Documente Academic
Documente Profesional
Documente Cultură
a. Distance between the plate and inversely proportional to the plate area
b. Plate area and is not affected by the distance between the plate.
c. *Plate area and inversely proportional to the distance between the plate
d. None of these
Transfer of electrical energy from one conductor to another without the aid of electrical
connection is
*a) Induction b) Air gap transfer
c) Not possible d) Possible but will cause excessive arcing thus not practical
One micron is
a) 10-3 meter *b) 10-6 meter
c) 10-9 meter d) None of these
In a parallel circuit
*a) Total resistance is less than smallest resistor
b) Total resistance decreases when one of the resistance is removed
c) Total voltage drop is same as total resistance
d) All are correct
If there are ‘n’ numbers of calls, each having a voltage of ‘E’ and resistance ‘R’, then
voltmeter connected across the electrolyte will indicate
*a) nE b) (n-1)E
c) n(n - ½)E d) None of these
A 12V bulb is connected in series and draws 3 amperes current from a 12V battery. Its
resistance and power will be
a) 36 ohms, 4 W *b) 4 ohms, 36 W
c) 1 ohm, 12 W d) None of these
Y= ∑ (5, 15, 23, 29, 37, 47, 55, 61) + X (7, 13, 21, 31, 39, 45, 53, 63)
a) Y=EF b) Y= AB c) Y=CD + EF *d) Y=BD
If active low output is required for checking odd parity we will use
a) AND gate b) OR gate c) XOR gate *d) XNOR gate
If a demultiplexer is converted into decoder, to get output high on required output lines, we
will tie date line to
a) OV b) Ground c) Either a) or b) *d) +VCC
Which of the following relation is correct?
*a) Vo=AdVd[1+(1/CMRR) Vc/Vd] b) Vo=AcVc[1+(1/CMRR) Vd/Vc]
c) Vo=AdVd[1+CMRR . Vc/Vd] a) Vo=AdVd[1+(1/CMRR) Vd/Vc]
In a 3 phase system, the phase winding is spaced symmetrically so that the voltage induced
is
a) 90o apart *b) 120o apart c) 60o apart d) 180o apart
To avoid armature reaction of small DC generator (1000 watt or less) type. The method
used is
a) Interpole Method b) Brush setting method *c) both (a) & (b) d) None of
these
If a D flip-flop is to switch from 0 to 1, then input is to be kept high for at least time T
where
*a) T= t setup + t hold b) T= t setup + t hold + t
propagation delay
c) T= t setup + t hold - t propagation delay d) T= clock period
The relationship between back emf and applied voltage in case of a dc motor is given by
a) Eb = V + Ia Ra *b) Eb = V – Ia Ra c) Eb = V d) None of
these
An engine driven 50 Hz alternator has a speed of 750 rpm. How many poles it has?
a) 6 poles b) 4 poles c) 2 poles *d) 8 poles
The device used to measure very high insulation resistance of electric cable is
a) High resistance voltmeter *b) Megger / Insulation resistance tester
c) Iron vane meter d) Ammeter of high range
If six cells are connected in series of each E volts, the total voltage of the battery will be
*a) 6E b) 3E c) 4E d) 12E
Special test equipment comprising a meter and two cables each of specific length, is
required for checking the resistance of bonding. A meter widely used , consists of an ohm-
meter operating on
*a) Principle of current ratio b) Principle of voltage ratio c) None of these
If six cells are connected in series of each E volts, the total voltage of the battery will be
*a) 6E b) 3E c) 4E d) 12E
Transfer of electrical energy from one conductor to another without the add of electrical
connections
*a) is called induction b) is called air gap transfer
c) Will cause excessive arching and heat, and as a result is impractical
What is the value of a resistance if given colour codes as brown, black, brown, black and
brown.
a) 1010 ohms b) 1000 ohms *c) 101 ohms d) 10.1 K ohms
What is the value of a capacitor if given colour codes are orange, orange, blue and white.
