Documente Academic
Documente Profesional
Documente Cultură
1. The three beams in a color CRT are associated with the colors
a) Red, yellow and blue
b) Red, green and blue
c) Green, blue and yellow.
Page 1 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
a) Top to bottom.
b) Left to right.
c) Both (a) & (b) are correct.
Page 2 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
c) Transient.
15. EPROM
a) Can only be programmed by manufacturers.
b) By user.
c) Both (a) & (b) are correct.
19. Which one of the following gives the length of an ARINC 429 data
word:
a) 16 bits
b) 32 bits
c) 64 bits
20. In a binary counter, the clock input of each bistable stage is fed
from:
a) The same clock line
b) The Q output of the previous stage
c) The CLEAR line.
21. Adjacent phosphors of blue and green are illuminated on the screen
of a CRT. The resultant colour produced will be:
a) Cyan
b) White
Page 3 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
c) Magenta.
33. When compared with an LCD, a CRT display offers the advantage
that:
a) The resolution and focus are better
b) It can be viewed over a large angle
c) It uses low voltages and is more energy efficient.
40. When landing gear fully down and locked then light will glow
a) Blue.
b) Red.
c) Green.
Page 6 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
46. Fibre optic cable over copper cable has the following advantages
a) Non-conductive, easier to manufacture and assemble, greater
bandwidth
b) Non-conductive, greater bandwidth, greater signal security
c) Greater bandwidth, greater signal security, more robust
47. To deflect the beam of a CRT horizontally, coils are placed on the
neck of the tube
a) One on the side, one at the bottom
b) Each side
c) Top and bottom
Page 7 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
48. The light source used in fibre optics is
a) Higher bandwidth than visible light
b) Lower bandwidth than visible light
c) Visible light
a) Bi-directional
b) One way data buses
c) Simplex
52. When an electrically operated landing gear is fully retracted, the up-
lock switch contacts:
a) Open, thereby removing power from the motor
b) Close, thereby removing power from the motor
c) Open, thereby applying power to the motor.
60. Which one of the following gives the length of an ARINC 429 data
word:
a) 16 bits
b) 32 bits
c) 64 bits.
66. If lightning strike pass from the structure the changes damage are
mostly at
a) At all points.
b) At the points of lightning strike.
c) At the point of existing the strike from aircraft to atmosphere.
d) No change.
71. EMI
a) Desensitize receiver antenna operation
b) Random lines in the display unit
c) Erroneous indicator reading.
d) All of the above.
72. RAM
a) Data can be retrieved from all the location.
b) Few data can be retrieved from selected location.
c) None of the above.
Page 12 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
b) A silica glass core with a cladding having a higher refractive
index.
c) A plastic core with a cladding having a higher refractive index.
86. Some of the advantages of fibre optic cable over copper cable are
a) Smaller size and weight, nonconductive, more rugged, higher
security.
b) Nonconductive, easy to manufacture and assemble higher
bandwidth.
c) Nonconductive, higher bandwidth, higher security, smaller
size and weight.
90. Two connected fibre optic cable ends are parallel but not quite
touching. This is called
a) End to end coupling.
Page 13 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
b) Lens connector.
c) End fire coupling.
91. Which of the following ESDS devices can withstand higher static
electricity voltage
a) MOSFET.
b) SCR.
c) ECL.
Page 14 of 15
MODULE-5 (Cat.B1.1) DGCA NOVEMBER -2018 QUESTION PAPER
Page 15 of 15