Documente Academic
Documente Profesional
Documente Cultură
Hardware Ver. 2
This new interface allows you to decode with IMMO-OFF or Virgin most
Marelli ECU (59F; 5AF; 4AF; 4EF; 5NF - Hardware > 100 and < 100). No
Boot, No Open ECU, No computer use, all in one minute. It is able to recognize
automatically the type of ECU, and to verify the current status through LED.
DECODING
To begin the process of decoding press the ON/OFF button
once (Green LED START);
now the interface queries the ECU and displays by the RED
LED and the LED ORANGE the current code this:
WARNING:
In the event that the ECU does not communicate, the interface indicates the error with
the flashing of all LEDs for 3 seconds, returning to the position of StandBy.
Notes for 5AF: Only in case of failure to start, cut the two lines CAN pin n. 20
and n. 29
Connettore M
Pin 5 :-> Massa (Ground)
Connettore V
Pin 16 :-> +12Volt
Pin 12 :-> +12Volt (Key On)
Pin 10 :-> K Line
To begin the process of decoding connect the ECU to the diagram, and power interface, then press and hold
the "DECODE" button for 3 seconds until Green LED START will flash quickly. Now the interface is in IAW
8/16/18F.
At this point, insert the wire BOOT between pins 2 and 3 of the processor (68HC11F1), then press once the
ON / OFF button immediately after removing the tip of the BOOT;
If everything goes well the RED Led and Orange Led flash rapidly, indicating that the procedure of
decoding. After about 10 seconds interface will return to the initial position (green LED Flashing START).
Led Green with RED and Orange Fixed, Flashing Fast decoding in progress
Led Green with RED and Orange Fixed, Flashing slowly BOOT wrong or ECU Not Found
Led Green quickly Standby mode ECU Iaw 8/16/18F
CAUTION: If for some reason the unit does not communicate, the interface indicates that
error or fault by the simultaneous flashing of all LEDs for 3 seconds and then returns to the
position of StandBy.