Documente Academic
Documente Profesional
Documente Cultură
Sound Bar
MODEL
LAS260B
www.lg.com
*MFL69466682* Copyright © 2017 LG Electronics. All Rights Reserved
Getting Started 3
Getting Started
Slots and openings in the cabinet are provided
CAUTION: TO REDUCE THE RISK OF ELECTRIC
for ventilation and to ensure reliable operation of
SHOCK DO NOT REMOVE COVER (OR BACK)
the product and to protect it from over heating.
NO USER-SERVICEABLE PARTS INSIDE REFER
The openings shall be never be blocked by placing
SERVICING TO QUALIFIED SERVICE PERSONNEL.
the product on a bed, sofa, rug or other similar
This lightning flash with arrowhead surface. This product shall not be placed in a built-
symbol within an equilateral in installation such as a bookcase or rack unless
triangle is intended to alert the proper ventilation is provided or the manufacturer’s
user to the presence of uninsulated instruction has been adhered to.
dangerous voltage within the
product’s enclosure that may be of CAUTION concerning the Power Cord
sufficient magnitude to constitute
a risk of electric shock to persons. The Power Plug is the disconnecting device. In
case of an emergency, the Power Plug must
The exclamation point within an remain readily accessible. Check the specification
equilateral triangle is intended page of this owner’s manual to be certain of the
to alert the user to the presence current requirements. Do not overload wall outlets.
of important operating and Overloaded wall outlets, loose or damaged wall
maintenance (servicing) outlets, extension cords, frayed power cords, or
instructions in the literature damaged or cracked wire insulation are dangerous.
accompanying the product. Any of these conditions could result in electric
WARNING: TO PREVENT FIRE OR ELECTRIC SHOCK shock or fire. Periodically examine the cord of your
HAZARD, DO NOT EXPOSE THIS PRODUCT TO RAIN device, and if its appearance indicates damage
OR MOISTURE. or deterioration, unplug it, discontinue use of the
CAUTION: The apparatus shall not be exposed to device, and have the cord replaced with an exact
water (dripping or splashing) and no objects filled replacement part by an authorized service center.
with liquids, such as vases, shall be placed on the Protect the power cord from physical or mechanical
apparatus. abuse, such as being twisted, kinked, pinched, closed
in a door, or walked upon. Pay particular attention to
WARNING: Do not install this equipment in a plugs, wall outlets, and the point where the cord exits
confined space such as a book case or similar unit. the device.
4 Getting Started
Table of Contents
1
1 Getting Started 3 Operating
3 Safety Information 12 Operations
6 Unique features 12 – DRC (Dynamic range control)
6 – Auto power down 12 – Turn off the sound temporarily
2
6 – Portable In 12 – Using your TV remote control
6 Introduction 13 – AUTO POWER On/Off
6 – Symbols used in this manual 13 – Auto function change
6 Accessories 14 Using BLUETOOTH® technology
7 Remote control 14 – Listening to music stored on the
3
8 Front panel BLUETOOTH devices
8 Rear panel 15 Sound adjustment
9 Installing the sound bar
4 Troubleshooting
2 Connecting 4
16 Troubleshooting
10 Connecting to your TV 17 NOTES to use wireless
10 – Using an OPTICAL cable
11 Optional equipment connection
5 Appendix
11 – OPTICAL IN connection 5
11 – PORT. IN connection 18 Trademarks and licenses
19 Specifications
20 Maintenance
20 – Handling the unit
6 Getting Started
energy consumption.
Portable In
Remote control (1) Batteries (2)
Listen to music from your portable device.
(MP3 player, Notebook, Smart phone, etc..)
Introduction
Symbols used in this manual
,,Note
Indicates special notes and operating features.
>>Caution
Indicates cautions for preventing possible damages
from abuse.
Getting Started 7
Remote control • • • • • • • • • • • • • • a• • • • • • • • • • • • • •
1 (Power): Switches the unit ON or OFF.
F : Changes input sources.
STANDARD : Selects STANDARD sound effect. 1
VOICE : Selects VOICE sound effect.
Getting Started
CINEMA : Selects CINEMA sound effect.
(Mute) : Mutes the sound.
VOL o/p : Adjusts speaker volume.
• • • • • • • • • • • • • • b• • • • • • • • • • • • • •
DRC ON/OFF : Turns on or off DRC function.
(Refer to the page 12.)
AUTO POWER ON/OFF: Turns on or off AUTO
POWER function. (Refer to the page 13.)
? : This button is not used.
