Documente Academic
Documente Profesional
Documente Cultură
PC001WP
Product Description
SealArm Tape TPE is a thermoplastic high igh performance water proofing Joint Tape for expansion and connection joints
and cracks. It is to be installed with ReArm Bond 4031
4031. When fixed to the joint, it allows irregular and high movement in
more than one direction, whilst maintaining a high quality seal.
Uses Features and Benefits
Application Methodology
Ver/1/May2019 1 of 4
Building & Joint Sealants
PC001WP
Mixing: ReArm Bond 4031 Apply the adhesive at a thickness of 1 mm over the full
Mix parts A+B together for at least 3 minutes with a width of the SealArm Tape TPE and extend a minimum
mixing spindle attached to a slow speed (200 -300 RPM) of 10mm beyond edges of the SealArm Tape TPE and
electric drill (max 600 rpm) until the material becomes finally ensure a neat and precise finish.
smooth in consistency and a uniform grey colour. Avoid
aeration while mixing. Then, pour the whole mix into a Jointing / Connection of SealArm Tape TPE
clean container and stir again for approx. 1 more minute
at low speed to keep air entrapment at minimum. Mix The layer to be overlapp
ped (50 mm) shall be done with
only that quantity which can be used within its pot life. adhesive.
Ver/1/May2019 2 of 4
Building & Joint Sealants
Legal Note
The information, and, in particular, the recommendations relating to the application and end end-use
use of MYK Arment products, are given in good
faith based on MYK Arment current knowledge and experience of the products when properly stored, handled and applied under no normal
conditions in accordance withh MYK Arment’s recommendations. In practice, the difference in materials, substrates and actual site conditions
are such that no warranty in respect of merchant ability or of fitness for a particular purpose, nor any liability arising ou
out of any legal relationship
whatsoever, can be inferred either from this information, or from any written recommendations, or from any other advice offer offered. the user of
the product must test the product's suitability for the intended application & purpose. MYK Arment reserve
reserves the right to change the properties
of its products. the proprietary rights of third parties must be observed. All orders are accepted subject to our current ter terms of sale and
delivery. Users must always refer to the most recent issue of the local product data sheet for the product concerned, copies of which will be
supplied on request.
4 of 4
Ver/1/May2019