Documente Academic
Documente Profesional
Documente Cultură
ENGINE 01
FOREWORD
This wiring diagram incorporates the wiring schematics
of the Mazda3 and available optional equipment. Actual
vehicle wiring may vary slightly depending on optional SUSPENSION 02
equipment or local specifications, or both.
RESTRAINTS 08
Mazda Motor Corporation
HIROSHIMA, JAPAN
SYSTEM INDEX
00 GENERAL INFORMATION 08 RESTRAINTS
R READING WIRING DIAGRAMS 10 AIR BAG SYSTEM
VEHICLE IDENTIFICATION NUMBER (VIN) CODE ............2 AIR BAG SYSTEM (INCLUDES PRE-TENSIONER
VEHICLE IDENTIFICATION NUMBERS (VIN) .....................3 SEAT BELT INFORMATION) ......................................... 146
CONTENTS OF WIRING DIAGRAMS..................................4
GROUND POINTS................................................................5 09 BODY & ACCESSORIES
SYSTEM CIRCUIT DIAGRAM/ 12 GLASS/WINDOWS/MIRRORS
CONNECTOR DIAGRAM ...................................................6 REAR WINDOW DEFROSTER ....................................... 154
ROUTING DIAGRAM............................................................8 POWER WINDOW SYSTEM ........................................... 156
HARNESS SYMBOLS ..........................................................9 POWER OUTER MIRROR............................................... 160
WIRING COLOR CODE .......................................................9 RETRACTABLE OUTER MIRROR .................................. 160
SYMBOLS.............................................................................9 14 SECURITY AND LOCKS
SERVICE WARNING AND CAUTION FOR VEHICLES POWER DOOR LOCK SYSTEM
WITH SRS AIR BAG SYSTEM .........................................12 WITHOUT DOUBLE LOCKING SYSTEM..................... 162
SERVICE WARNING FOR VEHICLES WITH DOUBLE LOCKING SYSTEM ............................ 168
WITH DISCHARGE HEADLIGHT.....................................12 IMMOBILIZER SYSTEM .................................................. 174
ABBREVIATIONS USED IN THIS MANUAL.......................12 KEYLESS ENTRY SYSTEM ............................................ 176
P ELECTRICAL SYSTEM GENERAL PROCEDURES ...........14 15 SUNROOF ....................................................................... 178
POWER, GROUND & COMMON CONNECTOR 18 LIGHTING SYSTEMS
HEADLIGHT
E ELECTRICAL WIRING SCHEMATIC.................................18 WITHOUT AUTO LIGHT SYSTEM................................ 180
MZR-CD (RF Turbo)..................................................... 18-2 WITH AUTO LIGHT SYSTEM ....................................... 184
F FUSE BOX..........................................................................20 LICENSE PLATE LIGHT .................................................. 188
J INTERCONNECTING DIAGRAM OF PASSENGER PARKING LIGHT.............................................................. 188
JUNCTION BOX (PJB).....................................................22 TAILLIGHT ....................................................................... 188
C COMMON CONNECTOR LIST ..........................................26 FRONT FOG LIGHT ........................................................ 190
G GROUND POINT ................................................................34 TURN AND HAZARD WARNING LIGHT ......................... 192
BACK-UP LIGHT.............................................................. 194
DATA LINK CONNECTOR BRAKE LIGHT ................................................................. 196
D DATA LINK CONNECTOR .................................................38 HIGH-MOUNT BRAKE LIGHT ......................................... 196
INTERIOR LIGHT ............................................................ 198
01 ENGINE MAP LIGHT...................................................................... 198
12 COOLING SYSTEM ...........................................................42 CARGO COMPARTMENT LIGHT (5HB) ......................... 200
14 FUEL SYSTEM TRUNK COMPARTMENT LIGHT (4SD) .......................... 200
EXCEPT L3 Turbo............................................................44 ILLUMINATION LIGHT..................................................... 202
L3 Turbo ...........................................................................46 HEADLIGHT AUTO LEVELING SYSTEM ....................... 208
17 CHARGING SYSTEM.........................................................48 HEADLIGHT MANUAL LEVELING SYSTEM .................. 210
19 WIPER/WASHER SYSTEM
MZR-CD (RF Turbo)..................................................... 48-2
WINDSHIELD WIPER AND WASHER............................. 212
19 STARTING SYSTEM REAR WIPER AND WASHER ......................................... 216
ATX...................................................................................50 HEADLIGHT CLEANER................................................... 218
MTX..................................................................................52
20 ENTERTAINMENT
MZR-CD (RF Turbo)..................................................... 52-2 ACCESSORY SOCKET ................................................... 220
20 CRUISE CONTROL SYSTEM ............................................54 CIGARETTE LIGHTER .................................................... 220
40 CONTROL SYSTEM AUDIO SYSTEM
Z6,ZY:INCLUDES AUTOMATIC STANDARD TYPE AUDIO............................................. 222
TRANSAXLE CONTROL INFORMATION .....................56 Bose® TYPE AUDIO ..................................................... 226
LF,L3:INCLUDES AUTOMATIC 22 INSTRUMENTATION/DRIVER INFO.
