Documente Academic
Documente Profesional
Documente Cultură
B 1 RUMAH TERES 1 TINGKAT (28 UNIT - JENIS 'A' CORNER & 28 Unit
SUM
SUM/ME/37
SECTION A
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
A PRELIMINARY
To supply and provide the following:
A.3 To provide safety signage and warning sign to the public and ls 1
workers as per Safety and Health Department regulation and
CIDB requirement.
A.4 Carry out site clearing within the limit of works in accordance ls 1
with the specification and as Engineer's Instruction
TO COLLECTION RM
PRELIM/2 Preliminary
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.5 Liasing with TNB, TM and other relevant authorities for testing, 1 ls
commisioning inclusive of obtaining their approvals before
commencement of releted works, arrangement for their
supervision at site, and arrangement for their acceptance test.
A.6 Any other works are not mentioned above but necessary for
the complete installation as per drawing:
a)
b)
c)
To Collection RM
PRELIM/3 Preliminary
SECTION A
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
COLLECTION
1. PAGE 1 1 Unit
2. PAGE 2 1 Unit
PRELIM/4 Preliminary
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
RUMAH TERES 1 TINGKAT (28 UNIT - JENIS 'A' CORNER & END TYPE)
LOW VOLTAGE ELECTRICAL INSTALLATION BILL 2
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.1.2 Metering panel c/w cut-off and neutral link and all accessories
a) 63A SPN 1 nos
A.1.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM 0.00
A.2.2 Opening hole through beam/wall with 75mm dia. UPVC pipe for five 1 L.S
foot way TNB cable
A.2.3 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
A.3.1 Lighting point final circuit 2 x 1.5 sq.mm/1C PVC copper cable c/w 13 nos
earth cable in concealed uPVC high impact conduit and Full Plate
type switch .
A.3.2 Fan point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth cable 5 nos
in concealed uPVC high impact conduit, fan hook and Full Plate type
switch.
A.3.3 Door bell point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth 0 nos
cable in concealed uPVC high impact conduit and Full Plate type
switch.
A.3.4 13A SPN (SSO) switch socket outlet using 2 x 2.5 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit.
A.3.5 15A SPN (SSO) switch socket outlet using 2 x 4 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit, 20A neon light switch for air conditioning and water heater.
A.3.6 Fiber wall socket point using fiber cable c/w earth cable in uPVC 1 nos
high impact conduit and jack outlet. Cable end to be enclosed by
end cap.
A.3.7 TV point using RG-6 cable c/w earth cable in uPVC high impact 1 nos
conduit.
A.3.8 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
TO COLLECTION RM 0.00
A.4.2 Bonding and termination system c/w clip, test and junction clamp, 1 ls
bimetallic connector or gas welding.
A.4.3 Plastic earth chamber c/w cover, clamp, earth rod, backfill 1 set
conductive sand and necessary accessories
A.4.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
RUMAH TERES 1 TINGKAT (28 UNIT - JENIS 'A' CORNER & END TYPE) BILL 2
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
COLLECTION
1. PAGE 1 1 unit
2. PAGE 2 1 unit
3. PAGE 3 1 unit
4. PAGE 4 1 unit
A.1.2 Metering panel c/w cut-off and neutral link and all accessories
a) 63A SPN 1 nos
A.1.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
A-Typical
A-T /10
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.2.2 Opening hole through beam/wall with 75mm dia. UPVC pipe for five 1 L.S
foot way TNB cable
A.2.3 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
A-Typical
A-T /11
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.3.1 Lighting point final circuit 2 x 1.5 sq.mm/1C PVC copper cable c/w 12 nos
earth cable in concealed uPVC high impact conduit and Full Plate
type switch.
A.3.2 Fan point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth cable 5 nos
in concealed uPVC high impact conduit, fan hook and Full Plate type
switch.
A.3.3 Door bell point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth 0 nos
cable in concealed uPVC high impact conduit and Full Plate type
switch.
A.3.4 13A SPN (SSO) switch socket outlet using 2 x 2.5 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit.
A.3.5 15A SPN (SSO) switch socket outlet using 2 x 4 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit, 20A neon light switch for air conditioning and water heater.
