Case No/Job Title: F4-82/2015-R [APPRAISING/ VALUATION OFFICER]
Ministry/Department: FEDERAL BOARD OF REVENUE/REVENUE DIVISION
Grade: BS-16 Special Pay: (i) Examination of export/import consignments/ goods at wharfs/ Dry ports/ Airport/ Customs stations etc. and detection of mis-declarations. (ii) Reconciliation/audit of temporary import bonds (Raw material & machinery). Job Duties: (iii) Assessment of duty/taxes and determination of value of consignment in accordance with the Customs Act, 1969. (iv) Confirmation of Pakistan Customs Tariff(PCT) headings, ascertains and cross checks the value, type quality and quantity of the consignment. Job status: Permanent Eligibility: Both male and female candidates are eligible Any relaxation in Maximum age Plus five (5) years general relaxation in upper age limit. limits Min Age: 20 Max Age: 28 (i) Second Class or Grade ‘C’ Bachelor’s degree from a recognized university with Economics, Commerce, Statistics, Qualification/Experience Accounting, Computer Science, Law, Pharmacy, Chemistry or Physics as one of the subjects or B.Sc. Engineering in required: any speciality. (ii) Computer literacy up to the level of MS Word, MS Power Point and MS Excel. MERIT=17, PUNJAB=113, SINDH(R)=26, SINDH(U)=17, KHYBER_PAKHTUNKHWA=26, BALOCHISTAN=14, Domicile: GBFATA=9, AJK=5, Closing Date: 27-JUL-15 DOMICILE: Merit= Seventeen, Punjab= One Hundred and Thirteen (Open merit=Ninety Six, Women quota= Eleven and Minorities/Non-Muslims quota=Six), Sindh(Rural)=Twenty Six (Open merit=Twenty Two, Women quota=Three and Minorities/Non-Muslims quota=One), Sindh(Urban)=Seventeen (Open merit= Fourteen, Women quota=Two and Note: Minorities/Non-Muslims quota=One), Khyber Pakhtunkhwa=Twenty Six (Open merit=Twenty Two, Women quota= Three and Minorities/Non-Muslims quota=One), Balochistan=Fourteen (Open merit=Twelve, Women quota=One and Minorities/ Non-Muslims quota=One), GBFATA=Nine (Open merit=Eight and Women quota=One) and AJK=Five (Open merit=Four and Women quota=One).
Prepred by: waqas ur rehman. Engr_waqas12@yahoo.com Page 1
SUPARCO test Ques:
1- Which of the following effects dominate in long transmission lines?
(skin, feranti*, compton) 2- disruptive critical voltage for air is? (10kv/cm, 20kv/cm, 30kv/cm*, 40kv/cm) 3- at 11kv which of the following insulators used? (pin type*, suspension, string, none of above) 4- surge impedance of HV transmission line has a value of ? (20, 100, 300*, 400, 500) ans Zo is of order of 250-350 ohm 5- Xtic impedance relation ship with T/L length? ans independant of Length 6- loss angle ? The loss tangent is then defined as the ratio (or angle in a complex plane) of the lossy reaction to the electric field Ein the curl equation to the lossless reaction: 7- shielding angle for overhead transmission lines? (15, 30*, 45, 60) 8- if system freq increased from 50 to 53 hz, which of the following will be affected most? (power transformer*, alternator, turbine, all) 9- effect on capacity of T/L line if freq changed from 50 to 60hz? 10- no of discs used for 220 kv? (10, 15*, 20) 11- spacing between bundle conductors in T/L line? (20, 30, 60, 80) 12- GMD, GMR 13- 2 to 3 per unit questions (memorise formulae) 14- relationshhip between inductance and GMD, GMR? 15- HVDC used for ? (Long distances*, short distances, medium)
Prepred by: waqas ur rehman. Engr_waqas12@yahoo.com Page 2
16- non uniform dist of current ? (ferranti, skin*, proximity) 17- conductor inner flux relation with frequency? 18- marginally stable system? (having real part of roots= zero) 19- 20- load factor numerical 21- capacity factor num 22- load curve num 22- running cost base ascending order of hydel, thermal, nuclear, diesel 23- max Transmission V in pak? 500kv 24- turbine efficiency can be increased by (regenerating, reheating, intercooling, all) 25- which of the following is more stable? cylindrical or salient pole gen 26- when exciting of syn gen is off, it acts as? Ind gen*, ind motor, syn gen, syn motor 27- insulation resistance of cables relation with length? (inversely prop) 28- test used to find fault in under ground cables? (murrey loop*, etc) 29- when X/R=1, zero voltage regulation occur at p.f? (unity, leading 0.707*, lagging 0.707, zero) 30- real power transfer depends upon? (V diff,Angle diff*, Vs, Vr, delta s, delta r) 31- reactive power transfer depends upon? (V diff*, angle diff, Vs, Vr, etc) 32- power transfer angle practical value? (20, 30*, 45, 90) 33- Which type is common for overhead lines? All Al, all Cu, ACSR*, etc 34- communicaton system questions—about 8-10
Prepred by: waqas ur rehman. Engr_waqas12@yahoo.com Page 3
