Documente Academic
Documente Profesional
Documente Cultură
engine approximately
a. 10 feet b. 15 feet *c. 25 feet d. 35 feet
Which of the following is the most satisfactory extinguishing agent for use on a carburetor
or intake fire?
a. Dry chemical b. A fine water mist *c. Carbon dioxide
d. Form
When approaching the rear of an idling turbo jet engine the hazard area extends aft of the
engine approximately
a. 200 feet *b. 100 feet c. 50 feet d. 25 feet
The main difference between grades 100 and 100LL fuel are
a. Volatility and lead content b. Volatility, lead content and colour
*c. Lead content and colour d. All of these
Tail-wheel type aeroplanes have the greatest tendency to move side-ways during taxing
when there is
*a) Cross wind b) Tail wind c) Head wind d) None of
these
When parking a aircraft after towing, the nose wheel should be left
*a) Pointed straight ahead b) As it was when towing stopped
c) Unlocked d) All are correct
In open centre system, the number of services can be operated at one time is
*a) One only b) Two only c) Any number d) All of these
In closed system where fixed volume pump is fitted, the system is fitted with
a) Automatic cut out value to divert pump output to reservoir
b) To maintain the normal built up pressure
*c) Both a) & b)
d) None of these
Packing is made of
a) Asbestos b) Cork *c) Synthetic or natural rubber d) Felt
Roots type blower pressurized and send air to cabin duct by taking
*a) Ram air b) Air from exhaust c) Bleed air d)None of these
In open centre system, the number of services can be operated at one time is
*a) One only b) Two only c) Any number d) All of these
When no services are operated in open centre system, the pressure value in the system is
a) At low value b) At high value
*c) Pump output passes directly to the reservoir d) Both a) & c)
In closed system where fixed volume pump is fitted, the system is fitted with
a) Automatic cut out value to divert pump output to reservoir
b) To maintain the normal built up pressure
*c) Both a) & b) d) None of these
To maintain a free flow of ventilation air within the aircraft when parked the component is
filled to
a) Safety value *b) Ground automatic relief value c) outflow value d)
Both a) & c)
Roots type blower pressurised and send air to cabin duct by taking
*a) Ram air b) Air from exhaust c) Bleed air d) None of these
Engine driven cabin compressor which is used on turbo prop aircraft, its output pressure is
controlled
*a) Automatically b) Manually c) Not controlled d) Both a) &
b)
When taxying an aircraft, an alternating red and green light from the control tower means
(a) Move clear of the runway/taxy way immediately
*(b) OK to proceed but used extreme caution
(c) Return to starting point
(d) Stop where are
If air intake fire occurs before the engine picks up an ideal ground fire extinguishes used is
(a) methyl bronze *(b) CO2 (c) BCF (d) both (b) &
(c)
Tail-wheel type aero planes have the greatest tendency to move side-ways during taxing
when there is
* a) Cross wind
b) Tail wind
c) Head wind
d) None of these
When parking a aircraft after towing, the nose wheel should be left
* a) Pointed straight ahead
b) As it was when towing stopped
c) Unlocked
d) All are correct