A.3.6 Fiber wall socket point using fiber cable c/w earth cable in uPVC 1 nos
high impact conduit and jack outlet. Cable end to be enclosed by
end cap.
A.3.7 TV point using RG-6 cable c/w earth cable in uPVC high impact 1 nos
conduit.
A.3.8 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
TO COLLECTION RM
A-Typical
A-T /12
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.4.2 Bonding and termination system c/w clip, test and junction clamp, 1 ls
bimetallic connector or gas welding.
A.4.3 Plastic earth chamber c/w cover, clamp, earth rod, backfill 1 set
conductive sand and necessary accessories
A.4.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
A-Typical
A-T /13
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
COLLECTION
1. PAGE 1 1 unit
2. PAGE 2 1 unit
3. PAGE 3 1 unit
4. PAGE 4 1 unit
A-Typical
A-T /14
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
A.1.2 Metering panel c/w cut-off and neutral link and all accessories
a) 63A SPN 1 nos
A.1.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
B-Typical
B-T /15
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.2.2 Opening hole through beam/wall with 75mm dia. UPVC pipe for five 1 L.S
foot way TNB cable
A.2.3 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
B-Typical
B-T /16
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.3.1 Lighting point final circuit 2 x 1.5 sq.mm/1C PVC copper cable c/w 12 nos
earth cable in concealed uPVC high impact conduit and Full Plate
type switch.
A.3.2 Fan point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth cable 5 nos
in concealed uPVC high impact conduit, fan hook and Full Plate type
switch.
A.3.3 Door bell point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth 0 nos
cable in concealed uPVC high impact conduit and Full Plate type
switch.
A.3.4 13A SPN (SSO) switch socket outlet using 2 x 2.5 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit.
A.3.5 15A SPN (SSO) switch socket outlet using 2 x 4 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit, 20A neon light switch for air conditioning and water heater.
A.3.6 Fiber wall socket point using fiber cable c/w earth cable in uPVC 1 nos
high impact conduit and jack outlet. Cable end to be enclosed by
end cap.
A.3.7 TV point using RG-6 cable c/w earth cable in uPVC high impact 1 nos
conduit.
A.3.8 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
TO COLLECTION RM
B-Typical
B-T /17
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.4.2 Bonding and termination system c/w clip, test and junction clamp, 1 ls
bimetallic connector or gas welding.
A.4.3 Plastic earth chamber c/w cover, clamp, earth rod, backfill 1 set
conductive sand and necessary accessories
A.4.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
B-Typical
B-T /18
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
COLLECTION
1. PAGE 1 1 unit
2. PAGE 2 1 unit
3. PAGE 3 1 unit
4. PAGE 4 1 unit
B-Typical
B-T /19
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
A.1.2 Metering panel c/w cut-off and neutral link and all accessories
a) 63A SPN 1 nos
A.1.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
C-Corner
C-C /20
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.2.2 Opening hole through beam/wall with 75mm dia. UPVC pipe for five 1 L.S
foot way TNB cable
A.2.3 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
C-Corner
C-C /21
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.3.1 Lighting point final circuit 2 x 1.5 sq.mm/1C PVC copper cable c/w 14 nos
earth cable in concealed uPVC high impact conduit and Full Plate
type switch.
A.3.2 Fan point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth cable 5 nos
in concealed uPVC high impact conduit, fan hook and Full Plate type
switch.
A.3.3 Door bell point using 2 x 1.5 sq.mm/1C PVC copper cable c/w earth 0 nos
cable in concealed uPVC high impact conduit and Full Plate type
switch.
A.3.4 13A SPN (SSO) switch socket outlet using 2 x 2.5 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit.
A.3.5 15A SPN (SSO) switch socket outlet using 2 x 4 sq.mm/1C PVC
copper cable c/w earth cable in concealed uPVC high impact
conduit, 20A neon light switch for air conditioning and water heater.
A.3.6 Fiber wall socket point using fiber cable c/w earth cable in uPVC 1 nos
high impact conduit and jack outlet. Cable end to be enclosed by
end cap.