TRANSAXLE CONTROL INFORMATION .....................74 INSTRUMENT CLUSTER ................................................ 234
L3 Turbo ...........................................................................90 HORN............................................................................... 246
MZR-CD (RF Turbo)................................................... 112-2 REAR SEAT BELT REMINDER SYSTEM........................ 248
04 BRAKES INFORMATION DISPLAY................................................. 250
13 ANTILOCK BRAKE SYSTEM..........................................114 AI ALPHABETICAL INDEX
15 DYNAMIC STABILITY CONTROL (DSC) ........................116 ALPHABETICAL INDEX .................................................. 252
05 TRANSMISSION/TRANSAXLE
17 EC-AT CONTROL SYSTEM (FS5A-EL) ..........................120
18 AUTOMATIC TRANSAXLE SHIFT MECHANISM
KEY INTERLOCK SYSTEM .............................................128
SHIFT-LOCK SYSTEM ....................................................128
06 STEERING
14 POWER STEERING
ELECTRO HYDRAULIC POWER
ASSIST STEERING (EHPAS) SYSTEM..........................130
07 HEATER, VENTILATION & AIR CONDITIONING (HVAC)
40 CONTROL SYSTEM
FULL-AUTO AIR CONDITIONER SYSTEM .....................132
MANUAL AIR CONDITIONER SYSTEM ..........................138
A/C COMPRESSOR CONTROL ......................................144
Two digits (section ID) indicated in front of each title are commonly used with the Workshop Manual.
J M0BK 10F20 0 1 2 3 4 5 6
Serial No.
No significance 0= Dummy
4
Reading Wiring Diagrams 00R
GROUND POINTS
x This shows ground points of the harness.
GROUND POINT 00G-a
1
L
2
B B/ O B G
4 B 1 2 3 16
B/ O B/ O B
5
L
17
B/ L
B/ L B
6 B
B/ L B
B
(LF) (Z6,ZJ) (MZ-CD 1.6)
[ ] AT X
B(F) 1
EXCEPT MZ-CD 1.6
B(F) B(F) 1
B(E) B(E) 5
B/O(F)
ENGINE HARNESS(E)
a B(F)
B/L(E)
MZ-CD 1.6 B/O(F) 2
C-16
B/O(F) [C-25]
LF
B(F) B(F) 2
FRONT HARNESS(F) B/L(EM) 6
B/L(EM)
B(F) 3
a B(F) B(EM)
C-23
MZ-CD 1.6
L 16
B(EM) 6
G
B(EM)
L 16
SHORT CORD
AT X
B 17
MZ-CD 1.6
Ground indication
On vehide Indication
On circuit diagrams and ground points
C-23
L(F) L(EM) 94 PCM
(SECTION 0140-3e)
MZ-CD 1.6
L(F)
0112-01
1D 1C
1A 2A
0112-01 0112-01
M
B(F) B(F)
2 3 1
0112-01
FAN CONTROL MODULE
1D P B 1A
R B
L
2A
1C
5
00R Reading Wiring Diagrams
SYSTEM CIRCUIT DIAGRAM/CONNECTOR DIAGRAM
x These diagrams show the circuits for each system, from the power supply to the ground. The power supply side
is on the upper part of the page, the ground side on the lower part. The diagrams describe circuits with the
ignition switch off.
Below is an explanation of the various points in the diagram.
