, 3-17, 5-7, C42-07510-86 ................ 3-23 5-13 H62-E1212-90........... 2-3, 7-9
5-11, 8-13, 8-17 C42-07513-80 ......... 2-3, 6-21 C95-00100-24 .................. 5-7 H62-F1616-00.................. 6-3
C31-02504-81 .........5-9, 5-13 C42-10013-80 ................ 1-17 C95-00135-24 ................ 5-11 H62-N0402-00 ............... 3-21
C31-03101-86 .................. 1-7 C43-05019-81 ......... 5-9, 5-13 C95-00150-24 .................. 5-9 H64-00404-00 ................ 7-29
C31-03104-81 .................. 8-3 C43-06218-00 .................. 1-5 C95-03000-25 .........6-7, 7-13 H64-D1616-00 ................. 6-5
C31-03701-861-13, 1-21, 2-3, C49-00400-BN ..... 7-15, 7-17, C95-05000-45 ................ 7-29 H64-E0606-00................ 7-13
3-5, 3-9, 3-27, 7-19, 7-21, 7-27 C96-10100-00 .................. 3-7 H64-U0404-00 ............... 7-13
3-29, 5-3, 5-5, C49-75016-00 .................. 1-5 C96-34375-03 ................ 1-23 H66-E0404-00...... 7-15, 7-17,
5-9, 5-13, 6-7, C51-03700-00 ....... 1-11, 1-13 C99-00323-00 5-7, 5-9, 5-11, 7-19, 7-21, 7-27
8-3, 8-15, 8-17 C51-07500-00 ................ 1-21 5-13 H90-10012-00 ........... 2-3, 7-9
C31-03703-81 ..1-27, 6-5, 6-7 C51-10000-00 ................ 1-21 C99-00646-00 .......3-11, 3-27 H90-10040-00 ........... 2-3, 7-9
C31-05002-86 ...... 3-15, 3-27, C51-12500-00 ......... 1-11, 5-3 C99-02804-00 ................ 3-23 H91-10011-02 ................ 6-15
3-29, 5-5 C53-05000-01 .................. 5-9 C99-18001-00 ................ 3-11 H92-01917-06 ................ 6-13
C31-05003-81 ................ 6-15 C53-07500-017-17, 7-21, 7-25 C99-44024-00 5-7, 5-9, 5-11, H93-21030-00 ................ 6-13
C31-05004-81 ....... 1-13, 6-15 C54-56150-00 .. 5-3, 5-5, 5-11 5-13 M51-10515-00.................. 1-5
C31-05006-81 .3-7, 3-29, 6-7, C59-00002-00 ....... 1-27, 1-29 C99-75425-00 .......3-11, 3-27 M51-10520-00................ 1-15
6-25 C61-12150-02 .................. 6-5 D105-00757...................... 4-3 M72-00128-00. 5-7, 5-9, 5-11,
C31-05604-81 .................. 6-5 C61-18150-03 ................ 3-23 D105-00758...................... 4-3 5-13
C31-05606-81 .................. 6-5 C64-98250-00 ................ 3-23 D110-00755...................... 4-3 M72-10016-00................ 3-11
C31-06203-81 .........1-9, 3-17 C65-99200-00 ................ 3-11 D110-00756...................... 4-3 M72-13013-00................ 1-21
C31-06204-81 ...1-7, 1-9, 3-7, C69-63137-00 ................ 6-19 E51-97778-00.................8-15 M72-24016-00.................. 1-9
3-13 C81-03750-00 ......... 5-9, 5-13 E51-97778-01.................8-15 M72-24028-00................ 1-11
C31-06206-81 .................. 3-5 C81-W050R-13 ................ 5-5 E52-30250-00 1-11, 1-21, 3-7 M99-00011-00................ 1-29
C31-10004-81 ................ 1-17 C81-W98BL-00 5-3, 5-5, 5-11 G21-04108-00 .................. 6-3 P-3510A ......................... 8-15
C33-00807-03 .................. 8-5 C84-04090-88 .................. 5-5 G21-PK7500-0 ................. 6-3 S01-000V0-00................ 3-17
C34-05002-86 ................ 3-23 C84-C0050-00 ................. 5-3 H10-25700-00 ................ 6-11 S01-00790-00 ................ 3-15
C36-05000-82 ................ 3-27 C84-J0037-00 ......... 5-9, 5-13 H11-25600-01 ................ 6-11 S01-00AV0-00 ............... 3-19
C39-37137-091-9, 1-11, 1-13, C84-J0100-005-5, 5-11, 5-13, H12-22702-00 ................ 7-13 S01-00CK0-00 ............... 3-19
