Documente Academic
Documente Profesional
Documente Cultură
Safety data sheet according to Regulation (EC) No 1272/2008, Annex II
1. Identification
2. Hazards Identification
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
1
SDS_N22138_2015-09_EN
BAUER COMPRESSOR OIL N22138
Signs and Symptoms Oil acne/folliculitis signs and symptoms may include
formation of black pustules and spots on the skin of
exposed areas. Ingestion may result in nausea,
vomiting and/or diarrhoea.
3. Composition/information on ingredients
Additional Information Highly refined mineral oils and additives. The highly
refined mineral oil contains <3% (w/w) DMSO-
extract, according to IP346
5. Firefighting measures
Special hazards arising from the In case of fire the following can develop:
substance or mixture Oxides of carbon, Oxides of nitrogen, Toxic pyrolysis products,
Hot product gives off combustible vapours
Advice for firefighters In case of fire and/or explosion do not breathe fumes. Protective
respirator with independent air supply. According to size of fire:
Full protection, if necessary. Cool container at risk with water.
Dispose of contaminated extinction water according to official
regulations.
Personal precautions, protective Ensure sufficient supply of air. Avoid contact with eyes or skin.
equipment and emergency procedures If applicable, caution – risk of slipping.
Methods and material for Soak up with absorbent material (e.g. universal binding agent,
containment and cleaning up sand, diatomaceous earth) and dispose of according to Section
13.
Reference to other sections For personal protective equipment see Section 8 and for
disposal instructions see Section 13.
General recommendations Ensure good ventilation. Avoid formation of oil mist. Do not
heat to temperatures close to flash point. Do not carry cleaning
cloths soaked in product in trouser pockets. Eating, drinking,
smoking, as well as food-storage, is prohibited in work-room.
Observe directions on label and instructions for use.
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
3
SDS_N22138_2015-09_EN
BAUER COMPRESSOR OIL N22138
Notes on general hygiene measures at General hygiene measures for the handling of chemicals are
the workplace applicable. Wash hands before breaks and at end of work. Keep
away from food, drink and animal feedingstuffs. Remove
contaminated clothing and protective equipment before
entering areas in which food is consumed.
Conditions for safe storage, including Store product closed and only in original packing. Not to be
any incompatibilities stored in gangways or stair wells. Do not store with oxidizing
agents. Solvent resistant floor. Store in a well ventilated place.
Protect from direct sunlight and warming.
Appropriate engineering controls Ensure good ventilation. This can be achieved by local suction or
general air extraction. If this is insufficient to maintain the
concentration under the WEL or AGW values, suitable breathing
protection should be worn. Applies only if maximum permissible
exposure values are listed here.
Individual protection measures, such General hygiene measures for the handling of chemicals are
as personal protective equipment applicable. Wash hands before breaks and at end of work. Keep
away from food, drink and animal feedingstuffs. Remove
contaminated clothing and protective equipment before
entering areas in which food is consumed.
Eye/face protection Tight fitting protective goggles (EN 166) with side protection,
with danger of projections.
Skin protection – other Protective working garments (e. g. safety shoes EN ISO 20345,
long-sleeved protective working garments).
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
4
SDS_N22138_2015-09_EN
BAUER COMPRESSOR OIL N22138
Additional information on hand In the case of mixtures, the selection has been made according
protection – No tests have been to the knowledge available and the information about the
performed contents. Selection of materials derived from glove
manufacturer`s indications. Final selection of glove material must
be made taking the breakthrough times, permeation rates and
degradation into account. Selection of a suitable glove depends
not only on the material but also on other quality characteristics
and varies from manufacturer to manufacturer. In the case of
mixtures, the resistance of glove materials can not be predicted
and must therefore be tested before use. The exact
breakthrough time of the glove material can be requested from
the protective glove manufacturer and must be observed.
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
5
SDS_N22138_2015-09_EN
BAUER COMPRESSOR OIL N22138
Stability Stable
Hazardous Decomposition Products Hazardous decomposition products are not expected to form
during normal storage.
Basis for Assessment Information given is based on data on the components and the
toxicology of similar products. Unless indicated otherwise, the
data presented is representative of the product as a whole,
rather than for individual component(s).
Acute toxicity, by oral route Expected to be of low toxicity: LD50 > 5000mg/kg, Rat
Acute toxicity, by dermal route Expected to be of low toxicity: LD50 > 5000mg/kg, Rabbit
Acute toxicity, by inhalation Not considered tob e an inhalation hazard under normal
conditions of use.
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
6
SDS_N22138_2015-09_EN
BAUER COMPRESSOR OIL N22138
Additional Information Used oils may contain harmful impurities that have accumulated
during use. The concentration of such impurities will depend on
use and they may present risks to health and the environment
on disposal. ALL used oil should be handled with caution and
skin contact avoided as far as possible.
Generell informations Ecotoxicological data have not been determined specifically for
this product. Information given is based on a knowledge of the
components and the ecotoxicology of similar products. Unless
indicated otherwise, the data presented is representative of the
product as a whole, rather than for individual component(s).
Acute Toxicity Poorly soluble mixture. May cause physical fouling of aquatic
organisms. Expected to be practically non toxic: LL/EL/IL50 >
100 mg/l (to aquatic organisms) LL/EL50 expressed as the
nominal amount of product required to prepare aqueous test
extract. Mineral oil is not expected to cause any chronic effects
to aquatic organisms at concentrations less than 1mg/l.
Other Adverse Effects Product is a mixture of non-volatile components, which are not
expected to be released to air in any significant quantities. Not
expected to have ozone depletion potential, photochemical
ozone creation potential or global warming potential.
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
7
SDS_N22138_2015-09_EN
BAUER COMPRESSOR OIL N22138
US Department of Transportation The material is not subject to DOT regulations under 49 CFR
Classification (49CFR) Parts 171-180
IATA (Country variations may apply) This material is either not classified as dangerous under IATA
regulations or needs to follow country specific requirements.
SDS Revisions A vertical bar in the left margin indicates an amendment from
the previous version.
SDS Regulation The content and format of this MSDS is in accordance with the
OSHA Hazard Communication Standard, 29 CFR 1910.1200.
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
8
SDS_N22138_2015-09_EN
BAUER COMPRESSOR OIL N22138
BAUER KOMPRESSOREN GmbH
Stäblistr. 8 | 81477 München | Deutschland
Tel. +49(0)89/78049-0 | Fax +49(0)89/78049-167 | info@bauer-kompressoren.de | www.bauer-kompressoren.de
9
SDS_N22138_2015-09_EN