Documente Academic
Documente Profesional
Documente Cultură
3 08.04.04 REVISED & REISSUED AS STD. SPEC. DNN AKM SSA SKG
Abbreviations:
EN European Norm
IS Indian Standard
CONTENTS
1.0 SCOPE 4
2.0 GENERAL 4
1.0 SCOPE
1.1 This specification covers additional and supplementary requirements for weldable structural
quality Steel Plates to IS: 2062 (latest), intended primarily for storage tanks and vessels.
1.2 Following Codes, standards etc. shall be followed in their latest edition and addenda, errata,
amendments unless specified otherwise:
2.0 GENERAL
2.1 The maximum under tolerance permissible on the thickness of plate shall be 0.25 mm.
Tolerances on other dimensions of plates shall be as per IS: 1852.
2.3 Reconditioning/Repair of plates by welding shall not be permitted. Surface finish shall be
ground/flush smooth and shall be free from any surface imperfection.
3.1 Heat analysis and product analysis shall be carried out for each heat and chemical composition
shall meet the limits as specified in IS: 2062.
3.2 Y-groove weld crackability test as per IS: 10842 shall be carried out for plates conforming to
Gr. E250 C having thickness 12mm and above.
3.3 Charpy impact test shall be carried out on the plates having thickness greater than 12 mm
conforming to Grade E250 BR, E250 BO & E250 C. Test temperature and acceptance criteria
for energy absorption shall be as mentioned in Table-2 of the specification IS: 2062.
a. Chemical Analysis
b. Mechanical Tests
c. Data of heat treatment
d. Charpy V-notch impact tests
e. Y- groove crackability test
No painting/coating of any kind is permitted on the steel plates except stencil marking.
However steel plates shall be carefully protected and packed against any damage during transit
and shall be of sea worthy conditions.
Material test certificates, duly certified by Mill's Quality Assurance Department are acceptable
i.e. 3.1 certification as per EN 10204. However, if third party inspection is required specially
for plates in material requisition, all test certificates and documents shall be duly certified by
the third party. i.e. 3.2 certification as per EN 10204.