A.3.7 TV point using RG-6 cable c/w earth cable in uPVC high impact 1 nos
conduit.
A.3.8 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
TO COLLECTION RM
C-Corner
C-C /22
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
A.4.2 Bonding and termination system c/w clip, test and junction clamp, 1 ls
bimetallic connector or gas welding.
A.4.3 Plastic earth chamber c/w cover, clamp, earth rod, backfill 1 set
conductive sand and necessary accessories
A.4.4 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM
C-Corner
C-C /23
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
COLLECTION
1. PAGE 1 1 unit
2. PAGE 2 1 unit
3. PAGE 3 1 unit
4. PAGE 4 1 unit
C-Corner
C-C /24
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
A.1.3 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TNB Substation
SS/25
TO COLLECTION RM
TNB Substation
SS/26
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
a) DB.TNB 10 m
A.2.2 8-ways 150mm dia. G.I ducts for cable entry for road crossing,
drain, hard standing ground and etc for underground cable
inclusive of excavation work and backfilling (located at TNB sub
station) and extended beyond drain.
50 m
A.2.3 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
C.1 Lighting point final circuit 2 x 1.5 sq.mm/1C PVC copper cable
c/w earth cable in concealed/surfaced G.I conduit with C.P.C and
switch.
15 nos
C.2 13A SPN (SSO) switch socket outlet final circuit 2 x 2.5
sq.mm/1C PVC copper cable c/w earth cable in
concealed/surfaced G.I conduit with C.P.C
C.3 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TNB Substation
SS/27
TO COLLECTION RM
TNB Substation
SS/28
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
D FITTINGS
D.4 Identification
a) Dilarang masuk/No Entry 4 pcs
b) Awas Bahaya/Danger 4 pcs
c) Security plate as per drawing 1 pcs
d) Tagging of DB (incoming and outgoing) 1 ls
e) Demarcation 1 ls
f) CPR Chart 3 pcs
D.6 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TNB Substation
SS/29
TO COLLECTION RM
TNB Substation
SS/30
ITEM DESCRIPTION QTY UNIT RATE AMOUNT
(RM) (RM)
E.2 Bonding and termination system c/w clip, test and junction clamp,
bimetallic connector or gas welding.
1 ls
E.3 Heavy duty concrete earth chamber c/w cover, clamp, earth rod,
backfill conductive aggregate and necessary accessories
4 set
E.5 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TNB Substation
SS/31
TO COLLECTION RM
TNB Substation
SS/32
SECTION B
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
COLLECTION
1. PAGE 1 1 unit
2. PAGE 2 1 unit
3. PAGE 3 1 unit
4. PAGE 4 1 unit
TNB Substation
SS/33
SECTION C
A.1 To supply and install street lantern fitting c/w steel arm
bracket, clamp, wiring, termination jumping cable (if
required) and accessories to be mounted to TNB
concrete pole as per drawing and TNB specification
A.5 Any other works are not mentioned above but necessary
for the complete installation as per drawing:
a)
b)
c)
SL/34 Street.Lighting
SECTION C
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
INFRASTRUCTURE SERVICES
A EQUIPMENTS
To supply, deliver, install and test the following:
TO COLLECTION RM
Telephone.Infra
ET/35 434034299.xlsx
ITEM DESCRIPTION QTY UNIT RATE (RM) AMOUNT (RM)
A.8 Any other works are not mentioned above but necessary for the
complete installation as per drawing:
a)
b)
c)
TO COLLECTION RM 0.00
Telephone.Infra
ET/36 434034299.xlsx
SECTION C
CADANGAN MEMBINA DAN MENYIAPKAN SKIM PERUMAHAN TERDIRI DARIPADA :-
FASA 2 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 1- 80
FASA 3 : 80 UNIT RUMAH TERES 1 TINGKAT UNIT 81- 160
DI ATAS SEBAHAGIAN LOT 8019, (LOT LAMA PT 841) JALAN ILMU, MUKIM 9, NIBONG TEBAL, SEBERANG
PERAI SELATAN UNTUK TETUAN J.K.P. SDN. BHD.
Telephone.Infra
ET/37 434034299.xlsx