System name
CONTROL SYSTEM (MZ-CD 1.6)
GY(EM) B/L(EM)
Connector code ENGINE SWITCH(IG1) 101
AO
(SECTION 0140-3a) W
GY(F)
The prefix letter indicates the system in which the G/Y(R) C-05 B/L(F)
connector is used. GY(R)
0140-322
E
F: Fuse box connectors F E
0119: Starting system connectors 225 226 227 228 229 230 231 232 233 234 235 236
High pow er-Euro 4 : B
0120: Cruise control system connectors High pow er-Euro 4 : W G W V
G
325 326
327 328 329 330 331 332
0140: Engine control system connectors 317 318 319 320 321 322 323 324
BR W B W B
0212: Wheel and tires connectors BR
W
W
R
B
R
G
V
B
L V
W
BR
W W
L
G
G
O
B
Y
W R L
0318: 4-Wheel drive connectors GY
G B L
Y
R
W
B
G
L
W
G
R
O
L
L
R
GY G
L
B
G
B
G
0415: Dynamic stability control connectors 213 214 215 216 217 218 219 220 221 222 223 224 301 302
303 304 305 306 307 308
201 202
0513: Automatic transmission connectors 203 204 205 206 207 208 209 210 211 212
6
Reading Wiring Diagrams 00R
The number indicates that the circuit Current symbol
continues to the related system
diagram. Current flows in the direction of the arrow.
White
313 307 308 332
29 231 124
B Black W/R (base color)
0140-301
(F) (F)
EM) W/B(EM) W/R(EM)
C-23
Red(stripe)
Z B/G(EM) B/Y(EM) B/Y(EM) B/Y(EM)
C
0140-323
B/L(EM)
G/R(F)
Connector symbols
LAY 151
-3a)
BR F G
L
: High pow er-Euro 4 Y
B
109 110 111 112 113 114 115 116 G Female
101 102
103 104 105 106 107 108 L
Female
R
Ground numbers x Like connectors are linked by dashed lines between the
A harness ground is represented differently than a connector symbols.
unit ground. x Connector diagrams show connectors on the harness
side. The terminal indicates the view from the harness
side.
Types of grounds Symbol
Harness (Example)
7
00R Reading Wiring Diagrams
ROUTING DIAGRAM
x The routing diagram shows where electrical components are on the system circuit diagram by call out line and
connector symbols.
F-01
MAIN FUSE BLOCK
(REFER TO 00F SECTION)
12
15
[5HB] :FRONT HARNESS
:ENGINE HARNESS
:REAR HARNESS
0918-404 :REAR NO.2,3,4 HARNESS
14
BRAKE LIGHT RH :EMISSION HARNESS
[4SD] [YELLOW]
:DOOR HARNESS
0918-404 :INTERIOR LIGHT HARNESS
BRAKE LIGHT RH :INJECTION HARNESS
[YELLOW]
8
Reading Wiring Diagrams 00R
HARNESS SYMBOLS
SYMBOLS
–––––––––––––––
Ground (1) x Connecting point to vehicle body or
other ground wire where current flows
from positive to negative terminal of
battery.
1 x Ground (1) indicates a ground point to
body through wire harness.
Ground (2) x Ground (2) indicates point where Resistance x A resistor with a constant value.
component is grounded directly to x Mainly used to protect electrical
body. components in circuits by maintaining
rated voltage.
Remarks
x Current will not flow through a circuit if
Ground (3) ground is faulty. Motor x Converts electrical energy into
mechanical energy.
9
00R Reading Wiring Diagrams
Precautions
x Do not replace with fuses exceeding
specified capacity. Cigarette lighter x Electrical coil that generates heat.
Speaker
No flow Flow
Normally open
10
Reading Wiring Diagrams 00R
Symbol Meaning Symbol Meaning
Relay (2) x Current flowing through coil produces electromagnetic force causing contactto close.
No current to coil Current to coil
Flow No flow
Normally closed
Sensor (1) x Detects characteristics such as intake Solenoid x Current flowing through coil generates
manifold vacuum and airflow amount electromagnetic force to operate
according to resistance variation. plungers.
Sensor (2) x Detects resistance variation according Diode x Known as a semiconductor rectifier,
to operation of other parts. the diode allows current flow in one
direction only.
Cathode(K) Anode(A)
Sensor (3) x A resistor whose resistance variation Flow of electric current
according to temperature variation.
x When temperature increases, K A K A K A
resistance decreases.
Sensor (4) x Detects pulse signals from rotating Light-emitting x A diode that lights when current flows.
object. diode x Unlike ordinary bulbs, the diode does
(LED) not generate heat when lit.
