Documente Academic
Documente Profesional
Documente Cultură
com
Regulations-2008
Sixth Semester
1. (i) Write the Assembly Language Program to perform 16 bit addition in 8085 Microprocessor.
(50)
(ii) Design an integrator circuit using op-amp IC 741. Assume the input waveform to be sine
waveform and square waveform (50)
2. (i) Write the Assembly Language Program to perform 16 bit addition without using DAD in
8085 Microprocessor. (50)
(ii) Design a gray to binary code converter using suitable logic gates and verify their function.
(50)
3. (i) Write the Assembly Language Program to perform 8 bit multiplication in 8085
Microprocessor. (50)
(ii) Design & construct Full subtractor by using suitable logic gates & verify its truth
table. (50)
4. (i) Write the Assembly Language Program to perform 8 bit division in 8085 Microprocessor.
(50)
(ii) Write a 8085 ALP to convert an analog signal in the range of 0V to 5V to its corresponding
digital value. (50)
www.Vidyarthiplus.com
www.Vidyarthiplus.com
5. (i) Write the Assembly Language Program to find the smallest number in an array using 8085.
(50)
(ii) Generate pulse wave with Ton/Toff is equal to 1, by interfacing DAC interfacing kit with
8051 microcontroller kit. (50)
6. (i) Write the Assembly Language Program to find the largest number in an array using 8085.
(50)
(ii) Design & construct Full adder by using suitable logic gates & verify its truth table. (50)
7. (i) Write the Assembly Language Program to arrange the numbers in an array in ascending
order using 8085. (50)
(ii) Design a circuit and study the operation of 741 op-amp as comparator.
8. Write the Assembly Language Program to perform the basic arithmetic operations in 8051.
(100)
9. Construct a circuit Operate the IC555 timer in Monostable mode to generate a 1KHz square
waveform. (100)
10. (i) Write the Assembly Language Program to perform 8 bit subtraction in 8085
Microprocessor. (50)
(ii) Write an ALP using 8051 mnemonics to make the stepper motor to rotate with a specific
delay by continuously energizing the coils. (50)
www.Vidyarthiplus.com
www.Vidyarthiplus.com
11. (i) Write the Assembly Language Program to perform code conversions from BCD to Hex
using 8085. (50)
(ii) Interface 8279 with 8085 and write an ALP to display the message “AUC”. (50)
12. (i) Design & construct NE 565 PLL & to use it as frequency multiplier. (50)
(ii) Write the Assembly Language program to find the sum of numbers in an array using
8051. (50)
13. Write and execute an assembly language program to generate a triangular wave with a pulse
of 25 ms using 8085 microprocessor through 8253 in Mode 0. (100)
14. Write an assembly language program to simulate the traffic lights at an intersection using a
traffic light interface. (100)
15. (i) Design & construct Schmitt trigger using Operational Amplifier IC (50)
(ii) Write the Assembly Language Program to perform code conversions from BCD to ASCII
using 8085. (50)
16. Design & construct a 4 bit Parallel in serial out and serial in serial out shift register. (100)
www.Vidyarthiplus.com
www.Vidyarthiplus.com
18. (i) Design and implement 2x4 decoder using suitable logic gates and verify its truth
table. (50)
(ii) Write the Assembly Language Program to find the product of two 8 bit numbers using
8051. (50)
(ii) Design and implement 4x2 encoder using suitable logic gates and verify its truth
table. (50)
20. (i) Write an ALP to find if a given number is odd or even. (50)
(ii) Generate pulse wave with Ton/Toff is greater than 1, by interfacing DAC interfacing kit
with 8085 microprocessor kit. (50)
MARK ALLOCATION
Aim/Procedure/Algorithm - 25
Circuit Diagram/Program - 25
Result - 25
Viva Voice - 10
Total - 100
www.Vidyarthiplus.com