Documente Academic
Documente Profesional
Documente Cultură
!
!
!
spanning-tree mode pvst
!
!
!
!
!
!
interface GigabitEthernet0/0
no ip address
duplex auto
speed auto
shutdown
!
interface GigabitEthernet0/1
no ip address
duplex auto
speed auto
shutdown
!
interface Vlan1
no ip address
shutdown
!
ip classless
!
Router#conf
Router#configure t
Router#configure terminal
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#con
Router(config)#in
Router(config)#interface g
Router(config)#interface gigabitEthernet 0/0
Router(config-if)#no sh
Router(config-if)#no shutdown
Router(config-if)#
%LINK-5-CHANGED: Interface GigabitEthernet0/0, changed state to up
Router(config-if)#ip ad
Router(config-if)#ip address 192.168.1.1 255.255.255.0
Router(config-if)#^Z
Router#
%SYS-5-CONFIG_I: Configured from console by console
Router#show flash
Router#copy fla
Router#copy flash: tf
Router#copy flash: tftp:
Source filename []? c1900-universalk9-mz.SPA.151-4.M4.bin
Address or name of remote host []? 192.168.1.2
Destination filename [c1900-universalk9-mz.SPA.151-4.M4.bin]?
Writing c1900-universalk9-mz.SPA.151-
4.M4.bin....!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!
[OK - 33591768 bytes]
Router#
Router#
Router#copy run
Router#copy running-config tf
Router#copy running-config tftp:
Address or name of remote host []? 192.168.1.2
Destination filename [Router-confg]? R1-run
Writing running-config...!!
[OK - 645 bytes]
santhosh#copy tf
santhosh#copy tftp: run
santhosh#copy tftp: running-config
Address or name of remote host []? 192.168.1.2
Source filename []? R1-run
Destination filename [running-config]?
Accessing tftp://192.168.1.2/R1-run...
Loading R1-run from 192.168.1.2: !
[OK - 645 bytes]
Router#
Router#
Router#enable