Replacement of battery
Front panel
1 A B C
Getting Started
G D E F G
G Speakers
Rear panel
A
B
Getting Started
device you want. (Refer to pages 10 - 11.)
>>Caution
For best performance of wireless connection
such as Bluetooth, do not install the unit on
Metallic furniture because wireless connection
communicates through a module positioned on
the bottom of the unit.
10 Connecting
OPTICAL IN connection
Connect an optical output jack of external devices to
the OPTICAL IN jack.
2
Connecting
MP3 player, etc...
To the digital
optical output jack of
external device
,,Note
yy Supported TV brands
LG Panasonic Philips Samsung
Sharp Sony Toshiba Vizio
Operating
there is no signal for a certain period of time music on the Bluetooth device.
from the external device.
yy If you turned off the unit directly, it cannot
,,Note
be turned on automatically by AUTO POWER To change to optical function, it needs 5 seconds
function. However the unit can be turned on of no signal.
by AUTO POWER function when optical signal
comes in after 5 seconds of no signal.
yy Depending on the connected device, this
function may not operate.
yy If you disconnect Bluetooth connection by
this unit, some Bluetooth devices try to
connect to the unit continually. Therefore it is
recommended to disconnect the connection
before turn off the unit.
yy When you turn on this unit for the first time,
Auto Power function is turned on status.
yy To use this function, the main unit must be
registered in paired devices list of Bluetooth
device.
14 Operating
Operating
connection interfered by the other electronic
wave. yy In some of sound effect mode, some speakers,
yy You may not control the Bluetooth device there’s no sound or low sound. It depends on
with this unit. the mode of sound and the source of audio, it
is not defective.
yy Pairing is limited one Bluetooth device per
one unit and multi-pairing is not supported. yy You may need to reset the sound effect
mode, after switching the input, sometimes
yy Depending on the type of the device, you may
not be able to use the Bluetooth function. even after the sound file changed.
Troubleshooting
yy Turn off the power of this unit and the connected external device
(TV, Woofer, DVD-player, Amplifier, etc.) and turn it on again.
The unit does not yy Disconnect the power cord of this unit and the connected external device
work properly. (TV, Woofer, DVD-player, Amplifier, etc.) and then try connecting again.
yy Previous setting may not be saved when device power is shut off.
The AUTO POWER yy Check connection of the external device such as TV, DVD/Blu-Ray player or
function does not Bluetooth device.
work. yy Depending on the connected device, this function may not operate.
Troubleshooting 17
Check the details below and adjust the unit according to them.
yy Switch [ON] state of DRC function to [OFF] by using remote controller.
yy With the sound bar connected with TV, change the AUDIO DIGITAL OUT setting on
When you feel the TV Setup Menu from [PCM] to [AUTO] or [BITSTREAM].
output sound of the
unit is low. yy With the sound bar connected with Player, change the AUDIO DIGITAL OUT
setting on Player Setup Menu from [PCM] to [PRIMARY PASS-THROUGH] or
[BITSTREAM].
yy Change Audio DRC setting on Player setup menu to [OFF] state.
Troubleshooting
This device may have yy Wireless may not operate normally in weak signal area.
wireless interference. yy Do not install the device on metal furniture for optimum performance.
yy When any part of your body contact the transceiver of the Bluetooth device or
sound bar.
yy When there is an obstacle or wall or the device is installed in a secluded spot.
Bluetooth device may yy When there is a device(a wireless LAN, a medical equipment or a microwave) using
malfunction or make same frequency, make the distance between the products as far away as possible
noise in the following each other.
cases. yy When to connecting the device to the Bluetooth device, make the distance
between the products as close as possible each other.
yy When the device gets too far from the Bluetooth device, the connection is
disconnected and also malfunction may occur.
18 Appendix
Specifications
General
Power requirements Refer to main label.
Refer to main label.
Power consumption Networked standby : 0.5 W
(If all network ports are activated.)
Dimensions (W x H x D) Approx. 950 mm x 71 mm x 47 mm
Net Weight Approx. 2.47 kg
Operating temperature 5 °C to 35 °C
Operating humidity 5 % to 90 %
Inputs
Digital audio in (OPTICAL IN) 3 V (p-p), Optical jack x 1
Portable in (PORT. IN) 0.32 Vrms (3.5 mm stereo jack) x 1
Available Digital Input Audio
32 kHz, 44.1 kHz, 48 kHz, 88.2 kHz, 96 kHz
Sampling Frequency
Available Digital Input Audio format Dolby Digital, DTS Digital Surround, PCM
Appendix
Front 50 W +50 W RMS (4 Ω at 1 kHz, 10% THD)
Maintenance