a) 33nF *b) 33μF c) 33pF d) 3300μF
Peak Inverse Voltage (PIV) across the non-conducting diode (Reverse biased) in center tape
full wave rectifier is equal to
a) Vm b) 2/Vm *c) Vm/2 d) 2Vm
A gusset is
a. A bracing between longerons
b. *A type of connecting bracket
c. Used for fail safe construction
d. Like a butt plate
The phase difference between voltage and current in a purely resistive circuit is given by
a. *00
b. 900
c. 450
d. 1350
Two resistances of 15, 12 ohms each are connected in parallel across a supply, giving 27
ampere, then current through 15 ohm will be
a. 27 amp
b. *12 amp
c. 15 amp
d. 1 amp
To get a basic D.C. generator from A.C. generator which of the following arrangement is
made?
a. *By replacing the slip rings of the A.C. generator with commutator
b. By the addition of extra slip rings
c. By connecting a rectifier
d. None of the above
When the conduction-band orbit of one atom may intersect the hole orbit of another atom
merging of a free electron and a hole takes place. This merging of electron and hole is
known as
(a) Current flow (b) Minority current flow
(c) Combination *(d) Recombination
The barrier potential at 25˚C in respect of silicon and germanium is
*(a) Si-0.7V and Ge-0.3V (b) Si-0.3V and Ge-0.7V
(c) Si-0.7V and Ge-0.7V (d) Si-0.3V and Ge-0.3V
Unit of m.m.f. is
(a) weber *b) gilbert (c) maxwell (d) henry
If there are ‘N’ number of cells, each having voltage E and internal resistance ‘r’ are
connected in series, then the resulting e.m.f of the circuit is given by
*(a) NE volt (b) E/N volt (c) E volt (d) NEr volt
The phase difference between voltage and current in a purely resistive circuit is given by
* (a) 0° (b) 90° (c) 45° (d) 135°
If ‘Im’ is the maximum current for sine AC then its R.M.S value is given by
* (a) 0.707 Im (b) Im
(c) 0.5 Im (d) 1.414 Im
The relationship between voltage and current in a purely inductive circuit is given by
(a) Voltage leads the current by 90°
(b) Current lags the voltage by 90°
* (c) both (a) & (b)
(d) None of the above
When two sphere are of same mass, one is positive charge and the other is negative charge
then new mass will remain
(a) change *(b) unchanged (c) sum of both mass
If the conductor is of 4 and if it is stretched to twice its length then its resistance is
(a) 1 (b) 2 *(c) 16 (d) 32
A & B are big and small battery having same emf internal resistance of battery A is
*(a) less than B (b) greater than B (c) equal to B (d) unaffected
Two wires each one meter long are kept at a distance of 0.02mt. apart. If 1 amp current is
flowing through each wire, then force acting in the wire will be
(a) *attractive if the direction of the current flowing through wires is same.
(b) attractive if the direction of the current will be opposite.
(c) repulsive if direction of the current will be reverse.
(d) Both (b) and (c) are correct.
The identical insulated wire coils are hung from air so that they are facing each other and
supplied with same direction a.c.
*(a) both are attracted to each other (b) both are repelled
(c) clockwise rotation (d) anticlockwise rotation
Rheostat varies
*(a) amount of current (b) amount of voltage
(c) both (a) & (b) (d) none
Potentiometer varies
(a) amount of current *(b) amount of voltage
(c) both (a) & (b) (d) none
Construction of separator of a lead acid battery is made in such a way that it circulates the
electrolyte freely around the plates in addition it also provides a path for sediments to
settle.
