Documente Academic
Documente Profesional
Documente Cultură
Source: http://newsgroups.derkeiler.com/Archive/Comp/comp.dcom.sys.cisco/2007−08/msg00345.html
• From: icschorr@xxxxxxxxxxxxxx
• Date: Sun, 12 Aug 2007 10:59:11 −0700
Hello all, I just purchased a Cisco ASA 5505 and I am having trouble
configuring my device to work with my BellSouth DSL connection. I
tried placing the Netopia 3347NWG in what's called bridge mode but
then configure the 5505 for PPPOE but authentication continued to
fail.
Now I am going to try PPPoE with a Routed Subnet, using the
instructions from the Netopia link below (http://www.netopia.com/
support/hardware/technotes/CQG_042.html)
−JT−
hostname JASZLINK−5505
domain−name jaszlink.net
enable password xxxxx encrypted
names
name 10.1.1.200 DC01 description Doman Controller
name 10.1.1.206 Dev01 description Development Server
name 10.1.1.202 Exchange01 description Exchange Server
name 10.1.1.204 Project01 description Project Server
!
interface Vlan1
description Inside Network Interface
nameif inside/LAN
security−level 100
ip address 10.1.1.1 255.255.255.0
!
interface Vlan2
description Outside Network Interface
nameif outside/WAN
security−level 0
ip address 72.151.92.106 255.255.255.248
!
interface Ethernet0/0
!
class−map inspection_default
match default−inspection−traffic
!
!
policy−map type inspect dns preset_dns_map
parameters
message−length maximum 512
policy−map global_policy
class inspection_default
inspect dns preset_dns_map
inspect ftp
inspect h323 h225
inspect h323 ras
inspect rsh
inspect rtsp
inspect esmtp
inspect sqlnet
inspect skinny
inspect sunrpc
inspect xdmcp
inspect sip
inspect netbios
inspect tftp
Hello,
when you have a routed subnet you must set the default route /for the
internet/. So I don't can see your routing information.