Documente Academic
Documente Profesional
Documente Cultură
sites.google.com/site/azboxmeinfo/home/cardsaring-in-home/cgfnmgjhkl
A quick & basic guide to setting up a internal (in house) cardsharing system with CCCam
card emulator software. This may be useful for resharing around your own home etc.
Next make sure that you have CCcam and CCcam.cfg installed on your box.
(depending on image you may need to ftp CCcam to your box whereas others allow the
direct download thru the box)
After you have installed CCcam make sure to set it as your default cam. (usually found in
blue panel or softcam/ci from menu)
1/3
Next go to CCcam.cfg and add your F line to the box which you will provide the share
from.
After this has been done we will then access CCcam.cfg on the box which you wish to
receive the share on and add the corresponding C line.
2/3
Note that the F and C line don’t need to follow the traditional format used when sharing
with external peers.
(Note: dreamboxIP is from the box we are sharing from i.e. where we added our F line –
default port is usually 12000 though for security purposes I would advise changing that)
In CCcam.cfg make sure to remove any # from in front of the F or C line otherwise the
command will not be active.
After you have done this save and exit CCcam.cfg and if all has gone to plan we should
now have our internal share up and running.
To add more boxes to your internal share simply follow the same procedure as above and
add a F line to your master box for each slave box on your internal network and the
corresponding C line to any additional slave box which you might wish to add.
It makes things easier to assign each box on a network a static IP which was described at
the beginning of this post.
Just gonna add to make sure CCcam is setup as the default cam on the receiving box also,
otherwise the share will not be successful – this caught a few people out in the past.
3/3