Cathode(K) Anode(A)
Sensor (5) x Generates potential difference when Cathode(K)
tension or pressure is applied.
Anode(A)
Flow of current
Capacitor x Component that temporarily stores Reference diode x Allows current to flow in one direction
electrical charge. (Zener diode) up to a certain voltage; allows current
to flow in the other direction once that
voltage is exceeded.
Symbol Meaning
Extent of the change in the wiring position (1) x The wiring position can be exchanged freely within the
connector.
C A
E
E C A
B B B
B B B
F D B
F D B
Extent of the change in the wiring position (2) x The wiring position can be exchanged according to the
following combinations only.
C
E A Between A and B, Between C and D, Between E and F
B B B E C A
B B B
F D B F D B
Extent of the change in the wiring position (3) x The wiring position can be exchanged according to the
following combinations only.
3 2 1 2 1 Between 1, 2, 4 and 7.
L B B
5 4 x The wiring positions may be indicated by numbers for some
L B 4
connectors.
8 7 6
B/Y B R 7
11
00R Reading Wiring Diagrams
SERVICE WARNING AND CAUTION FOR VEHICLES WITH SRS AIR BAG SYSTEM
If the SRS air bag system inspection and servicing is not done using the correct procedure, an air bag could operate (deploy)
accidentally, which may cause injury or the system to operate (deploy) improperly.
Always follow the service warnings and cautions when performing the SRS air bag system-related inspection or servicing.
12
Reading Wiring Diagrams 00R
MIX MIXTURE TP THROTTLE POSITION SENSOR
MPX MULTIPLEX TR TRANSMISSION(TRANSAXLE) RANGE
MS MIDDLE SPEED TWS TOTAL WIRING SYSTEM
MT MANUAL TRANSMISSION V VOLT
MTX MANUAL TRANSAXLE VAF VOLUME AIR FLOW SENSOR
N NEUTRAL VENT VENTILATION
NC NORMALLY CLOSED VARIABLE INERTIA CHARGING
VICS
NO NORMALLY OPEN SYSTEM
O2S OXYGEN SENSOR VOL VOLUME
OBD ON-BOARD DIAGNOSTIC VR VOLTAGE REGULATOR
O/D OVER DRIVE VARIABLE RESONANCE INDUCTION
VRIS
OFF SWITCH OFF SYSTEM
ON SWITCH ON VSS VEHICLE SPEED SENSOR
OSC OSCILLATOR VARIABLE TUMBLE CONTROL
VTCS
P POWER SYSTEM
P/S POWER STEERING W WATT(S)
PCM POWERTRAIN CONTROL MODULE WOT WIDE OPEN THROTTLE
PJB PASSENGER JUNCTION BOX
PNP PARK/NEUTRAL POSITION
PRC PRESSURE REGULATOR CONTROL
PRG PURGE SOLENOID VALVE
PSP POWER STEERING PRESSURE
POSITIVE TEMPERATURE
PTC
COEFFICIENT HEATER
PWM PULSE WIDTH MODULATION
QSS QUICK-START SYSTEM
R REAR
REC RECIRCULATION
RES REAR ENTERTAINMENT SYSTEM
RF RIGHT FRONT
RH RIGHT HAND
RPM REVOLUTIONS PER MINUTE
RR RIGHT REAR
SAS SOPHISTICATED AIR BAG SENSOR
SEQUENTIAL MULTIPOINT FUEL
SFI
INJECTION
SOL SOLENOID
SPV SPILL VALVE
ST START
SW SWITCH
TC TURBOCHARGER
TCC TORQUE CONVERTER CLUTCH
TRANSMISSION(TRANSAXLE)
TCM
CONTROL MODULE
TCS TRACTION CONTROL SYSTEM
TEMP TEMPERATURE
TFT TRANSAXLE FLUID TEMPERATURE
TRIPLE INDUCTION CONTROL
TICS
SYSTEM
TNS TAIL NUMBER SIDE LIGHTS
13
00P Electrical System General Procedures
ELECTRICAL PARTS B6U000000006W03
Battery Cable
• Before disconnecting connectors or removing
electrical parts, disconnect the negative battery cable. NEGATIVE BATTERY CABLE
WGIWXX0007E
Wiring Harness
• To remove the wiring harness from the clip in the
engine room, pry up the hook of the clip using a
flathead screwdriver.
WGIWXX0039E
Caution
• Do not remove the Harness protective tape.