KRL TEST Ques Q1- energy stored in an inductor? (1/2 LI2) Q2-buccholz relay is used for? large internal faults*, over current protection, any of them.....(flux saturation) Q3- breathing in transformer is used for....... absorb moisture* Q4- wattmeter is used to measure ? active*, reactive, real, total power.... Q5- if shunt resistance is increased in parrallel with galvalnometer, then current sensitivity decreases, current sensitivity increases, deflection torque increases, resistance increases.....decrease* Q6- jogging is used for...... breaking, motor running and then stopping, loading motor in steps*.... Q7-emf of dc generator is Eg= 4.44 fN F, Eg=120f/P, Eg= PFNZ/60A* Q8- in bus var protection, differential bus bar scheme has a series resistance, it is due to limit voltage that can damage relay, dissipate power across the resistance, for proper functioning of relay, All of them* Q9-for parallel function of 2 transformers, it must have same polarity*, same capacity, same voltage ratio, same efficiency Q10-form factor is rms/avg*, peak/rms, avg/rms........ • Q11- output of auto-transformer is input(1-N2/N1) , output (1-N2/N1)*, output (1-N1/N2) Q12- power of 2 phase sine signal is VIcos F/2, VIcos F, sqrt (2)VIcos F* Q13- speed of induction motor is Ns, 0.5Ns, sNs, Ns(1-s)*
Prepred by: waqas ur rehman. Engr_waqas12@yahoo.com Page 4
Q14-megnatic field of straight line conductor is NIµ/(2*pi*r) , NIµ/ l(length)*, third option i don't know Q15-if core loss =1600W, copper loss =900W, then at which percent load , efficiency will be max x2(cu loss) = core loss 75%*, 100%, 50%, 25% Q16- for microwave frequency, which core of transformer is used carbon, silicon steel, ferrite*, ferromagnetic Q17-if frequency increases, hysterisis loss will • The total core loss Pc in terms of voltage and frequency is Pc = hysteresis loss + eddy current loss = KhVxf 1 -x + KeV2. Hence, eddy current is independent of frequency and hysteresis loss is inversely varies with frequency. increase, decrease*, unchanged Q18- ohm's law is not applicable on high current, low resistance, high power, semi conductors* Q19- at resonance, the angle is 45 degree, 90 degrees, 180 degrees, 0 degree* Q20- pf of transformer is always leading, lagging, 0.8, depends on the nature of load* Q21- pf of synchronous generator is dependent on load*, angular speed, armature loss, core loss Q22- efficiency of distribution transformer is maximum at no load, 50% load*, 75% load, full load Q23- magnetising component of the transformer is always lagging*, leading, any of these Q24- total current in unbalanced phase is algebraic sum of Ia+Ib+Ic, vector sum of Ia+Ib+Ic*, zero. Q25- capacitor is always designed for peak voltage*, average voltage, rms voltage Q26- spark is produced due to high resistance, high inductance*, high power, all Q27- for 6 pole sync generator, electrical degrees in one revolution is equal to degrees 360,720, 1080*, 2160
Prepred by: waqas ur rehman. Engr_waqas12@yahoo.com Page 5
Q28- max efficiency of syn generator is when which configuration is used salient poles, non-salient poles*, any of these Q29- if 1000W heater is in series with 60 W lamp, now 100W lamp is connected with heater, what will be the effect heater output will decrease* heater output will increase heater output remains constant Q30-if 220 V dc series motor is given 220 V ac, then what will happen? motor will burn, it will not start, it will work smoothly, it will function but at low power* Q31- Ac is preffered over dc due to easy transformation*, low losses in long transmission lines, high power Q32- if voltage is doubled in the transmission line, then the conductor material used will be halved*, one fourth, doubled, four times Q33- if P=1000W, voltage is 200 V, then resistance will be 20 ohm, 40 ohm*, 400 ohm, 4000 ohm Q34- which will have the least value of resistance 220V1000W , 220V 500W , 115 V 1000W*, 115V 500W Q35- if resistance of tungsten is 10 times the cold resistance; if 200 V is applied and P=1000W then resistance of cold resistance will be Q36- 3 phase induction motor has f=50Hz, 220V, 200W and s(Slip) = 3%, then rotor frequency will be ===ns=120f/6 , ns=(ns-nr)/ns 1.5 Hz, 2 Hz, 4Hz, 3Hz Q37-P=200hp,200V,50Hz, 3-phase induction motor, full load current will be ( i don't know the options) Q38- in 3-phase delta configuration, I=40A, what will be current in Y configuration 40A, 28A, 21A, 55A Q38- core loss can be taken out by test short cct test, open cct test*, ( 2 other tests i didn't study in engineering) Short Circuit test on transformer is used to determine copper loss in transformer Q39- if load on the transformer changes, then
Prepred by: waqas ur rehman. Engr_waqas12@yahoo.com Page 6
core loss is unchanged, copper loss changes*, core loss changes Q40-jogging is used due to Breaking, step by step motor speeding*, ( 2 other options)
(note: check all answer by yourself, some of ‘em may not be correct)
Prepred by: waqas ur rehman. Engr_waqas12@yahoo.com Page 7