(a) at the side of cell (b) at the top of cell
*(c) at the bottom of cell (d) none
Potential difference between two conductors insulated from each other is measured in
a) Ampere b) Coulomb c) Ohm *d) Volt
Transfer of electrical energy from one conductor to another without the aid of electrical
connection is
*a) Induction b) Air gap transfer
c) Not possible d) Possible but will cause excessive arcing thus not
practical
In a 3 phase system, the phase winding is spaced symmetrically so that the voltage induced
is
a) 90o apart *b) 120o apart c) 60o apart d)
180 apart
o
To avoid armature reaction of small DC generator (1000 watt or less) type. The method
used is
a) Interpole Method b) Brush setting method
*c) both (a) & (b) d) None of these
The factor, which determines whether a given transformer is stepped up or steeped down, is
given by
a) *Current ratio
b) Voltage ratio
c) Power ratio
d) Turns ratio
RF transformer utilizes
a) *Iron core
b) Copper core
c) Magnetic core
d) Air core
To get a basic D.C. generator from A.C generator which of the following arrangement is
made
a) *By replacing the slip rings of the A.C generator with commutator
b) By the addition of extra slip rings
c) By connecting a rectifier
d) None of the above
If a constant voltage is desired, which one of the D.C generator we would prefer
a) Series wound D.C generator
b) *Shunt wound D.C generator
c) Both a and b
d) None of these
A generator in which the no load and full load voltages have the same value is called
a) *Flat compound generator
b) Shunt generator
c) Series generator
d) Both b and c
Immediately after picking up of signal by a super het type receiving antenna, the signal
goes to
a) *RF stage
b) Detector stage
c) IF stage
d) AF stage
If the shunt field of a compound generator is connected across both the armature and series
field, then the connection is said to be
a) *Long shunt connection
b) Short shunt connection
c) Parallel connection
d) Both a and b
Clamper is used to
a) Cut any portion of AC cycle
b) *Shift its DC level
c) Change the frequency
d) Adjust the AC level
The output is high only when both input are different. The device is
a) AND gate
b) NAND gate
c) *EXOR gate
d) EXNOR gate
Advantage of modulation is
a) Low frequency signals can be sent over long distance
b) Size of antenna is greatly reduced
c) No interference with other transmitters
d) *All of the above
In frequency modulation
a) The amplitude changes while frequency constant
b) *The frequency changes while amplitude constant
c) Both constant
d) Both vary
If the signal frequency band is between 550 – 1500 KHz., and local oscillator frequency
band [1045 – 1995] KHz then I.F. will be
a) 405 KHz
b) *495 KHz
c) 500 KHz
d) 1000 KHz
In conductor
a) Valence band is empty only
b) Conduction band is full only
c) *Both are overlapped
d) VB, CB never combined
Two resistors (R1, R2) of 30 and 20 ohms respectively, are connected in parallel across a
20V source. The current through R1 branch would be
a) 12A
b) 10A
c) 0.8A
d) *0.66A
Symbol indicate
a) Electrical s/w
b) Chemical s/w
c) *Electrolytic s/w
d) Electro-thermal s/w
The energy of a capacitor having capacitance ‘C’ and voltage ‘V’ is given by
a) *0.5 CV2
b) CV
c) C2V
d) 0.5 C2V
One unit of magnetic flux is given by
a) *Weber
b) Weber per meter square
c) Square root of Weber
d) Hennery
If there are ‘N’ number of cells, each having voltage E and internal resistance ‘r’ are
connected in series, then the resulting e.m.f of the circuit is given by
a) *NE volt
b) E/N volt
c) E volt
d) NEr volt
The phase difference between voltage and current in a purely resistive circuit is given by
a) *0o
b) 90o
c) 45o
d) 135o
If ‘Im’ is the maximum current for sine AC then its R.M.S value is given by
a) *0.707 Im
b) Im
c) 0.5 Im
d) 1.414 Im
The relationship between voltage and current in a purely inductive circuit is given by
a) Voltage leads the current by 90o
b) Current lags the voltage by 90o
c) *Both a and b
d) None of these
For aircraft generation plant inductor is 1H. The value of capacitor should be
a) *1 / (800 π)2 farad
b) (800 π) farads
c) (400 π) farads
d) √800 π farads
Two resistances of 15, 12 ohms each are connected in parallel across a supply, giving 27
ampere., then current through 15 ohm will be
a) 27 amp
b) *12 amp
c) 15 amp
d) 1 amp