Otherwise, the wires could rub against the body,
which could result in water penetration and
electrical shorting.
CONNECTORS NO GOOD
WGIWXX0040E
Data Link Connector
• Insert the probe into the terminal when connecting a
jumper wire to the data link connector.
GOOD NO GOOD
Caution
• Inserting a jumper wire probe into the data link
connector terminal may damage the terminal.
X3U000WAY
Disconnecting Connectors
• When disconnecting connector, grasp the connectors,
not the wires.
NO GOOD
WGIWXX0041E
14
Electrical System General Procedures 00P
• Connectors can be disconnected by pressing or
pulling the lock lever as shown.
WGIWXX0042E
Locking Connector
• When locking connectors, listen for a click indicating
they are securely locked.
X3U000WB1
Inspection
• When a tester is used to inspect for continuity or
measuring voltage, insert the tester probe from the
wiring harness side.
NO GOOD
WGIWXX0044E
Caution
• To prevent damage to the terminal, wrap a thin
wire around the tester probe before inserting
into terminal.
NO GOOD
WGIWXX0045E
15
00P Electrical System General Procedures
Terminals
Inspection
• Pull lightly on individual wires to verify that they are
secured in the terminal.
X3U000WB4
Replacement
• Use the appropriate tools to remove a terminal as
shown. When installing a terminal, be sure to insert it
until it locks securely.
• Insert a thin piece of metal from the terminal side of
the connector and with the terminal locking tab
pressed down, pull the terminal out from the
connector.
X3U000WB5
X3U000WB6
Fuse
Replacement
• When replacing a fuse, be sure to replace it with one
of the same capacity. If a fuse fails again, the circuit
probably has a short and the wiring should be
inspected.
• Be sure the negative battery terminal is disconnected
before replacing a main fuse.
YMU000WA1
16
Electrical System General Procedures 00P
• When replacing a pullout fuse, use the fuse puller.
YMU000WAK
Caution
• Do not connect a jumper wire from the power
source line to a body ground. This may cause
burning or other damage to wiring harnesses or
electronic components.
X3U000WBB
Voltmeter
• The DC voltmeter is used to measure circuit voltage. A
voltmeter with a range of 15 V or more is used by
connecting the positive (+) probe (red lead wire) to the
point where voltage will be measured and the negative
(-) probe (black lead wire) to a body ground.
X3U000WBC
Ohmmeter
• The ohmmeter is used to measure the resistance
between two points in a circuit and to inspect for
continuity and short circuits. POWER SOURCE LINE
Caution NO GOOD
• Do not connect the ohmmeter to any circuit
where voltage is applied. This will damage the
ohmmeter. GROUND LINE
OHMMETER
YMU000WAL
17
18
18-1
Mazda3 Wiring Diagram (5672-1*-06E)
18-2 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
19 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
Revised 9/2006 (Ref.No.L121/06)
20
20-1
Mazda3 Wiring Diagram (5672-1*-06E)
20-2 Added 6/2007 (Ref. No. L095/07)
22
23
24
25
26
Mazda3 Wiring Diagram (5672-1*-06E)
27 Revised 6/2007 (Ref. No. L095/07)
28
29
30
31
32
Mazda3 Wiring Diagram (5672-1*-06E)
33 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
34 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
35 Revised 6/2007 (Ref. No. L095/07)
36
37
38
39
Mazda3 Wiring Diagram (5672-1*-06E)
40 Revised 6/2007 (Ref. No. L095/07)
41
Mazda3 Wiring Diagram (5672-1*-06E)
42 Revised 6/2007 (Ref. No. L095/07)
43
44
45
46
47
48
48-1
Mazda3 Wiring Diagram (5672-1*-06E)
48-2 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
49 Revised 6/2007 (Ref. No. L095/07)
50
51
52
52-1
Mazda3 Wiring Diagram (5672-1*-06E)
52-2 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
53 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
54 Revised 6/2007 (Ref. No. L095/07)
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
112-1
Mazda3 Wiring Diagram (5672-1*-06E)
112-2 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-3 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-4 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-5 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-6 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-7 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-8 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-9 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-10 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-11 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-12 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-13 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-14 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-15 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
112-16 Added 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
113 Revised 6/2007 (Ref. No. L095/07)
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
Mazda3 Wiring Diagram (5672-1*-06E)
