Documente Academic
Documente Profesional
Documente Cultură
▣Ordering information
T 4 L P B 3 R P 4 C
Unit
C ℃
2 0~199.9
Temperature range 4 0~399
8 0~799
C 0~1200
F 600~1600
P Pt100Ω
Sensor input type J J(IC)
K K(CA)
R R(PR)
R Relay output
Output mode
S SSR output
C Current output(4-20mADC)
Power supply
3 110/220VAC 50/60Hz
Control mode
B ON/OFF, Proportional control
Sub output mode
P Double output
Size
L DIN W96×H96mm
Digit
4 4 Digit
Item
T Temperature
※Please check the range of temperature when select model. (Please see C-32 page)
C-31
Dual Setting Type
▣Temperature range for each sensor
(A)
Model T4LP Counter
▣Specifations
(E)
Model Panel
T4LP meter
Power supply 110/220VAC 50/60Hz
Allowable voltage range 90 ~ 110% of rated voltage (F)
Tacho/
Power consumption 3VA Speed/
Pulse
Display method 7Segment LED Display meter
C-32
T4LP
▣Connections
※RTD(Resistance Temperature Detector) : Pt 100Ω(3-wire type) ※Thermocouple : K, J, R
RTD T.C
lSSR OUT: A
24VDC ±3V 1 18
20mA Max. L
C CONTACT OUT:
lCURRENT OUT: 2 250VA C 3A 1c 17 S E N S OR
DC4-20mA H RESISTIVE LOAD
LOAD 600Ω Max. 3 16
B
4 15
L B'
C ALM OUT :
5 14
250VAC 2A 1c
H
6 13
220VAC
7 12
110VAC
8 ~ ! SOURCE 11
~
0V
9 10
▣Dimensions
118
96
18 87 13
TEM PERATUR E
1P
2P
℃
LO HI
SET SET
3 9 9 3 9 9
1 10 - +
P.B % RESE T
T4LP
lPanel cut-out
Min. 101
+ 0.8
92 - 0
Unit:mm
C-33
Dual Setting Type
▣Proper usage
(A)
◎Operation ◎Application of temperature controller and load Counter
IN PU T K ( CA ) 0~399 ℃
L Load
~ power
C COM
LO HI (F)
SE T 3 9 9 3 9 9 SE T
Tacho/
Speed/
0
H Pulse
1 10 - +
NC Relay contact output t erminal meter
P.B% RESET
T4 LP
(G)
P.B volume RE SET volume Output Relay contact capacity Display
unit
lP.B volume 1st OUT 250VAC 2A
In case of ON/OFF control, set variable F.S 0.2~3% 2nd OUT 250VAC 3A
of hysteresis, and in case of proportional control, (H)
②Turn right when offset value is lower than set case from its body.
(M)
value. (Direction ②) 5-Phase
stepping
motor &
◎NormalU Reverse operation P F P F Driver &
Controlle
Reverse operation outputs ON when processing Proportional control ON/OFF control
value is lower than setting value, and it is used with
reverse operation when heated.
On the contrary, normal operation runs conversely
and used for cooling. (This item runs as a reverse
operation)
C-34