Documente Academic
Documente Profesional
Documente Cultură
Saved Info Embed Print
D
Volvo Trucks North America Date Group No. Page
Service Bulletin 7.2007 214 52 6(17)
12
Remove the engine wiring harness support bracket from
the front of the valve cover.
W2004679
13
Remove the spring- loaded attaching bolts from the
valve cover.
T2020552
14
Lift and remove the valve cover.
15
Assemble the flywheel turning tool as follows:
Remove the snap ring and gear from tool 9996956.
Assemble the
85108855 andgear from
install the9996956 into
snap ring. adaptergear
Lubricate tool with
engine oil or grease before attempting to turn the flywheel.
D
16
Remove the inspection cover from the bottom of the
flywheel housing and install the flywheel turning tool
(85108855 with gear 9996956). Remove the rubber plug
in later models for engine turning tool 88800014.
W2005139
17
Camshaft markings for setting of valves and unit
injectors:
D
Volvo Trucks North America
Service Bulletin
Date
7.2007
Group
214
No.
52
Page
8(17)
This document is...
Intake Valves, Adjustment
18 Useful
Using the flywheel turning tools, rotate the engine to the
Not useful
next camshaft marking for adjustment of the intake valve.
Rotate the engine until the valve and injector mark on the
front end of the camshaft aligns with the stamped mark
on the camshaft front bearing cap.
19
Does not apply to valve bridge without locating
pin (non-adjustable):
Search
the valve location of the intended adjustment.
38 ± 4 Nm (28 ± 3 ft-lb)
20
With the engine
approximately 60cold (engine
C (140 F),temperature of
continue adjustment on the
same inlet rocker by checking the valve clearance. Push
down on the back of the rocker and insert a feeler gauge
of the proper specification of 0.3 ± 0.05 mm (0.012 ±
0.002 in.) between the bridge and the adjustment screw.
If the inlet rocker requires adjustment loosen the lock nut