136 Revised 6/2007 (Ref. No. L095/07)
137
138
139
140
141
Mazda3 Wiring Diagram (5672-1*-06E)
142 Revised 6/2007 (Ref. No. L095/07)
143
Mazda3 Wiring Diagram (5672-1*-06E)
144 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
145 Revised 6/2007 (Ref. No. L095/07)
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
161
162
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
181
182
183
184
185
186
187
188
189
190
191
192
193
Mazda3 Wiring Diagram (5672-1*-06E)
194 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
195 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
196 Revised 6/2007 (Ref. No. L095/07)
197
198
199
200
201
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
217
218
219
Mazda3 Wiring Diagram (5672-1*-06E)
Revised 9/2006 (Ref.No.L121/06)
220
Mazda3 Wiring Diagram (5672-1*-06E)
Revised 9/2006 (Ref.No.L121/06)
221
Mazda3 Wiring Diagram (5672-1*-06E)
Revised 9/2006 (Ref.No.L121/06)
222
Mazda3 Wiring Diagram (5672-1*-06E)
Revised 9/2006 (Ref.No.L121/06)
223
224
225
Mazda3 Wiring Diagram (5672-1*-06E)
Revised 9/2006 (Ref.No.L121/06)
226
Mazda3 Wiring Diagram (5672-1*-06E)
Revised 9/2006 (Ref.No.L121/06)
227
228
229
230
231
232
233
234
235
236
237
238
239
Mazda3 Wiring Diagram (5672-1*-06E)
240 Revised 6/2007 (Ref. No. L095/07)
Mazda3 Wiring Diagram (5672-1*-06E)
241 Revised 6/2007 (Ref. No. L095/07)
242
243
244
245
Mazda3 Wiring Diagram (5672-1*-06E)
246 Revised 6/2007 (Ref. No. L095/07)
247
248
249
250
251
Mazda3 Wiring Diagram (5672-1*-06E)
ALPHABETICAL INDEX
A FAN SWITCH.................................................................. 138
ABBREVIATIONS............................................................. 12 FILAMENT ...................................................................... 154
ABS HU/CM ................................................................... 114 FRONT DOOR LATCH SWITCH ............................. 162,168
ABS WHEEL-SPEED SENSOR.............................. 114,116 FRONT DOOR LOCK ACTUATOR.......................... 162,168
ACCELERATOR PEDAL FRONT DOOR SPEAKER....................................... 224,230
POSITION SENSOR.............................. 72,84,112, 112-8 FRONT FOG LIGHT ....................................................... 190
ACCESSORY SOCKET ................................................. 220 FRONT FOG LIGHT SWITCH........................................ 190
AIR INTAKE ACTUATOR......................................... 134,140 FRONT HEATED OXYGEN SENSOR......................... 62,78
AIR MIX ACTUATOR ...................................................... 134 FRONT SIDE TURN LIGHT ........................................... 192
AIRFLOW MODE ACTUATOR ....................................... 134 FRONT TURN LIGHT..................................................... 192
AMBIENT TEMPERATURE SENSOR ........................... 250 FUEL TEMPERATURE SENSOR.............................. 112-12
AUDIO AMPLIFIER ........................................................ 228 FRONT TWEETER.................................................. 224,230
AUDIO CONTROL SWITCH ................................... 222,226 FUEL GAUGE SENDER UNIT ....................................... 236
AUDIO UNIT............................................................ 222,226 FUEL INJECTOR...................................... 58,76,108, 112-6
AUTO LEVELING CONTROL MODULE ........................ 208 FUEL PRESSURE SENSOR ............................. 96, 112-16
AUTO LEVELING SENSOR........................................... 208 FUEL PUMP RESISTOR.................................................. 46
AUXILIARY JACK.................................................... 222,226 FUEL PUMP UNIT....................................................... 44,46
B FUSE BOX........................................................................ 20
BACK-UP LIGHT............................................................ 194 G
BACK-UP LIGHT SWITCH............................................. 194 GENERATOR ......................................................... 48, 48-2
BAROMETRIC PRESSURE SENSOR ............................ 62 GLOVE COMPARTMENT LIGHT ................................... 202
BLOWER MOTOR................................................... 132,138 GLOW PLUG ............................................................... 112-2
BOOST AIR TEMPERATURE SENSOR..................... 78,96
GROUND POINT.............................................................. 34
BOOST SENSOR...................................................... 112-16
BRAKE FLUID LEVEL SENSOR ................................... 234 H
BRAKE LIGHT................................................................ 196 HAZARD WARNING SWITCH ....................................... 192