6-13 5-17 H12-22702-01 ................ 7-13 S01-00Y00-00................ 3-19
C40-10000-00 .................. 5-3 C84-J2357-00 .................. 5-9 H12-25700-01 ................ 6-11 S02-02017-00 ................ 3-17
C41-00820-06 .................. 8-7 C84-J2537-00 ......... 5-9, 5-13 H12-25700-02 ................ 6-11 S02-02018-10 ................ 3-17
C41-02510-863-17, 5-7, 5-11, C84-N0050-00 ............... 5-11 H12-25700-04 ................ 6-11 S03-00420-00 ......... 3-7, 3-15
8-13 C84-N0100-005-5, 5-11, 5-13, H12-25700-05 ................ 6-11 S03-00430-00 .................. 3-5
C41-02514-86 ....... 3-27, 6-21 5-17 H12-25800-00 .........5-9, 5-13 S03-00920-00 ................ 3-27
C41-03110-81 ....... 7-11, 7-13 C84-N0100-04 ............... 5-11 H12-34001-00 ................ 6-11 S03-00AF0-00................ 3-27
C41-03130-82 .................. 8-3 C84-N0200-00 ............... 5-11 H31-10027-00 .................. 6-5 S03-00DB0-00 ................. 3-5
C41-03710-811-27, 3-11, 3-27 C84-P0051-00 ................. 5-5 H31-10101-58 .................. 6-3 S03-01280-00 .................. 1-7
C41-05710-82 .................. 6-5 C84-P0051-01 ................. 1-7 H31-10101-59 .................. 6-5 S05-00310-00 ......... 1-9, 1-11
C41-06210-80 .................. 1-7 C84-T0100-00................ 5-11 H31-10103-01 .................. 6-5 S05-00750-00 ................ 1-21
C41-06210-81 .........1-9, 3-17 C84-T0100-50.................. 5-5 H32-10006-00 .................. 6-3 S05-01890-00 ................ 1-13
C41-10013-81 ................ 1-17 C84-T1100-505-5, 5-11, 5-13, H32-10100-00 .................. 6-3 S05-04800-00 ................ 1-13
C42-00622-00 .................. 6-7 5-17 H41-10110-00 .......3-23, 6-19 S12-00CM0-00............... 1-25
C42-00622-06 ....... 7-13, 8-15 C91-03070-00 ................ 1-11 H42-20022-00 ................ 6-25 S12-00EA0-00 ................. 1-5
C42-01125-063-27, 6-7, 7-29, C91-03071-00 .................. 3-7 H43-10011-00 ................ 6-23 S12-00HB0-00 ................. 1-5
8-9 C91-11400-00 ................ 8-11 H61-A1616-00 .................. 7-9 S12-02170-01 .................. 1-5
C42-02512-863-7, 7-17, 7-21, C91-30700-00 ................ 1-21 H61-B0404-0F................ 7-13 S12-02250-00 .................. 1-5
7-25, 8-13, 8-17 C92-11012-00 .................. 3-5 H61-B1616-00 .................. 7-9 S12-03480-01 .................. 6-5
C42-03112-86 .................. 1-7 C94-00050-00 5-3, 5-11, 5-17 H61-D0604-00................ 7-27 S12-09970-01 ................ 1-29
C42-03712-82 ....... 3-11, 3-27 C94-00100-005-5, 5-11, 5-13, H61-D1216-00.................. 6-5 S12-09970-02 ................ 1-29
Part Number Page Part Number Page Part Number Page Part Number Page
S15-000F0-00 ................ 3-21
S15-000F0-01 ................ 3-21
S15-000F0-02 ................ 3-21
S15-000F0-03 ................ 3-21
S15-000F0-04 ................ 3-21
S15-000F0-05 ................ 3-21
S15-000F0-06 ................ 3-21
S15-000F0-07 ................ 3-21
S15-000F0-08 ................ 3-21
S15-000F0-09 ................ 3-21
S15-000F0-10 ................ 3-21
S15-000F0-12 ................ 3-21
S15-00BL0-00 ................ 3-21
S17-000R0-00................ 5-11
S17-00250-00 ......... 5-7, 5-11
S17-00610-00 ......... 5-9, 5-13
S17-02430-00 ................ 5-13
S17-02500-00 .................. 5-9
S17-50830-01 . 5-7, 5-9, 5-11,
5-13
Phone: 330-308-6727
Toll Free: 1-877-KIMBLES
Fax: 330-339-4892