Documente Academic
Documente Profesional
Documente Cultură
5.3.1 Purpose
If the FTE NIC is not installed at the factory, use the procedures in this section to install and
configure the FTE NICs for your FTE node. For further information, refer to the vendor-specific
documentation.
In addition, refer to the following topics in Planning, Installation, and Service Guide, for further
information about the specific platform being installed.
- 41 -
Chapter 5 - Install FTE hardware
Chapter 5 - Install FTE hardware
l FTE Slot Requirements in System Planning section.
5.4.1 Install Intel network driver and PROSet software for the Intel
NICs
Perform the following procedure to install Intel network driver and PROSet software for Intel NICs.
- 44 -
ATTENTION
l Before you begin, ensure that you have used the dual NICs listed in FTE-qualified
NICs, for configuring FTE on computers that do not have the onboard adapters.
l If drivers were downloaded from the Honeywellprocess.com website, ensure that
the instructions included with the drivers are followed instead of this procedure.
CAUTION
If FTE is installed and is operating, disable the FTE by performing the procedure in Unbind
physical adapters from Honeywell FTE adapter, before updating the adapter driver version.
Install Intel drivers
1. Insert the Experion PKS System Initialization media in the DVD drive.
2. In the Honeywell –Experion PKS System Initialization window, click Utilities.
3. On the left pane, click NIC Drivers.
4. Select the Intel NIC driver that applies to your system and then follow the instructions onscreen
to complete the installation.
5. Return to the checklist.