Documente Academic
Documente Profesional
Documente Cultură
Pantalla anterior
Bienvenido: cr080x0058223x09
Producto: TRUCK ENGINE
Modelo: C13 TRUCK ENGINE LEE17574
Configuración: C13 On-Highway Engine LEE00001-UP
Desarmado y Armado
C13 Engine
Número de medio -RENR9705-09 Fecha de publicación -01/12/2014 Fecha de actualización -09/12/2014
i02736779
Camshaft - Install
SMCS - 1210-012
Installation Procedure
Table 1
Required Tools
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpa… 1/4
29/1/2019 C13 On-Highway Engine LEE00001-UP(SEBP4356 - 61) - Documentación
Illustration 1 g01292428
Note: Ensure that camshaft (6) and Tooling (B) are clean. Apply clean engine oil to the lobes and
journals of camshaft (6) and Tooling (B) .
Note: During installation of camshaft (6), rotate the camshaft in both directions in order to prevent
binding in the camshaft bearing bores.
NOTICE
When installing the camshaft, make sure the number one cylinder is at
top center of the compression stroke with the timing bolt installed in
the flywheel. The camshaft timing is very important. The timing mark
on the camshaft drive gear must line up with the timing mark on the
idler gear. Refer to the Specifications Manual for more information.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpa… 2/4
29/1/2019 C13 On-Highway Engine LEE00001-UP(SEBP4356 - 61) - Documentación
Illustration 2 g01292427
3. Ensure that the timing Marks (X) on the idler gear are aligned with the timing marks on the crankshaft
gear and the camshaft drive gear.
Illustration 3 g01372193
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpa… 3/4
29/1/2019 C13 On-Highway Engine LEE00001-UP(SEBP4356 - 61) - Documentación
Illustration 4 g01011039
End By:
a. Install the camshaft position sensor. Refer to Disassembly and Assembly, "Camshaft Position Sensor -
Remove and Install".
b. Install the front cover. Refer to Disassembly and Assembly, "Front Cover - Install".
c. Install the rocker arm and shaft. Refer to Disassembly and Assembly, "Rocker Arm and Shaft -
Install".
Copyright 1993 - 2019 Caterpillar Inc. Tue Jan 29 2019 20:39:32 GMT-0500 (hora estándar oriental)
Todos los derechos reservados.
cr080x0058223x09
Red privada para licenciados del SIS.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpa… 4/4