BRAKE SWITCH ....................................................... 54,196 HEADLIGHT CLEANER MOTOR ................................... 218
HEADLIGHT HIGH .................................................. 182,186
C
HEADLIGHT LEVELING ACTUATOR...................... 208,210
CABIN TEMPERATURE SENSOR ................................ 132
HEADLIGHT LEVELING SWITCH ................................. 210
CAMSHAFT POSITION SENSOR ......... 60,80,100, 112-14
HEADLIGHT LOW .................................................. 182,186
CARGO COMPARTMENT LIGHT .................................. 200
HIGH-MOUNT BRAKE LIGHT........................................ 196
CARGO COMPARTMENT LIGHT SWITCH................... 200
HIGH PRESSURE FUEL PUMP .................................... 106
CIGARETTE LIGHTER .................................................. 220
CLIMATE CONTROL UNIT ..................................... 132,138 HO2S........................................................................... 112-8
CLUTCH PEDAL POSITION SWITCH................. 66,84,112 HO2S(FRONT) ................................................................. 98
CLUTCH SWITCH..................................................... 112-16 HO2S(REAR) ................................................................... 96
COIL ANTENNA............................................................. 174 HORN ............................................................................. 246
COMBINED SENSOR.................................................... 118 HORN SWITCH .............................................................. 246
COMMON CONNECTOR LIST ........................................ 26 I
CONDENSER ............................................... 58,76,102,196 IDLE AIR CONTROL VALVE ............................................ 60
CRANKSHAFT POSITION SENSOR..... 60,80,100, 112-14 IGNITION COIL .................................................... 58,76,102
CRASH ZONE SENSOR................................................ 146 ILLUMINATION
CRUISE CONTROL SWITCH .......................................... 54 ASHTRAY .................................................................... 202
CURRENT SENSOR........................................................ 72 AUDIO CONTROL SWITCH ........................................ 206
D CIGARETTE LIGHTER................................................ 204
DATA LINK CONNECTOR-2............................................. 38 CRUISE CONTROL SWITCH...................................... 206
DOOR KEY CYLINDER SWITCH .................................. 168 DSC OFF SWITCH ...................................................... 206
DOOR LOCK-LINK SWITCH .................................. 162,168 HAZARD WARNING SWITCH..................................... 204
DRIVER-SIDE AIR BAG MODULE ................................ 148 HEADLIGHT LEVELING SWITCH .............................. 204
IGNITION KEY............................................................. 202
DRIVER-SIDE CURTAIN AIR BAG MODULE................ 152
SELECTOR.................................................................. 204
DRIVER-SIDE PRE-TENSIONER SEAT BELT .............. 152
DRIVER-SIDE SIDE AIR BAG SENSOR ....................... 150 INFORMATION DISPLAY ............................................... 250
DSC HU/CM ................................................................... 116 INPUT/TURBINE SPEED SENSOR..................... 70,88,122
DSC OFF SWITCH ........................................................ 118 INSTRUMENT CLUSTER .............................................. 234
INTAKE AIR TEMPERATURE SENSOR NO.2 ............ 112-4
E INTAKE SHUTTER VALVE ........................................ 112-12
EGR VALVE............................................ 64,80,104, 112-12 INTERCONNECTING DIAGRAM OF
EHPAS CONTROL MODULE......................................... 130 PASSENGER JUNCTION BOX (PJB) ........................... 22
ELECTRICAL WIRING SCHEMATIC ..................... 18, 18-2 INTERIOR LIGHT ........................................................... 198
ENGINE COOLANT INTERMEDIATE SENSOR ............................................. 122
TEMPERATURE SENSOR.................... 62,78,106, 112-12
EVAPORATOR TEMPERATURE SENSOR ............ 134,140 K
EXHAUST GAS PRESSURE CORRECTION KEY INTERLOCK SOLENOID ....................................... 128
TEMPERATURE SENSOR..................................... 112-16 KEYLESS RECEIVER .................................................... 176
EXHAUST GAS PRESSURE SENSOR .................... 112-10 KNOCK SENSOR................................................. 64,80,100
EXHAUST GAS TEMPERATURE SENSOR ............. 112-10 L
F LIFTGATE LOCK ACTUATOR ................................. 166,172
FAN CONTROL MODULE................................................ 42 LIGHT SWITCH ....................................................... 180,184