Documente Academic
Documente Profesional
Documente Cultură
html
Generated by Foxit PDF Creator © Foxit Software
http://www.foxitsoftware.com For evaluation only.
CHAPTER 6
MOTOR DYNAMICS
In the most basic form, two current carrying circuits can experience mutual
forces. A current carrying conductor in a magnetic field experiences a field
too. Torque (T) is determined from force (F) with the following relationship:
where r is the length of arm or distance from the center of action of the
force.
where B is the flux-density, l is the wire length and I is the current flowing
in that wire. Refer to Section 4.1 for further discussion.
where h is the distance between conductor and surface. The force will be zero
if that conductor is halfway between two iron surfaces, (Reference 10 & 17).
where l is the width of the slot and d, the distance to the bottom of the slot,
as shown in Figure 6.2.
The forces on the sides of a deep parallel-sided slot and on the sides of an
air-gap can be determined using Maxwell stresses, as shown below.
Along DA and D'A' in Figure 6.3, the force of attraction per unit area towards
surface FF' is:
Where and are the values of the magnetic field at those surfaces. The
resultant of these 2 forces is:
which when integrated along the whole surface simply results in:
This simplified analysis shows that the force is actually developed on the
sides of the slot rather than directly on the conductor. This explains the
paradox that the conductor being in the slot can only see a very small amount
of flux to explain the forces (and torque) generated by motors, (Reference 10).
A current carrying coil can be broken into a number of small loops of square
areas. Each loop is rotated until its plane is parallel to the total field and
no flux is linked. The potential energy of a current carrying circuit in a
magnetic field can then be determined from the work required to reassemble the
original circuit.
If a current loop is moved, the flux linked with it is reduced by d and the
potential energy is increased by Id . The emf E is, therefore:
The energy drawn from the power source is then reduced by EI t. To maintain the
current from the source at a constant value, extra energy must be supplied in
time t. Integrating the increments of current over the whole time interval
results in:
This indicates that half the energy withdrawn from the source is used for
mechanical work and half is stored in the field.
The general equation for torque balance at the motor shaft is (Reference 20)
The stability or instability of the operating points depends on the motor and
load speed torque characteristics. Figure 6.4 shows an example of a brushless
dc motor and a fan load.
From Equation 6.14 and from the acceleration/deceleration curves, the torque
versus current (or excitation) of the motor can be determined, (Reference 17).
and A can be determined at any value of speed S after determining the rate of
deceleration S/ t from the test.
Torque can be developed as a mutual reaction between two fields under one or
more of the following conditions, (Reference 21):
1. The speed of rotation of the 2 fields must be the same since the summation
of the reaction over any whole number of relative revolutions is zero.
b. The angle between the 2 field vectors must be more than zero.
c. The two fields must change sign simultaneously if they are alternating
fields.
d. At least one field must exist independently. The other can also be
independent, e.g. a permanent magnet, or dependent, e.g. the rotor field
in an induction motor.